2006 Volkswagen Jetta

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT WAS TRAVELING 60 MPH WHEN THE VEHICLE BECAME RESISTANT TO ACCELERATION ATTEMPTS. THE CHECK ENGINE WARNING LIGHT ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 122,000.

RECURRING DSG TRANSMISSION PROBLEMS: FIRST REPORTED TO VW IN JANUARY OF 2006 WITH FAILURE TO DOWNSHIFT AT 22K MILES (NO PROBLEM FOUND/NO CODES).IN 2010 REPORTED LOSS OF POWER AND OR SHIFTING IN AND OUT OF GEAR DURING HIGH AMBIENT TEMPERATURE. IN JUNE OF 2012; FROM PARKING, DELAYED SHIFTING INTO REVERSE OR DRIVE AND THEN VIOLENTLY ENGAGING. ON RETURN FROM ARIZONA, AGAIN HIGH TEMP, FOR APPROXIMATELY 100 -150 MILES WOULD LOSE POWER TO WHEELS AND THEN WOULD RETURN TO NORMAL REPEATEDLY. VW WILL NOT COVER 2006 JETTA UNDER DSG RECALL (I BELIEVE THERE ARE TWO RECALLS). COST OF NEW DSG TRANSMISSION QUOTED AT $7000.00! *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, HE NOTICED THAT THE VEHICLE WOULD NOT SHIFT GEARS. HE PULLED OVER AND WAITED UNTIL THE VEHICLE COOLED DOWN. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THEY WERE NOT SURE WHAT WAS WRONG WITH THE VEHICLE. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE.THE FAILURE MILEAGE WAS 29,000 AND THE CURRENT MILEAGE WAS 94,000. UPDATED 08/23/12*LJ UPDATED 09/24/2012 *JS

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT AND A LIGHT INDICATED THAT THE HEADLIGHTS WERE NOT FUNCTIONING WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER AND THE DEALER STATED THAT SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE NOT AVAILABLE.

2006 JETTA 2.0T WITH A DSG TRANSMISSION HAS A DUAL MASS FLYWHEEL (DMF) WHICH IS FAILING: CHATTERING AT IDLE, WHEN SHIFTING GEARS, AND WHEN SLOWING TO A STOP. SPOKE WITH A FEW DEALERS IN THE AREA TO ASK ABOUT THE REPAIR AND WAS QUOTED $2500 TO REPAIR (THE DMF ONLY!). CONTACTED VOA TO FIND OUT IF THIS ISSUE WAS PART OF A RECALL, BUT NO RECALLS FOR SUCH FAILURES. HOWEVER, I WAS OFFERED $1000 TOWARDS THE PURCHASE OF A NEW VW - THAT WON'T FIX MY PROBLEM. ALL DEALERS I SPOKE WITH HAVE NO RECOLLECTION OF ANY OTHER FAILED DMFS - AT ALL. THROUGH MY OWN RESEARCH, I DISCOVERED THAT AUDI (VW PARTNER COMPANY) ISSUED A RECALL FOR A NUMBER OF 2006 A3 MODELS WITH THE SAME PART NUMBER (SAME PART) TO REPLACE THIS DEFECTIVE DMF PART (R/2006/031). ALSO LEARNED THAT THERE WAS A RECALL ISSUED FOR 1.9TDI MODEL JETTAS IN AUSTRALIA (135C). THERE HAS BEEN NO SUCH RECALL FOR US OWNERS OF VW MODELS WITH THE DSG TRANSMISSION AND THE DMF. WHY NOT? I ALSO OWN A 2010 PASSAT WITH THE SAME ENGINE, TRANSMISSION AND DMF PART. I CAN ONLY EXPECT TO HAVE THE SAME ISSUES WITH THAT CAR LATER ON. IT WOULD BE NICE EVEN TO HAVE VW ACCEPT THE RESPONSIBILITY OF ADDRESSING THE DMF PART MAKER (LUK AND/OR SACHS) FOR A PARTIAL PAYMENT OF THE REPAIRS. AT THIS POINT I HAVE TWO OPTIONS; SELL THE CAR TO AN UNSUSPECTING VICTIM, OR PAY NEARLY 50% OF THE TRADE VALUE OF THE CAR WITH 106,000 MILES ON IT TO HAVE IT FIXED. *TR

ENGINE LOSS OF POWER, BLACK SMOKE FROM EXHAUST AND PINGING NOISE FROM ENGINE VEHICLE STALLED A FEW TIME IN TRAFFIC ALMOST CAUSING AN ACCIDENT WITH OTHER VEHICLES DRIVING VEHICLE TO WORK, STARTED MAKING NOISE AND DECIDED TO DRIVE TO VW DEALERSHIP. DEARLERSHIP FIRST DIAGNOSED THE PROBLEM AS A BAD CLUTCH. UNDER MY RECOMMENDATION CAMSHAFT WAS INSPECTED AND FOUND TO BE DEFECTIVE AS WELL AS THE LIFTERS THAT CONTACT THE CAMSHAFT. DEALER SAYS THIS IS NOT A VW PROBLEM AND WAS SURPRISED TO SEE A PROBLEM WITH THE CAMSHAFT. IF YOU LOOK ON THE INTERNET, MANY TDI VW OWNERS ARE EXPERIENCING THE SAME PROBLEM. THIS PROBLEM IS NOT BEING RECONGIZED BY VW AND IS COSTING OWNERS A LOT OF MONEY IN REPAIRS AS WELL AS CREATING UNSAFE DRIVING CONDITIONS FOR OWNERS OF THIS VEHICLE. *JS

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT A LOUD NOISE EMITTED FROM THE DRIVE TRAIN WHENEVER THE VEHICLE WAS OPERATED. THE NOISE SOUNDED LIKE SOMETHING WAS BANGING UNDER THE HOOD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT EXAMINED THE VEHICLE AND STATED THAT THE FLY WHEEL WITHIN THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 78,000.

CAMSHAFT BEGAN KNOCKING AROUND 100,000 MILES. MANY OTHER '06 JETTA TDI HAVE HAD PREMATURE CAMSHAFT FAILURES AS WELL. KNOCKING INTENSIFIED JUST BEFORE 101,000 MILES. TOOK IT TO MECHANIC WHO WAS VERY FAMILIAR WITH THE ISSUE, AS HE HAS SEEN MORE THAN HIS SHARE. HE SAID THE EARLIEST FAILURE HE HAS SEEN WAS AT AROUND 40,000 MILES. I HAD TO GO TO GREAT EXPENSE TO REPLACE CAM FOLLOWER, CAMSHAFT AND CAM BEARINGS. IT ALSO CAUSED PREMATURE WEAR ON MY LIFTERS, WHICH I EXPECT I'LL HAVE TO DO SOON, AS THEY ARE STARTING TO "TICK". I LOVE MY TDI, AND HAVE MADE SURE ALL SERVICE WAS DONE PROMPTLY. I AM FRUSTRATED THAT VWAG HAS DENIED THERE IS A PROBLEM. IF ENOUGH PEOPLE COMPLAIN, THEN THEY WILL HAVE TO ADMIT THAT POOR ENGINEERING IS THE CAUSE OF THE PREMATURE CAMSHAFT FAILURES THAT ARE PLAGUING PUMPED USE OWNERS. *TR

I WAS IN 2 ACCIDENTS I DON'T REMEMBER THE DATES, BUT ONE WAS IN THE LATTER PART OF 2010 AND ANOTHER WAS IN 2008. IN BOTH ACCIDENTS THE AIR BAGS FAILED TO DEPLOY, THE AIR BAG LIGHT NEVER GOES OFF, EVEN BEFORE THE ACCIDENTS. I HAD THIS LIGHT RESET ABOUT 3 TIMES, THE FIRST TIME WAS THROUGH THE DEALER AND THE OTHERS WHERE THROUGH AUTO MECHANIC SHOP. THE DEALER WANTS TO CHARGE ME $250 TO FIX THE LIGHT PROBLEM, THEY SAY IT HAS SOMETHING TO DO WITH THE SEAT BELT BUCKLE. I REALLY THINK THAT THIS HAS BEEN A SAFETY PROBLEM AND THAT THERE HAVE BEEN MANY COMPLAINTS INREGARD TO THIS MATTER. YET THE DEALER DOES NOT WANT TO ACCEPT RESPONSIBILITY. *TT