NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
10 reportsClear category filter5,000 miles · Oct 18, 2005
SteeringSuspension
1) SINCE I PURCHASED THE CAR IN 2000, THERE HAS BEEN A SOUND MADE AT THE FRONT END OF THE CAR WHILE DRIVING. 2) LOUD SOUND WHEN DRIVING ON REGULAR ROADS. PERSISTENT LOUD THUMP SOUND. 3) I HAVE TAKEN THE CAR TO THE DEALER SEVERAL TIMES FOR SOUNDS AND HAVE ASKED OTHER JETTA OWNERS AND THEY TOO AGREED THAT THEIR CAR HAD A LOU…
Read full complaint
1) SINCE I PURCHASED THE CAR IN 2000, THERE HAS BEEN A SOUND MADE AT THE FRONT END OF THE CAR WHILE DRIVING. 2) LOUD SOUND WHEN DRIVING ON REGULAR ROADS. PERSISTENT LOUD THUMP SOUND. 3) I HAVE TAKEN THE CAR TO THE DEALER SEVERAL TIMES FOR SOUNDS AND HAVE ASKED OTHER JETTA OWNERS AND THEY TOO AGREED THAT THEIR CAR HAD A LOUD NOISE FROM THE FRONT END. I WAS EVEN CHARGED SEVERAL TIMES BY THE DEALER WERE I PURCHASED THE CAR TO RE-TORQUE AND TEST THE FRONT END. THEY AGREED THAT THEY COULD DEFINITELY HEAR THE SOUND BUT COULD NOT TROUBLE SHOOT THE PROBLEM. ALL ATTEMPTS TO REPAIR OR FIND PROBLEM ARE DOCUMENTED IN MY SERVICE THROUGH VOLKSWAGEN. I ALSO HAVE TAKEN MY CAR TO APPROXIMATELY 8 ADDITIONAL SHOPS TO TROUBLE SHOOT NOISE. ALL AGREED THAT THE NOISE WAS UNBEARABLE BUT NO SOLUTION WAS FOUND. NOW I HAVE HAD MY CAR FOR 4.5 YEARS AND IT SOUNDS LIKE MY FRONT END IS GOING TO FALL APART. *JB
NHTSA ODI #10140103
Mileage unknown · Dec 15, 2004
Engine And Engine CoolingStructureSuspension
I PURCHASED A 2000 VPLKSWAGEN JETTA IN THE YEAR 2002, PRE-OWNED. I HAVE HAD NOTHING BUT PROBLEMS WITH IT SINCE I BOUGHT IT, AND NOW AM TRADING IT IN, AND TAKING A $3000 LOSS. HERE IS A LIST OF THE PROBLEMS I HAVE HAD IN THE LAST 2 YEARS LISTED FROM FIRST PROBLEMS TO MOST RECENT: 1. WINDOW TRAY BROKE, WINDOW FELL INTO THE DOO…
Read full complaint
I PURCHASED A 2000 VPLKSWAGEN JETTA IN THE YEAR 2002, PRE-OWNED. I HAVE HAD NOTHING BUT PROBLEMS WITH IT SINCE I BOUGHT IT, AND NOW AM TRADING IT IN, AND TAKING A $3000 LOSS. HERE IS A LIST OF THE PROBLEMS I HAVE HAD IN THE LAST 2 YEARS LISTED FROM FIRST PROBLEMS TO MOST RECENT: 1. WINDOW TRAY BROKE, WINDOW FELL INTO THE DOOR. $300 2. TRUNK LATCH BROKE, HAD TO GET REPLACED $50 3. SUNROOF BROKE, WOULD NOT MOVE AND NEEDED THE ENTIRE THING REPLACED INCLUDING THE MOTOR. $1800 4. WATER PUMP LEAKED OUT ALL COOLANT, NEEDED TO BE REPLACED $ 600 5. STRUT COIL SNAPED IN HALF WHILE DRIVING, NEEDED TO REPLACE BOTH SIDES $500 6. LASTLY, (THIS IS THE POINT WHEN I DECIDED TO FILE A COMPLAINT AND TRADE THE CAR IN FOR ANOTHER BRAND) WATER LEAKING FROM THE ELECTRICAL PANEL ON TOP OF INSIDE ROOF. SUNROOF THEN MALFUNCTIONED, OPENING WHEN THE CAR WAS STARTED AND THE KNOB WAS NOT TOUCHED. HAD TO PAY TO DISCONNECT POWER SUNROOF. WHATEVER YOU DO, PLEASE, DO NOT BUY A VW JETTA. THAT IS UNLESS YOU WANT TO HAVE IT CONTINUALLY IN THE SHOP AND HAVING TO SPEND A LOT OF MONEY ON REPAIRS. *AK
NHTSA ODI #10103035
38,000 miles · Jul 6, 2004
Electrical SystemEquipmentPower Train
TRANSMISSION FAILED. THE DEALER REPLACED THE PART. HOWEVER, TWO WEEKS LATER THE PART FAILED AGAIN. *AK THE VEHICLE WOULD NOT GO INTO REVERSE. THE TRANSMISSION SLIPPED AND THE VEHICLE HAD RUN INTO A POLE AT A GAS STATION ON THE RIGHT FRONT SIDE. THIS PROBLEM REMAINED THE SAME. THE ENGINE LIGHT HAD COME ON ALONG WITH THE…
Read full complaint
TRANSMISSION FAILED. THE DEALER REPLACED THE PART. HOWEVER, TWO WEEKS LATER THE PART FAILED AGAIN. *AK THE VEHICLE WOULD NOT GO INTO REVERSE. THE TRANSMISSION SLIPPED AND THE VEHICLE HAD RUN INTO A POLE AT A GAS STATION ON THE RIGHT FRONT SIDE. THIS PROBLEM REMAINED THE SAME. THE ENGINE LIGHT HAD COME ON ALONG WITH THE TRANSMISSION PROBLEMS. OTHER PROBLEMS WERE: THE TIRE PRESSURE HAD TO BE RESET ON NUMEROUS OCCASIONS, REAR PADS, A/C WAS NOT COOLING, GLOVE BOX, POWER WINDOWS, CONSOLE, POWER SUNROOF, INTERIOR TRIM, STEERING/SUSPENSION, DRIVEABILITY, TRIM ELECTRICAL, SOUND SYSTEM, AND HEATING/COOLING. *SC THE CONSUMER DID NOT REPORT ANY DAMAGE TO VEHICLE WHEN SHE HIT THE POLE. *JB
NHTSA ODI #10074085
Mileage unknown · Oct 6, 2003
SeatsSuspension
CONSUMER NOTICED BROKEN SPRINGS UNDER DRIVER'S AND PASSENGER'S SEATS. AS A RESULT, WAS UNABLE TO RAISE PASSENGER'S SEAT.*AK
NHTSA ODI #10042394
Mileage unknown · Sep 9, 2003
Engine And Engine CoolingStructureSuspension
CONSUMER CONCERNED WITH ENGINE AND WHEEL BEARING ISSUES. WANTS TO KNOW WHO IS GOING TO REIMBURSE FOR REPAIRS. OXYGEN SENSOR HAD TO BE REPLACED SEVERAL TIMES. THE DRIVER SIDE INNER DOOR HANDLE WAS DIFFICULT TO OPERATE. THE LEFT SIDE AXLE SHAFT WAS REPLACED BECAUSE IT WAS MAKING A WHINING NOISE. WHILE DRIVING THE VEHICLE STAL…
Read full complaint
CONSUMER CONCERNED WITH ENGINE AND WHEEL BEARING ISSUES. WANTS TO KNOW WHO IS GOING TO REIMBURSE FOR REPAIRS. OXYGEN SENSOR HAD TO BE REPLACED SEVERAL TIMES. THE DRIVER SIDE INNER DOOR HANDLE WAS DIFFICULT TO OPERATE. THE LEFT SIDE AXLE SHAFT WAS REPLACED BECAUSE IT WAS MAKING A WHINING NOISE. WHILE DRIVING THE VEHICLE STALLED. IT WAS LATER DETERMINED THAT A SMALL RODENT HAD BUILT A NEST WHICH CLOGGED THE AIR BOX. THE VEHICLE STALLED AGAIN AND THIS TIME THEY REPLACE THE MAF SENSOR. THE CRUISE CONTROL WAS INOPERATIVE. *NM
NHTSA ODI #10039837
11,000 miles · Jan 21, 2003
Suspension
WHILE DRIVING AT ANY SPEED THE VEHICLE VIBRATES AND SUDDENLY TAKES OFF FASTER THAN NORMAL. THERE IS A SMELL OF SULFUR. TOOK TO DEALER AND THE DEALER STATED THE IGNITION COILS ARE FAULTY. DEALER IS REPLACING WITH THE SAME DESIGN COIL. PLEASE PROVIDE ANY FURTHER INFORMATION. PH
NHTSA ODI #10004280
Mileage unknown · Dec 9, 2002
SuspensionUnknown Or OtherVisibility
THIS CAR HAS LITERALLY COME UNSCREWED SINCE I PURCHASED IT 2.5 YEARS AGO-PARTS INSIDE AND OUT! MOST RECENTLY THE AXLE "CAME UNSCREWED" FOR NO REASON AND THE BOLTS SNAPPED. THE WINDOWS HAVE MALFUNCTIONED AND THE REAR SUSPENSION HAD TO BE SCREWED BACK TOGETHER SHORTLY AFTER I BOUGHT IT. THE PLASTIC COVERING UNDERNEATH ALSO FELL …
Read full complaint
THIS CAR HAS LITERALLY COME UNSCREWED SINCE I PURCHASED IT 2.5 YEARS AGO-PARTS INSIDE AND OUT! MOST RECENTLY THE AXLE "CAME UNSCREWED" FOR NO REASON AND THE BOLTS SNAPPED. THE WINDOWS HAVE MALFUNCTIONED AND THE REAR SUSPENSION HAD TO BE SCREWED BACK TOGETHER SHORTLY AFTER I BOUGHT IT. THE PLASTIC COVERING UNDERNEATH ALSO FELL OFF FOR NO REASON-ALSO WHILE I WAS DRIVING. THE WINDSHIELD WIPERS HAVE COME UNSCREWED TWICE AND CEASED TO FUNCTION ONCE ON THE HIGHWAY AT HIGH SPEED DURING A RAIN STORM. THE GLOVE COMPARTMENT AND CUP HOLDERS HAVE ALL FALLEN OUT. I BOUGHT THIS CAR NEW 2 1/2 YEARS AGO AND I KNOW FEAR FOR MY LIFE EVERY TIME I GET INTO IT. I HAVE REPORTED THIS TO BOTH THE DEALER AND TO VOLKSWAGEN. NEITHER HAVE EXPRESSED ANY CONCERN WHATSOEVER. DT
NHTSA ODI #770649
Mileage unknown · Jan 30, 2002
Power TrainSuspension
VEHICLE PULLED TO THE SIDE WHEN HITTING BUMPS AND SEEMED TO HIT BUMPS HARDER, CONSUMER TOOK IT TO THE DEALER WHO TIGHTENED THE FRONT END, HOWEVER THE PROBLEMS STILL EXIST. *SLC
NHTSA ODI #564200
Mileage unknown · Aug 15, 2001
Suspension
VEHICLE PULLED TO THE RIGHT ON DATE OF PURCHASE,AFTR 3 ATTEMPTS TO ALIGN FRONT END WITH NO REMEDY MFG REPLACED VEHICLE. *AK
NHTSA ODI #750498
Mileage unknown · Feb 21, 2001
Suspension
DEALERSHIP HAS ATTEMPTED TO FIX CREAKING SUSPENSION NOISE 3 TIMES. UNABLE TO DIAGNOSE PROBLEM, OR FIX IT. PROBLEM IS GETTING WORSE. EXTERIOR NOISE WHEN DRIVING OVER BUMPS, HOLES IN ROAD, AND WHEN TURNING RIGHT, OR WHEN STEERING WHEEL IS TURNING RIGHT. DEFINITELY NOT AN INTERIOR CREAKING NOISE. WORRIED ABOUT SAFETY B/C DEALERSHIP…
Read full complaint
DEALERSHIP HAS ATTEMPTED TO FIX CREAKING SUSPENSION NOISE 3 TIMES. UNABLE TO DIAGNOSE PROBLEM, OR FIX IT. PROBLEM IS GETTING WORSE. EXTERIOR NOISE WHEN DRIVING OVER BUMPS, HOLES IN ROAD, AND WHEN TURNING RIGHT, OR WHEN STEERING WHEEL IS TURNING RIGHT. DEFINITELY NOT AN INTERIOR CREAKING NOISE. WORRIED ABOUT SAFETY B/C DEALERSHIP IS UNABLE TO DIAGNOSE PROBLEM. NOT SURE IF THE PROBLEM IS A SUSPENSION ISSUE. PLEASE HELP GET THIS FIXED?
NHTSA ODI #741279
Official recalls
4May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
Illustration