IllustrationDRIVER'S SIDE SEATBELT LATCH BROKEN. TRIED TO BUCKLE SEAT BELT AND A PART IN SEATBELT LATCH MECHANISM BROKE OFF INSIDE. SEATBELT WILL NOT LATCH. *TR
2004 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2004 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
2925–50K
4450–75K
3075–100K
35100–150K
15150K+
191 reports with mileage · 40 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports20 fire reports13 injury reports
Seat Belts complaints
6 reports1. SEAT BELT BECOMES DIFFICULT TO PULL AND LOCK. THEN FAILS. 2. BACK SEAT, CENTER POSITION SEAT, BELT TENSIONER UNIT FAILS, CANNOT PULL AND FASTEN SEAT BELT. 3. REMOVE SEAT, REPLACE BELT TENSIONER UNIT. OLD PART AVAILABLE. *TR
DRIVER'S SIDE SEATBELT LATCH BROKEN. TRIED TO BUCKLE SEAT BELT AND A PART IN SEATBELT LATCH MECHANISM BROKE OFF INSIDE. SEATBELT WILL NOT LATCH. *TR
TL*THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT HER REAR MIDDLE SEAT BELT DOES NOT COME OUT IN ORDER FOR IT TO BE USED. THE VEHICLE HAS BEEN TO THE DEALER APPROXIMATELY FOUR TIMES WITH NO RESOLUTION. THE CURRENT MILEAGE WAS 43,057 AND FAILURE MILEAGE WAS 38,173. UPDATED 07/15/08. *JB
MY 2004 JETTA HAS 51,000 MILES AND IS ONLY 3.5 YEARS OLD. THE AIR BAG/ SEAT BELT ALERT ICON CAME ON AND I BROUGHT THE CAR TO NEW COUNTRY VW IN GREENWICH CT. I WAS TOLD THAT THE PASSENGER SEAT BELT LATCH FAILED AND NEEDED TO BE REPLACED. I WAS CHARGED $140.00 FOR THIS VISIT AND WAS TOLD THAT THE REPAIR WOULD COST $425.00. THEY ST…
Read full complaint
MY 2004 JETTA HAS 51,000 MILES AND IS ONLY 3.5 YEARS OLD. THE AIR BAG/ SEAT BELT ALERT ICON CAME ON AND I BROUGHT THE CAR TO NEW COUNTRY VW IN GREENWICH CT. I WAS TOLD THAT THE PASSENGER SEAT BELT LATCH FAILED AND NEEDED TO BE REPLACED. I WAS CHARGED $140.00 FOR THIS VISIT AND WAS TOLD THAT THE REPAIR WOULD COST $425.00. THEY STATED THAT THE PART WAS ON A NATION WIDE BACKORDER AND THEY DID NOT KNOW WHEN THE PART WOULD BE IN THE USA. THE FACT THAT THERE WAS NO PART AVAILABLE IN THE ENTIRE US INDICATES TO ME THAT THERE IS A PROBLEM WITH THIS PART. A CRITICAL SAFETY COMPONENT LIKE SAFETY BELTS SHOULD NOT FAIL AFTER ONLY 3.5 YEARS AND SHOULD BE EXCLUDED FROM ANY LIMITED WARRANTY. ALSO BECAUSE OF THIS PARTS FAILURE I WAS TOLD THAT THE AIR BAG SYSTEM WOULD NOT WORK PROPERLY, WHICH IS ANOTHER SAFETY ISSUE. *CN
DT*: THE CONTACT STATED WHILE TRAVELING 35 MPH, THE DRIVER SIDE CURTAIN AIRBAG AND THE REAR LEFT PASSENGER SIDE CURTAIN AIR BAG DEPLOYED WITHOUT WARNING, PUSHING THE CONTACT TO THE RIGHT SIDE OF THE VEHICLE, AND DAMAGING THE SEAT BELT. A POLICE REPORT AND PHOTOS WERE TAKEN OF THE VEHICLE. THE CONTACT SUSTAINED A WELT ON THE LE…
Read full complaint
DT*: THE CONTACT STATED WHILE TRAVELING 35 MPH, THE DRIVER SIDE CURTAIN AIRBAG AND THE REAR LEFT PASSENGER SIDE CURTAIN AIR BAG DEPLOYED WITHOUT WARNING, PUSHING THE CONTACT TO THE RIGHT SIDE OF THE VEHICLE, AND DAMAGING THE SEAT BELT. A POLICE REPORT AND PHOTOS WERE TAKEN OF THE VEHICLE. THE CONTACT SUSTAINED A WELT ON THE LEFT HIP FROM THE AIRBAG. THE VEHICLE WAS DRIVEN TO A RESIDENCE. THE SERVICE DEALER WAS NOTIFIED AND THE VEHICLE WAS TAKEN TO THE DEALER THE NEXT MORNING. THE MANUFACTURER WAS NOTIFIED.
Official recalls
207V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
04V586000 · Fuel System, Diesel
Dec 15, 2004
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.