LOOSE STEERING CHANCE OF LOSS OF CONTROL DUE TO INCORRECT TIE ROD END FROM KIT SPECIFIC TO VEHICLE. RESULTING IN RUINED TIRES AND ALIGNMENT. HTTPS://WWW.AUTOPARTSWAREHOUSE.COM/SKU/VOLKSWAGEN/JETTA/REPLACEMENT/CONTROL_ARM_KIT/2004/TDI/4_CYL_1-DOT-9L/REPV281502.HTML . THE KIT I BELIEVE HAS A TIE ROD END MEANT FOR A PREIOUS GENERA…
Read full complaint
LOOSE STEERING CHANCE OF LOSS OF CONTROL DUE TO INCORRECT TIE ROD END FROM KIT SPECIFIC TO VEHICLE. RESULTING IN RUINED TIRES AND ALIGNMENT. HTTPS://WWW.AUTOPARTSWAREHOUSE.COM/SKU/VOLKSWAGEN/JETTA/REPLACEMENT/CONTROL_ARM_KIT/2004/TDI/4_CYL_1-DOT-9L/REPV281502.HTML . THE KIT I BELIEVE HAS A TIE ROD END MEANT FOR A PREIOUS GENERATION VOLKSWAGON AS IT IS SMALLER IN DIAMETER AND CANNOT TAPER LOCK. IT TOOK ABOUT A MONTH OF DRIVING FOR IT TO LOOSEN UP. THE PHYSICAL PROBLEM IS THE OUTER TIR ROD BUT THE INNER TIE ROD IS OF A SMALLER DIAMETER AND ADJUSTMENTS WERE MADE INSTALLING SO THE DUST BOOT WOULD PROPERLY SEAL BUT IT WAS MECHANICALLY COMPATABLE.
NHTSA ODI #11171055
118,000 miles · Jul 13, 2012
Electrical SystemEngineSteering
2004 VW JETTA GLS TDI OPERATING AT 75MPH ON INTERSTATE ON CRUISE CONTROL WHEN THE ENGINE SHUTOFF COMPLETELY. THE VEHICLE STILL HAD ELECTRICAL POWER AND ENGINE WOULD CRANK BUT WOULD NOT START. I ROLLED THE VEHICLE OFF TO THE SIDE OF THE ROAD AND ATTEMPTED TO RE-START THE ENGINE AND IT FINALLY CRANKED AND DROVE VEHICLE APPROXIMATE…
Read full complaint
2004 VW JETTA GLS TDI OPERATING AT 75MPH ON INTERSTATE ON CRUISE CONTROL WHEN THE ENGINE SHUTOFF COMPLETELY. THE VEHICLE STILL HAD ELECTRICAL POWER AND ENGINE WOULD CRANK BUT WOULD NOT START. I ROLLED THE VEHICLE OFF TO THE SIDE OF THE ROAD AND ATTEMPTED TO RE-START THE ENGINE AND IT FINALLY CRANKED AND DROVE VEHICLE APPROXIMATELY 500 MILES BEFORE EXPERIENCING SIMILAR ISSUE. SINCE THAT TIME VEHICLE HAS HAD SAME ISSUE OVER 10 TIMES. DEALER HAS INSPECTED VEHICLE THREE TIMES AND HAS NOT DISCOVERED ISSUE. *TR
NHTSA ODI #10465504
48,500 miles · Oct 20, 2007
Steering
CLICKING/POPPING NOISE COMING FROM THE FRONT OF THE VEHICLE WHEN MAKING TURNS. TAKEN TO DEALERSHIP TWO TIME AND THEY STATE THEY CANNOT DUPLICATE THE SOUND. DROVE TECH AROUND AND DUPLICATED SOUND FOR HIM. DEALERSHIP STILL STATED THEY COULD NOT MAKE ANY REPAIRS BECAUSE THEY COULDN'T DUPLICATE THE PROBLEM. SERVICE ALSO STATED THAT …
Read full complaint
CLICKING/POPPING NOISE COMING FROM THE FRONT OF THE VEHICLE WHEN MAKING TURNS. TAKEN TO DEALERSHIP TWO TIME AND THEY STATE THEY CANNOT DUPLICATE THE SOUND. DROVE TECH AROUND AND DUPLICATED SOUND FOR HIM. DEALERSHIP STILL STATED THEY COULD NOT MAKE ANY REPAIRS BECAUSE THEY COULDN'T DUPLICATE THE PROBLEM. SERVICE ALSO STATED THAT THE PROBLEM WOULD HAVE TO GET WORSE BEFORE THEY COULD DO ANYTHING. *TR
NHTSA ODI #10206405
Mileage unknown · Jan 18, 2005
Steering
THERE IS A CLICKING NOISE COMING FROM THE FRONT OF THE VEHICLE, WHICH IS INTERFERING WITH THE STEERING MAKING IT DIFFICULT TO CONTROL. OWNER WILL CONTACT MANUFACTURER. *JB
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Volkswagen Jetta Problems, Complaints & Recalls | Skip That Year
Illustration