2006 Volkswagen Jetta

The contact owns a 2006 Volkswagen Jetta. The contact stated that brake fluid had leaked from her vehicle as the check engine light illuminated the instrument panel. The contact had taken the vehicle to an independent mechanic where she was informed that the brake master cylinder needed to be replaced. Soon after repair, the failure returned. Upon investigation, the contact discovered NHTSA Campaign Number: 20E064000 (Service Brakes, Hydraulic) which she linked to the failure. The dealer was notified of the failure and informed her that there were no recalls on the vehicle. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 110,000.

WHILE TRAVELING IN RAIN AT 70 MPH WITH CRUISE CONTROL ENGAGED THE SPEEDOMETER DROPPED TO ZERO, THE BRAKE AND ABS/ESP WARNING LIGHT CAME ON AND THERE WHERE THREE CHIMES. A SECOND LATER ALL WENT BACK TO NORMAL. THIS HAPPENED 6 TIMES THAT DAY, AND HAS HAPPENED AT IRREGULAR INTERVALS SINCE AT LEAST 7 TIMES. THERE IS NO CORRELATION ANYMORE BETWEEN WET AND DRY CONDITIONS, CRUISE CONTROL DOES NOT HAVE TO BE ENGAGED, I DO NOT HAVE TO BE TRAVELING AT A CONSTANT SPEED. THERE ARE NO TROUBLE CODES STORED IN THE VEHICLES COMPUTER, AND THE LOCAL DEALERSHIP IS UNABLE TO HELP. *TR

I RECENTLY PURCHASED A USED, LOW MILEAGE 2006 VW JETTA AND SOON AFTER I NOTICED THE HEADLINER BEGAN TO BUBBLE, SAG, AND TEAR AWAY FROM THE C-PILLARS I KNEW THAT THIS WAS NOT NORMAL FOR A FOUR-YEAR-OLD CAR AND THAT THIS COULD QUICKLY TURN INTO A SAFETY HAZARD IF LEFT IGNORED. SHOULD THE HEADLINER CONTINUE TO BUBBLE AND SAG INTO THE DRIVER'S LINE OF SIGHT THIS COULD BECOME A SERIOUS MOTOR VEHICLE HAZARD. I BEGAN TO READ AROUND ONLINE AND DISCOVERED, TO MY SHOCK, NEWS ABOUT THE COMMONALITY OF THIS ISSUE TO HUNDREDS OF OWNERS. SO, SURELY VOLKSWAGEN IS ALREADY AWARE THAT THIS IS A MASS ISSUE AND WOULD CERTAINLY WANT TO TAKE ACTION TO CORRECT IT, RIGHT? I AM WRITING BECAUSE I GENUINELY LOVE THIS CAR, BUT FEEL THAT THERE IS A SERIOUS MOTOR VEHICLE DEFECT WITHIN THE HEADLINER ASSEMBLY, GLUE OR THE WAY THE FABRIC LINER WAS CUT, POSSIBLY TOO SHORT. I WANT TO GET MY HEADLINER REPAIRED, BUT HONESTLY DO NOT FEEL THAT I SHOULD BE FULLY RESPONSIBLE FOR LOW QUALITY CRAFTSMANSHIP PUT INTO THE HEADLINER OF A FOUR YEAR OLD VEHICLE. I'D LIKE FOR VOLKSWAGEN TO PETITION TO HAVE THIS ITEM RECALLED CITING THE POTENTIAL SAFE HAZARDS IT CAN CAUSE DUE TO LOSS OF SIGHT WHILE DRIVING. ALSO, I'D LIKE FOR YOU TO CONTACT ME IN ORDER TO MAKE THE PROPER ARRANGEMENTS TO HAVE MINE REPLACED. I AM ALSO SENDING THIS LETTER TO VOLKSWAGEN'S CONSUMER COMPLAINTS DEPARTMENT, CONSUMER AFFAIRS, AND THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION FOR THEIR REVIEW. THE CONSUMER STATED WITHIN ONE WEEK OF OWNING THE VEHICLE, HE NOTICED A VIBRATION IN THE STEERING WHEEL. IT WAS DETERMINED THE ROTORS NEEDED TO BE REPLACED. SOON AFTER, THE RADIO AND WINDOW BUTTONS BEGAN TO PEEL AS IF THEY HAD BEEN SITTING OUT IN HEAT. UPDATED IVOQ 12/22/10*JB *TR THE CONSUMER ALSO STATED THE WIRING IN THE DRIVER'S SIDE DOOR WAS DEFECTIVE. THE EXTERIOR SIDE MIRROR TURN SIGNALS DID NOT FUNCTION PROPERLY. THE WIRING HARNESS INSIDE THE BOOT OF THE DRIVER'S DOOR SHOWED SIGNS OF WEAR. THE CONSUMER STATED 2 OUT OF THE 11 WIRES WERE BROKEN, INCLUDING THE GROUND WIRE. UPDATED 06/

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA TDI. THE CONTACT WAS DRIVING 25 MPH WHEN HE APPLIED THE BRAKES AND THEY DID NOT RESPOND. THE VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY UNTIL AFTER THE CRASH HAD ALREADY OCCURRED. THE CONTACT SUSTAINED ABRASIONS FROM THE AIR BAG DEPLOYMENT. IN ADDITION, THE AIR BAGS FRACTURED THE FRONT WINDSHIELD. A POLICE REPORT WAS AVAILABLE. ALSO, THE AIR BAGS CRACKED THE WINDSHIELD. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 96,000.

DRIVING ON I-95 IN JACKSONVILLE, FL, IT WAS RAINING WITH SOME POUNDING (APPROX. 1 INCH OF WATER) ON THE ROADWAY. I WAS MAINTAINING A SPEED OF 35-45 MPH WHEN THE EPC AND TRACTION CONTROL WARNING LIGHTS ILLUMINATED ON THE DASHBOARD. AT FIRST THE CAR BEHAVED NORMALLY BUT AFTER ABOUT 5 MINUTES IT LOST POWER AND WOULD NOT ACCELERATE ABOVE 1500 RPM. FORTUNATELY I WAS ABLE TO QUICKLY TAKE AN EXIT RAMP OFF THE FREEWAY AND COAST INTO A GAS STATION, THE CAR CONTINUING TO REFUSE TO ACCELERATE. I TURNED THE CAR OFF AND WAITED FOR ABOUT 5 MINUTES. I STARTED UP AGAIN AND DROVE AROUND THE GAS STATION AND THINGS SEEMED NORMAL AGAIN, ALTHOUGH THE EPC LIGHT WAS STILL ILLUMINATED. STOPPED AGAIN AND WAITED ANOTHER 5 MINUTES. UPON STARTING UP AGAIN, BOTH WARNING LIGHTS WERE GONE AND THE CAR BEHAVED AND ACCELERATED NORMALLY. THIS DEFECT COULD HAVE CAUSED ME TO GET STOPPED IN TRAFFIC ON A BUSY FREEWAY POSSIBLY CAUSING A CRASH AND INJURIES. I WAS VERY LUCKY THAT IT HAPPENED WHERE IT DID AND I WAS ABLE TO PULL OFF TO SAFETY. *TR

THIS LETTER IS TO EXPRESS MY DISSATISFACTION WITH REAR BRAKE PERFORMANCE ON MY 2007 JETTA. THE SUMMARY IS EXTREMELY RAPID REAR PAD WEAR, WHILE THEN FRONT, WHICH HAVE THE WEAR SENSOR, REMAIN UNSCATHED. THIS IS A KNOWN ISSUE AND THE DEALER ADMITS ITS PART OF A ?SAFE BRAKING? DESIGN THAT TRIES TO MAKE THE CAR SQUAT RATHER THAN DIVE. THE PROBLEM IS, THIS IS AN UNCONVENTIONAL METHOD OF BRAKE APPLICATION (REAR BIASED WHEN PHYSICS HAS THE FRONTS NORMALLY DOING MORE WORK), COMBINED WITH A CONVENTIONAL BRAKE DESIGN THAT HAS SMALLER PARTS AND NO WEAR SENSORS IN THE REAR. THE RESULT OF THIS ?SAFETY FEATURE? IS THAT I CAN EXPECT TO WEAR OUT REAR PADS FASTER THAN FRONT, IN AS LITTLE AS 9-10K MILES. THE PROBLEM IS A REASONABLY MINDED PERSON WOULD NOT COME TO THIS CONCLUSION, AND THE LACK OF A REAR PAD WEAR WARNING SYSTEM CREATES A POTENTIAL SAFETY ISSUE. THE USER MANUAL DOES NOT WARN THAT REAR PADS MAY WEAR FASTER, AND IN FACT INDICATES THEY SHOULD BE INSPECTED EACH 10 K, OR WHEN THE FRONT WEAR SENSOR ILLUMINATES. BOTH OF THESE CASES MAY BE TOO LATE, LEADING AT BEST TO EXPENSIVE REPAIRS WHEN THE ROTORS ARE DAMAGED, OR WORSE, TO UNPREDICTABLE BRAKING IN AN EMERGENCY. IF I HAVE MY CAR INSPECTED AT 10K, AND THE REARS ARE STILL SERVICEABLE, I DO NOT BELIEVE THEY WOULD MAKE IT TO 20K. THE DEALER ADMITS ITS A COMMON COMPLAINT, AND THAT THERE IS NOTHING THAN CAN BE DONE. I FEEL THIS IS A DESIGN DEFECT AND THAT PRESSURE SHOULD BE APPLIED FOR A REAL FIX. I AM NOT ALONE: HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F16F1F6/11 HTTP://ANSWERS.YAHOO.COM/QUESTION/INDEX?QID=20080205103511AA06FEQ HTTP://RABBITOWNERSCLUB.COM/VW/SHOWTHREAD.PHP/12-000-MILE-AND-MY-11363.HTML HTTP://WWW.MYVWLEMON.COM/UBB/FORUM1/HTML/000342.HTML HTTP://WWW.GOLFMKV.COM/FORUMS/SHOWTHREAD.PHP?P=803924 HTTP://RABBITOWNERSCLUB.COM/VW/SHOWTHREAD.PHP/EXCESSIVE-REAR-BRAKE-DUST-6947.HTML HTTP://WWW.CARCOMPLAINTS.COM/VOLKSWAGEN/JETTA/2005/BRAKES/PREMATURE_REAR_BRAKE_AND_ROTOR_REPLACEMENT.SHTML. *TR

MY 2006 VW JETTA 2.5L REQUIRED A BRAKE AND ROTOR CHANGE AT ONLY 20,000 MILES. THE NEXT BRAKE CHANGE HAD TO BE DONE AGAIN AT 36,000 MILES. I HAVE CHECKED A LOT OF FORUMS AND OTHER JETTA OWNERS ARE COMPLAINING THE SAME. VW DEALERS KEEP ON SAYING THAT THERE IS NOTHING WRONG WITH THE BRAKES AND ITS MY OWN DRIVING STYLE THAT CAUSES THIS. *TR

TOTAL BRAKE FAILURE. VEHICLE HAS ISSUE DRAINING BATTERIES--2006 CAR--CURRENTLY ON 3RD BATTERY. WHEN BATTERY IS CLOSE TO FAILURE, VEHICLE HAS STRANGE ELECTRICAL PROBLEMS SUCH AS TRUNK RELEASING AND BRAKES NOT WORKING. LAST INCIDENT WAS COMING TO A STOP SIGN. WHEN THE BRAKE PETAL WAS PUSHED, NO RESPONSE. LUCKILY THERE WAS NO CAR WAS IN FRONT OF ME AND I WENT THROUGH THE STOP SIGN. INCIDENTS HAVE BEEN REPORTED TO TWO VW DEALERSHIPS AND TO REGIONAL REP. THEY DO NOT FEEL THERE IS A PROBLEM. *TR