2004 Volkswagen Jetta

ON 1/25/2007 OUR VEHICLE WAS TAKEN IN TO DEALER SERVICE DEPARTMENT FOR REPAIR OF AN ENGINE VIBRATION. INITIAL DIAGNOSIS WAS THE TIMING BELT AND IT WAS ADJUSTED APPROXIMATELY 4 DEGREES AND PROMISED TO BE READY ON 1/27/07. BELT ADJUSTMENT DID NOT FIX THE PROBLEM AND CAR WAS NOT PICKED UP. ADDITIONAL DIAGNOSIS WAS PERFORMED, INCLUDING COMPRESSION TEST OF ENGINE, AND TECHNICIAN CONTACTED VOLKSWAGEN FOR ASSISTANCE. AFTER WEEKS OF DIAGNOSIS AND TESTING WE WERE TOLD THAT THE IN TANK FUEL PUMP THAT WAS REPLACED AT A DIFFERENT VW DEALERSHIP ON 9/11/06 HAD FAILED. RESEARCHING NHTSA I ALSO FOUND OUT THAT IT WAS A RECALLED PUMP. BECAUSE THE MILEAGE WAS ALMOST 3K OVER THE WARRANTY OF THE PART AND VW ALREADY SATISFIED THE RECALL VW WOULD NOT COVER A REPLACEMENT. THE NEW FUEL PUMP ALSO DID NOT FIX THE VIBRATION PROBLEM. DEALERS DIAGNOSIS WITH VOLKSWAGEN'S ASSISTANCE CONTINUED UNTIL 2/8/07 WHEN WE WERE TOLD THAT A VALVE LIFTER IN THE CAM ASSEMBLY HAD FAILED CAUSING THE VIBRATION. DEALERSHIP RECOMMENDED A COMPLETE "CYLINDER HEAD REPLACEMENT" AT A COST OF ABOUT $4,500. MY HUSBAND ASKED TO SPEAK WITH THE MECHANIC AND DETERMINED THAT THE DAMAGE WAS ONLY TO ONE VALVE LIFTER. MY HUSBAND AND I DECIDED TO FIX WHAT WAS BROKEN AND ONLY FIXED THE DAMAGED LIFTER WHICH WAS ESTIMATED AT ABOUT $500. THE DEALER AGREED TO PERFORM THIS REPAIR, BUT WOULD NOT WARRANTY THE WORK BECAUSE THEY WERE CONCERNED THAT CYLINDER HEAD MIGHT BE FAULTY. OUR VEHICLE WAS FINALLY REPAIRED AND ABLE TO BE PICKED UP ON 2/19/07. COST OF REPAIRS WAS NEGOTIATED WITHIN OUR SATISFACTION, HOWEVER, THE SERVICE WAS NOT TIMELY AND FEEL THAT THE PARTS IN THE VEHICLE ARE BELOW STANDARD. NOW WE HAVE AN ADDITIONAL PROBLEM WE DID NOT HAVE BEFORE TAKING IT IN FOR REPAIR. TWO DAYS AFTER WE RECEIVED THE VEHICLE FROM THE DEALERSHIP WE FIGURED OUT THE FUEL GAUGE IS NO LONGER WORKING PROPERLY AND HAS A FALSE READING OF APPROXIMATELY 1/4 TANK WHEN THE TANK IS EMPTY. *JB

FUEL PUMP LEAK. THE FUEL PUMP WAS FOUND TO BE LEAKING BY THE DEALERSHIP. THE DEALERSHIP COULD NOT EXPLAIN WHERE THE LEAK WAS COMING FROM OTHER THEN SAYING 'THE FUEL PUMP', THEY COULD NOT SAY IF THE PUMP PART WAS COVERED UNDER THE PREVIOUS RECALL IN 2005, THEY COULD NOT SAY IF THE PUMP WAS REPLACED UNDER THAT RECALL OR GIVE ANY INFORMATION ABOUT THE PREVIOUS RECALL. *JB

WAS DRIVING ALONG AFTER JUST ACCELERATING FROM A STOP LIGHT AND GOT UP TO SPEED (ABOUT 45 MPH). THEN I FELT WHAT I THOUGHT WAS THE ENGINE FALTER, AND THE MOTOR JUST QUIT, NO WARNING WHATSOEVER. NO ODD SOUNDS EITHER. JUST LIKE I TURNED THE KEY "OFF". I COASTED TO A STOP OFF THE ROAD AND TRIED TO START IT A FEW TIMES. JUST CONTINUOUS CRANKING AND NOT EVEN A "COUGH". NO UNUSUAL NOISES, COMPRESSION SEEMED GOOD. TIMING BELT FAILURE APPEARS TO BE RULED OUT. NO EXTERNAL LEAK IN THE FUEL PUMP (THE ONE IN THE ENGINE COMPARTMENT) EITHER. WHEN THE KEY IS TURNED ON, ALL THE NORMAL DASH LIGHTS LIGHT. YESTERDAY, I DID NOTICE A MORE PRONOUNCED SOUND COMING FROM THE IN-TANK LIFT PUMP WHEN I TURNED THE KEY TO "GLOW". AFTER THE ENGINE FAILURE TONIGHT, I COULD NOT HEAR ANY SOUND FROM THE LIFT PUMP. CAR WAS TOWED TO THE VW DEALER SINCE THE WARRANTY WAS STILL IN EFFECT. TODAY (THREE DAYS LATER) THE DEALER CALLED ME AND SAID THE IN-TANK FUEL PUMP FAILED AND IT WOULD BE REPLACED UNDER WARRANTY. *JB

I OWN A 2004 VW JETTA TDI. VW HAS A RECALL (VY) FO RPOSSIBLE DEFECTIVE TANDEM FUEL INJECTION PUMPS WHICH CAN RESULT IN AN ENGINE FIRE. THE RECALL STATES CARS BETWEN VIN 031216 TO 190756 WITH AN UNMARKED LUK PUMP NEEDS TO BE REPLACED. MY CARS VIN IS 166408 WHICH IS BELOW THE CUT OFF, MY CAR ALSO HAS THE UNMARKED LUK PUMP. ACCORDING TO VW MY CAR DOES NOT NEED A NEW PUMP. I HAVE TRIED TO DEAL WITH VW BUT THEY KEEP TELLING ME MY CAR IS NOT EFFECTED YET IT MEETS THEIR REQUIREMENTS. IT SOUNDS TO ME THAT THEY ARE NOT PERFORMING UP TO THEIR STATED RECALL PLAN.