2006 Volkswagen Jetta

BOUGHT NEW VW JETTA SEDAN ON 08/17/06. ON 05/13/10 TOOK THE CAR TO THE DEALER BECAUSE OF CAR DECELERATING WHILE DRIVING I.E. DROPPING IN SECONDS FROM 60 MILES TO 20 MILES. IT WAS TAKEN TO THE DEALER MULTIPLE TIMES FOR THE SAME PROBLEM. DEALER ANSWER "UNABLE TO REPLICATE PROBLEM" UNTIL WARRANTY OF FOUR YEARS EXPIRED. THE PROBLEM CONTINUES EVEN AFTER THE CARBON ACCUMULATED ON THE THROTTLE WAS CLEANED AND THE FUEL PUMP WAS REPLACED. DUE TO UNSAFE TO DRIVE, REQUESTED FOR THE DEALER TO BUY THE CAR BACK AS A LEMON. THE DEALER REFUSES BECAUSE THE FOUR YR WARRANTY IS OVER. OTHER PROBLEMS EXPERIENCED WITH THIS VEHICLE DURING THIS PERIOD: AIR BAGS LIGHTS GOING OFF, AIR BAG COVER FALLING OFF, TRUNK OPENING ON ITS OWN WHILE DRIVING, RAIN WATER LEAKING INSIDE THE LINING OF THE CAR, SCREWS COMING OFF A DOOR PANEL, DOORS FALLING OFF THE HINGES, EMERGENCY SWITCH FALLING INSIDE PANEL, FUEL CAP NOT LOCKING, RECALLS. DEALER RECOMMENDING TO REPLACE THE STEERING WHEEL COLUMN FOR 2,340.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE, THERE WAS A LOUD RATTLING NOISE COMING FROM THE HOOD AREA. THE CONTACT RESEARCHED AND FOUND THAT THE DUAL MASS FLY WHEEL COULD POSSIBLY BE DEFECTIVE. THE DEALER WAS MADE AWARE OF THE DEFECT, BUT DID NOT DIAGNOSE THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 91,000 AND THE CURRENT MILEAGE WAS 94,000.

ORIGINALLY PURCHASED IN 2007. COMPLAINED ABOUT THE CAR - WHEN SHIFTING IT WOULD EXCEL AND JERK AFTER SHIFTING. THEN AS TIME WENT ON I WOULD BE DRIVING AND THE JETTA WOULD HESITATE AS IF A FUEL WAS NOT GETTING TO THE ENGINE. I TOOK MY CAR IN FOR REGULAR OIL CHANGES AND REGULAR MAINTENANCE. I LIVE IN A RURAL AREA AND DRIVE JUST HIGHWAY MILES AND HAVE APPROX. 121,000 MILES ON IT. I PURCHASED THIS VW AS I ANTICIPATED IT TO LAST A LOT LONGER THAN A REGULAR VEHICLE. WHEN I TOOK IT IN FOR THE LAST OIL CHANGE AND THE INTERMITTENT HESITATION WAS REALLY BAD I WAS TOLD IT WOULD COST ME ANYWHERE FROM $7500 TO $8000 TO FIX. AND I STILL OWED $9000! I ASKED IF IT WAS COVERED UNDER THE WARRANTY. OF COURSE THE WARRANTY EXPIRED IN JULY...BUT NOTHING WAS FOUND ALL THE PREVIOUS TIMES I HAD BROUGHT MY CAR IN FOR SERVICE. AND VW'S REGIONAL REP AND HQ WAS CONTACTED AND BOTH WERE APOLOGETIC THAT VW COULD DO NOTHING ABOUT FIXING MY CAR. LOOKING AT THE INTERNET - I FOUND THAT NATIONWIDE AND UP TO CANADA OTHER INDIVIDUALS WITH LESS MILEAGE HAVE HAD THE SAME ISSUE AND INDIVIDUALS WERE SEEKING ARBITRATION AGAINST VW. I UNDERSTAND VW DOES NOT HAVE A RECALL OR ANYTHING CONSIDERING THIS IS A RECURRING PROBLEM. ALL THEY CAN OFFER IS $1000 TO BUY ANOTHER VW!!! THEIR NERVE! TOTALLY DISHEARTEN WITH VW. *TR

THE ENGINE IN OUR 2006 TDI DSG BEGAN TO EXHIBIT ROUGH IDLING. AT A CERTAIN POINT IT BECAME EVIDENT SOMETHING WAS WRONG. THE VEHICLE HAS ALWAYS BEEN SERVICED BY A VW DEALERSHIP AT THE SPECIFIED INTERVALS (I CALL THEM THE $400 OIL CHANGES). I COULD HEAR WHAT SOUNDED LIKE AN INTAKE VALVE POPPING AND COULD FEEL A PULSATION IN THE TURBO INTAKE HOSE. I CHECKED ON SOME OF THE FORUMS AND WAS SHOCKED TO LEARN OF THE EARLY CAMSHAFT FAILURE PROBLEM COMMON TO THE PD ENGINES. IT SEEMS THAT VW NARROWED UP THE INTAKE AND EXHAUST CAM LOBES BY ABOUT 30% TO MAKE ROOM FOR THE INJECTOR LOBE, AND TRIED TO COMPENSATE FOR THIS INADEQUATE DESIGN BY MANDATING "SPECIAL" OIL (WHICH I CAN ONLY HOPE OUR DEALER USED EACH TIME THE OIL WAS CHANGED). IT TURNS OUT THOUGH, THAT A CRITICAL CAN WEAR ADDITIVE IN THIS OIL, ZDDP, IN SUFFICIENT QUANTITIES CAN CAUSE EARLY FAILURE OF THE CATALYTIC CONVERTER (AN ITEM WHICH HAS A LONGER WARRANTY PERIOD THAN THE ENGINE). IT SEEMS THAT THE ZDDP ONLY EXISTS IN SUFFICIENT QUANTITY IN VW "SPECIAL" OIL TO GET THROUGH THE ENGINE WARRANTY PERIOD, WHILE AT THE SAME TIME PROTECTING THE CONVERTER FROM WARRANTY FAILURE. I BOUGHT AN AFTER MARKET CAM KIT AND INSTALLED IT MYSELF, SAVING NEARLY $3000 IN THE PROCESS. SINCE THEN WE'VE PUT ANOTHER 60K MILES, USING MOBIL TD TRUCK 5W40 OIL... SO FAR SO GOOD. I THINK THIS WHOLE SITUATION IS DISGRACEFUL AT BEST AND VW SHOULD BE RESPONSIBLE FOR ALL PD CAMSHAFT FAILURES TO A PERIOD SIGNIFICANTLY LONGER THAN THE 80,000 KM WARRANTY. THE PRIMARY REASON WE PAID 32K FOR A COMPACT SEDAN WAS THE REPUTED LONGEVITY OF THE DIESEL ENGINE. THIS FAILURE, ALONG WITH THE DUAL MASS FLYWHEEL FIASCO HAS MADE OUR PURCHASE OF THIS SILVER COLORED LEMON ANYTHING BUT A GOOD INVESTMENT. UNTIL VW FACES UP TO THEIR MORAL RESPONSIBILITIES IN THIS MATTER I WOULD CAUTION ANYONE CONSIDERING THIS MAKE OF VEHICLE. *KB

I TOOK MY 2006 VW JETTA TDI, 5 SP, 40K MILES TO THE VW DEALERSHIP FOR ITS 40K SERVICE ON 5/27/11. AFTER THE SERVICE WAS COMPLETED, I STARTED THE CAR AND NOTICED IT WAS RUNNING VERY ROUGH (THE CAR WASN'T RUNNING ROUGH WHEN I DROPPED IT OFF FOR SERVICE). MY SERVICE REP TOOK THE CAR BACK TO THE SERVICE TECHNICIAN WHO CHECKED ALL THE FILTERS AND RE-BLED THE FUEL FILTER TO REMOVE ANY AIR BUBBLES THAT MAY HAVE BEEN TRAPPED, WHICH DID NOT FIX THE ISSUE. THE SERVICE TECHNICIAN TOOK THE COVER OFF THE ENGINE AND IDENTIFIED THE THAT THE CAMSHAFT IS WEARING. MAINTENANCE ON THIS CAR IS COMPLETED EVERY 5K MILES AND SERVICED BY THE DEALERSHIP IT WAS PURCHASED FROM.

VW HAS CHANGED THE DIESEL ENGINES (TDI) STARTING WITH APPROXIMATE YEAR 2004 UNTIL 2007, WHEN THEY STOPPED SELLING TDI TO MEET EMISSION REQUIREMENTS. TO SAVE MONEY AND LICENSING FEES TO BOSCH THEY HAVE CHANGED FROM COMMON RAIL SYSTEM MADE BY BOSCH (FEEDS THE DIESEL FUEL TO ENGINE WITH VERY HIGH PRESSURE) TO VW SYSTEM CALLED TDI PD: PUMP DUSE (OR PUMP-NOZZLE INJECTION). TO ACCOMMODATE THE INJECTORS INSIDE THE ENGINE, THEY HAVE CHANGED THE SPECS AND DIMENSIONS OF MANY PARTS, INCLUDING THE CAMSHAFT. THE CAMSHAFT INSIDE THIS ENGINE HAS THE ADDED ROLE TO DRIVE THE PD LIFTERS, APART FROM VALVE LIFTING AND CLOSING. I OWN THIS TYPE OF CAR VW JETTA 2006 TDI, AND THE CAMSHAFT WORE OFF AT 80,000 MILES, AND YES IT WAS OUT OF WARRANTY AND IT COSTS $3000. APART FROM THE COSTS, WHICH ACCRUES TO APROX $3000 PER 50,000 TO 80,000 MILES RENDERING THIS CAR A LIABILITY COST TO THE OWNERS (A LONG TERM OWNER WILL HAVE THE PRICE OF CAR DOUBLED BY ADDED BILLS TO CHANGE THE CAMSHAFTS MANY TIMES. THIS IMPACTS DRASTICALLY FINANCIALLY MANY FAMILIES DEPENDING ON THIS CAR), WITHOUT THE POSSIBILITY TO FIX IT PERMANENTLY AND FOR ONCE . I HAVE CHANGED THE CAMSHAFT AND NOW AT 115000 MILES IT STARTS TO SHOWS SIGNS OF WEAR, LIKE LAST TIME. NOT CHANGING GEARS IN TIME, CAR IS SHAKING. THE EFFECT GETS WORSE, UNTIL WHEN THE CAMSHAFT LOBES WEARS OFF MORE, AND RESULTS IN VALVES NOT OPENING AND CLOSING IN RIGHT SEQUENCE AND TIME, AND ENGINE WILL STALL, LIKE MINE DID ON MY STREET. AS WELL I WAS ON HIGHWAY AND CAR WILL NOT OPERATE AND RESPOND TO ACCELERATION PEDAL INPUT, MAXIMUM PEDAL INPUT WAS GIVING ONLY 40MPH, EXPOSING ME TO A STAMPEDE OF CARS FROM BEHIND IN A DANGEROUS SITUATION UNABLE TO CONTROL THE CAR. I HAVE EXPLAINED THE SITUATION TO VW AND THEY DENY ANY: WRONGDOING, DESIGN FLAW, FAULT OR LIABILITY. ACCORDING TO TDICLUB.COM THERE IS UP TO 20% FAILURE OF THE ENGINES VIA CAMSHAFT WEAR OF LOBES. I TRUST YOU WILL INVESTIGATE AND REQUEST VW TO ADDRESS:SAFETY+FINANCIAL IMPACT TO TDI PD OWNERS. *TR

VERY STRONG EXHAUST/FOUL SMELL INSIDE VW JETTA CAR UPON RAPID ACCELERATION THIS SMELL OCCURS VERY OFTEN (SEVERAL TIMES A DAY) WHEN THE CAR ACCELERATES RAPIDLY (FOR EXAMPLE, WHEN PASSING ANOTHER CAR ETC.) WE'VE BEING TRYING TO RESOLVE THIS ISSUE FOR A LONG TIME: CHANGED FILTER, VW SAID IT WAS THE CATALYTIC CONVERTER AND CHANGED IT, BUT THE SMELL CAME BACK. THIS STRONG SMELL IS CAUSING MY KIDS TO COUGH AND IS UNBEARABLE. VW IS NOW REFUSING TO DO ANYTHING FURTHER AND EVERY TIME I ASK THE LOCAL DEALER TO DIAGNOSE IT, THEY CHARGE ME A LARGE FEE AND DO NOT SOLVE THIS ISSUE. *TR