2004 Volkswagen Jetta

TL*THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE OVERHEATED BECAUSE THE WATER PUMP FAILED. THE CONTACT STATED TAH THE RIM ON THE WATER PUMP MADE OF PLASTIC BROKE IN TWO PIECES. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 56,000. UPDATED 02/10/11 *BF UPDATED 10/12/11

TL*THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT HAD TO REPLACE THE IGNITION COILS AND THE CYLINDERS IN THE ENGINE. THE COILS WERE REPLACED SEVERAL TIMES AND FAILED AGAIN AFTER ONE MONTH. THE MECHANIC STATED THAT THIS WAS A MAJOR PROBLEM WITH THIS MAKE AND MODEL VEHICLE. THE FIRST FAILURE OCCURRED IN FEBRUARY 2010 WHEN THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS REPAIRED SIX TIMES WITHIN A YEAR. ALL OF THE COILS DO NOT FAIL AT THE SAME TIME, BUT THE ALL FOUR COILS HAVE BEEN REPLACED MORE THAN ONE TIME. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 101000 AND THE CURRENT MILEAGE WAS 135000.

CATASTROPHIC DRIVE TRAIN FAILURE OF A VW JETTA TDI 5-SPEED. WHILE TRAVELING AT 65-70 MPH ON RELATIVELY FLAT TERRAIN ON A CLEAR ROADWAY IN 5TH GEAR WITH NO INPUT TO THE CLUTCH OR THE TRANSMISSION, OCCUPANTS FELT & HEARD A SINGLE, MUFFLED 'THUMP'. ORIGINATING DRIVE TRAIN FAILURE EVENT OCCURRED SPONTANEOUSLY AND COMPLETELY UNEXPECTEDLY. AFTER THE ANOMALY, A LOW METALLIC RATTLE WAS HEARD. ONCE CLEAR OF SURROUNDING TRAFFIC, IN TROUBLESHOOTING ATTEMPT THE DRIVER ENGAGED CLUTCH AND SHIFTED INTO NEUTRAL; IMMEDIATELY THE RATTLING BECAME MORE PRONOUNCED. FIFTH GEAR IMMEDIATELY REENGAGED AND NOISE ABATED. DRIVER NAVIGATED VEHICLE UNDER POWER TO RIGHT LANE & SUBSEQUENTLY EXITED EXPRESSWAY. UPON APPROACH TO SIDE STREET TRAFFIC LIGHT, THE CLUTCH WAS REENGAGED RESULTING IN A RENEWED RATTLING; TRANSMISSION SHIFTED INTO NEUTRAL. WHEN CLUTCH WAS LET OUT, THE CONSTANT RATTLING NOISE CONTINUED AS ENGINE IDLED. WITH SIGNAL CHANGE, CLUTCH REENGAGED & TRANSMISSION SHIFTED TO 1ST GEAR. CLUTCH SLOWLY, CAREFULLY RELEASED: NOTICEABLE NOISE INCREASE FOLLOWED BY SHORT SERIES OF LOUD, SHARP NOISES. VEHICLE LURCHED AND STALLED. TWO ATTEMPTS TO RESTART ENGINE FAILED; NO ENGINE RESPONSE. POLICE NOTIFIED & VEHICLE TOWED TO DEALER. SIGNIFICANT FLUID LEAKAGE NOTICED. SUBSEQUENTLY NOTIFIED BY VW DEALER THAT MAIN SHAFT OF TRANSMISSION CATASTROPHICALLY FAILED PRESSING FLYWHEEL INTO MOTOR DAMAGING CASING, BEARINGS & CRANKSHAFT LOBS RESULTING IN IMMEDIATE SEIZING OF THE DIESEL POWER PLANT. TOTAL REPLACEMENT OF TRANSMISSION AND ENGINE ASSEMBLY REQUIRED (EST ~$11K). THIS VEHICLE HAD ALL MAINTENANCE SERVICE PERFORMED REGULARLY AT 5K INTERVALS BY VW DEALER (DOCUMENTED) AND HAD RECENTLY HAD FULL 100K SERVICE INCLUDING TIMING BELT REPLACEMENT. NO NOTIFICATION/CONCERN FOR ADDITIONAL TRANSMISSION INSPECTION/SERVICE. CLUTCH RECENTLY SEEMED TO BE ENGAGING A WEE BIT FURTHER BUT NO BOTTOMING OF PEDAL OR CLUTCH SLIPPAGE. OWNER EXPECTED TO SCHEDULE CLUTCH INSPECTION/WORK DURING NEXT 5K SERVICE VISIT. *TR

TL*THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE TRANSMISSION FAILED AND THE VEHICLE BECAME HESITANT WHEN THE ACCELERATOR PEDAL WAS APPLIED. THE FAILURE HAD BEEN AN ONGOING ISSUE SINCE THE VEHICLE WAS PURCHASED, BUT THE DEALER STATED THAT WAS HOW THE TRANSMISSION WORKED AND NOTHING WAS WRONG. THE VEHICLE ALSO MADE A KNOCKING NOISE AND WOULD BECOME SLUGGISH WHEN ACCELERATING. THE DEALER RECENTLY STATED THAT THE FAILURE WAS RELATED TO THE VALVE BODY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 10. THE CURRENT MILEAGE WAS 57396.

CAR BEGAN TO STUTTER AND SHAKE LIKE IT WAS RUNNING OUT OF GAS. SHORTLY AFTER I HAD AN EPC LIGHT THAT WOULD FLASH ON EVERY TIME I GOT UP TO SPEED AND IT WOULD START THE STUTTERING SOUND AGAIN. AFTER SEVERAL COSTLY TRIPS TO DEALERSHIP THEY DISCOVERED IT WAS A COOLANT MIGRATION PROBLEM. WHERE A DEFECTIVE PART THAT VW KNOWS ABOUT LEAKS COOLANT IN TO THE WIRE HARNESS. COOLANT CAN MIGRATE THROUGHOUT ALL ELECTRICAL ROUTES THROUGHOUT THE CAR. THIS HAS BEEN A PROBLEM SINCE 1998 AND VW WILL NOT DO A RECALL OR REIMBURSE FOR THE WORK. IF YOU HAVE ELECTRICAL PROBLEMS WITH YOUR VW THIS IS MOST LIKELY THE CAUSE. WE HAVE ALSO HAD PROBLEMS WITH TAILLIGHTS BLOWING VERY FREQUENTLY. THIS CAN BE A CAUSE OF COOLANT MIGRATING THROUGH THE WIRES. *TR

2004 JETTA TDI 4 DOOR SEDAN, IT'S A TURBO DIESEL. THE STALK HAVE TO GOES TO HIGH BEAM IN ORDER FOR THE CRUISE CONTROL TO WORK. THIS IS A DEFECTIVE PART, IT HAVE BEEN WITH THIS CAR FOR MANY YEARS BUT WE DO NOT HAVE TIME TO FIX THIS AND IT'S COST LOST OF MONEY TO REPLACE. WHEN CLICK ON THE TURN SIGNAL THE CRUISE CONTROL WHEN OFF, IT'S VERY DANGEROUS ON THE FREEWAY. I BELIEVE THIS PARTS OF THE CAR SHOULD BE RECALLED, IT'S DANGEROUS. THANK YOU FOR LISTENING. *TR

VOLKSWAGEN JETTA (ALL VW) HAVE PLASTIC IMPELLER WATER PUMP THAT BREAKS, CAUSING RAPID OVERHEATING AND POSSIBLE ENGINE SEIZURE. ENGINE SEIZURE MAY RESULT IN REAR END COLLISION. VOLKSWAGEN KNOWS OF THIS PROBLEM BUT REFUSES TO RECALL THE VEHICLES. NEW WATER PUMP IS REQUIRED TO REPAIR THE CONDITION. THE PARTS COSTS OVER $200.00. FAIRLY EASY TO REPLACE BUT THE PLASTIC PARTS COULD ALSO BREAK LOOSE AND GET PUMPED THROUGH THE ENGINE AND TURBO AND CAUSE CATASTROPHIC FAILURE. *TR

ON MARCH 25, 2007, I WOKE UP TO A STRONG FUEL LEAKAGE ODOR, SEEKING FOR AIR, ALMOST FINDING IT IMPOSSIBLE TO BREATHE PROPERLY, FORCING ME TO EVACUATE MY HOUSE AT LATE HOURS OF THE NIGHT THE GAS SMELL WAS COMING FROM MY CAR IN THE GARAGE. I CALLED DEALER, EXPLAINED MATTER. DEALER TOLD ME MY CAR WAS NO LONGER UNDER WARRANTY FOR THIS KIND OF SERVICE/OR REPAIR. THE CAR HAD 49,419 MILES AND WAS 4 YEARS OLD BUT VOLKSWAGEN WARRANTY IS COVERED FOR 50,000 MILES OR 5 YEARS WHICHEVER OCCURS FIRST. I CALLED VOLKSWAGEN BUT THEY ONLY CONFIRMED THE DEALER'S STATEMENT. TOOK CAR TO LOCAL SHOP, THEY REPLACED FUEL TANK AND FUEL PUMP ON MARCH 26, 2007, COST $754.11. THREE MONTHS AFTER THE STRONG GAS SMELL CAME BACK ONLY DIFFERENCE THE ENGINE LIGHT CAME ON AND SMELL WAS NOT AS STRONG. I TOOK CAR TO A DIFFERENT SHOP ON MAY 22, 2008 THEY REPAIRED GAS TANK AND FUEL PUMP SEAL COSTING ME $316.20. THIS APRIL RECEIVED A LETTER FROM VOLKSWAGEN FOR FAULTY CATALYTIC CONVERTER, RESEARCHED CONNECTION TO POTENTIAL GAS LEAK AND FOUND IN DISBELIEF THE GAS LEAK RECALL ON 2005, WHICH I WAS NOT NOTIFIED IN 2005 OR 2007. *TR