NHTSA owner reports · September 18, 2026 snapshot.
Seats complaints
17 reportsClear category filter489,000 miles · Oct 3, 2024
Electrical SystemSeatsInjury
The contact owns a 2000 Volkswagen Jetta. The contact stated that while driving with the front driver’s side seat heater activated, the seat became extremely hot. The contact started smelling a burning odor coming from the seat. The contact felt a hole in the seat, which burned the contact's middle finger. The contact immediatel…
Read full complaint
The contact owns a 2000 Volkswagen Jetta. The contact stated that while driving with the front driver’s side seat heater activated, the seat became extremely hot. The contact started smelling a burning odor coming from the seat. The contact felt a hole in the seat, which burned the contact's middle finger. The contact immediately pulled over and turned off the vehicle. The contact’s back started burning due to the extreme heat of the seat back. Upon inspection, the contact discovered a hole in his jacket and approximately four holes that had formed in the front driver seat due to the seat heater failure. The contact was not treated for the burns to his back. The contact stated that two dealers were notified of the failure but neither provided immediate assistance. The manufacturer was also notified of the failure and informed the contact that there were no recalls on the vehicle. The vehicle was not repaired. The failure mileage was approximately 489,000.
NHTSA ODI #11617892
297,000 miles · Feb 12, 2015
SeatsFireInjury
I OWN A 2000 VW JETTA. MY SON AND I WERE HEADING HOME AFTER A COLLEGE VISIT, HE TURNED ON HIS SEAT HEATER AND BEGAN TO NAP. 20 MINUTES LATER, HE POPPED UP RUBBING HIS SHOULDER, THE SEAT HEATER CAUSED THE SEAT TO CATCH FIRE AND BURNED A PORTION OF THE SEAT, HIS SHIRT AND SHOULDER. I CALLED THE DEALER AND WAS TOLD THEY'VE NEVER …
Read full complaint
I OWN A 2000 VW JETTA. MY SON AND I WERE HEADING HOME AFTER A COLLEGE VISIT, HE TURNED ON HIS SEAT HEATER AND BEGAN TO NAP. 20 MINUTES LATER, HE POPPED UP RUBBING HIS SHOULDER, THE SEAT HEATER CAUSED THE SEAT TO CATCH FIRE AND BURNED A PORTION OF THE SEAT, HIS SHIRT AND SHOULDER. I CALLED THE DEALER AND WAS TOLD THEY'VE NEVER HEARD OF THAT ISSUE AND THAT THERE HAS NEVER BEEN A RECALL FOR SUCH AN ISSUE. I THEN DID AN INTERNET SEARCH AND FOUND WHERE IT'S A VERY COMMON ISSUE. *TR
NHTSA ODI #10682887
41,000 miles · May 28, 2013
Seats
HEAT SEAT CONTROL AT 5 ONLY AVAILABLE. AFTER A NUMBER OF TIMES STARTED BURNING SEATS. LEATHER IS MELTED. NO LONGER USE. *TR
NHTSA ODI #10513956
110,839 miles · Nov 4, 2012
Seats
THE DRIVER SIDE SEAT NO LONGER STAYS IN A LOCKED POSITION, AND THE SEAT MOVES FREELY, SLIDING FROM BACK TO FRONT, MAKING CONTROL OVER THE VEHICLE'S PEDAL VERY DIFFICULT AND DRIVING HAZARDOUS. AFTER INSPECTING UNDERNEATH THE SEAT, A LARGE COILED PIECE OF METAL WAS FOUND LYING ON THE CARPET. THIS PIECE OF METAL MATCHES EXACTLY ANO…
Read full complaint
THE DRIVER SIDE SEAT NO LONGER STAYS IN A LOCKED POSITION, AND THE SEAT MOVES FREELY, SLIDING FROM BACK TO FRONT, MAKING CONTROL OVER THE VEHICLE'S PEDAL VERY DIFFICULT AND DRIVING HAZARDOUS. AFTER INSPECTING UNDERNEATH THE SEAT, A LARGE COILED PIECE OF METAL WAS FOUND LYING ON THE CARPET. THIS PIECE OF METAL MATCHES EXACTLY ANOTHER PIECE OF METAL THAT FELL OUT FROM THE BOTTOM OF THE PASSENGER SEAT OVER SIX YEARS AGO. I CONTACTED THE DEALER, (FRESNO MICHAEL AUDI VW) TO HAVE THEM REPLACE THE PART BACK INTO THE SEAT SO THAT THE SEAT NO LONGER MOVED FREELY AND THE SERVICE MANAGER REFUSED TO CARRY OUT ANY SUCH WORK ON MY VEHICLE. AFTER SPEAKING WITH TWO OTHER EMPLOYEES OF MICHAEL AUTOMOTIVE AND GETTING THE SAME REFUSALS EACH TIME, I ABANDONED THE ATTEMPT TO SOLICIT THEIR HELP IN REPAIRING MY VEHICLE. *TR
NHTSA ODI #10483322
160,000 miles · Apr 18, 2012
Seats
HAD THE CAR CLEANED AND WHEN I GOT THE CAR BACK THE SEAT ADJUSTMENT WOULD NO LONGER WORK. IT HASN'T WORKED SINCE. THE SEAT SLIDES FORWARD AND BACK AT WILL. *JS
NHTSA ODI #10455680
Mileage unknown · Dec 14, 2007
Seats
FOR TWO DAYS, I SMELLED AN ODOR SUCH AS A STARCHED IRON IN MY CAR. I TURNED THE HEATED SEATS OF FOR A FEW DAYS. TODAY I TURNED IT BACK ON AND THE SMELL CAME BACK. I TOOK MY JACKET OFF AND IN ONE PART OF THE SEAT, MY BACK WAS BURNING. THE DRIVERS HEATED SEAT IN MY 2000 VOLKSWAGEN JETTA BURNED THROUGH INTO THE EXTERIOR. THE HEATED…
Read full complaint
FOR TWO DAYS, I SMELLED AN ODOR SUCH AS A STARCHED IRON IN MY CAR. I TURNED THE HEATED SEATS OF FOR A FEW DAYS. TODAY I TURNED IT BACK ON AND THE SMELL CAME BACK. I TOOK MY JACKET OFF AND IN ONE PART OF THE SEAT, MY BACK WAS BURNING. THE DRIVERS HEATED SEAT IN MY 2000 VOLKSWAGEN JETTA BURNED THROUGH INTO THE EXTERIOR. THE HEATED SEAT CAUSED TWO HOLES IN MY SEAT AND A LARGE BROWN BURNT STAIN. IF I HAD NOT DISCOVERED THIS, THERE IS A POSSIBILITY IT WOULD CREATE MUCH MORE DAMAGE. *TR
NHTSA ODI #10211964
99,000 miles · Sep 17, 2007
Seats
DRIVING CAR, USING SEAT HEATER, STARTED SMELLING BURNING SMELL. WHEN I WAS ABLE TO STOP, THE LEATHER SEAT HAD BURNED. I AM NOT SURE WHAT WOULD HAVE OCCURRED IF I HAD NOT TURNED THE SEAT HEATER OFF WHEN I DID (FIRE, BURN ME). WENT TO DEALER TODAY, THEY SAID THAT THERE WAS NO RECALL FOR MY VEHICLE AND I WOULD HAVE TO REPAIR MY…
Read full complaint
DRIVING CAR, USING SEAT HEATER, STARTED SMELLING BURNING SMELL. WHEN I WAS ABLE TO STOP, THE LEATHER SEAT HAD BURNED. I AM NOT SURE WHAT WOULD HAVE OCCURRED IF I HAD NOT TURNED THE SEAT HEATER OFF WHEN I DID (FIRE, BURN ME). WENT TO DEALER TODAY, THEY SAID THAT THERE WAS NO RECALL FOR MY VEHICLE AND I WOULD HAVE TO REPAIR MYSELF. I FEEL THIS IS A SAFETY ISSUE, NOT A WEAR AND TEAR ISSUE AND VW OF AMERICA SHOULD REPLACE/REPAIR AT THEIR COST. *TR
NHTSA ODI #10203218
Mileage unknown · Aug 6, 2006
SeatsFireInjury
(2) THE SEAT WARMER ON THE DRIVER'S SEAT FAILED AND BURNED THROUGH THE SEAT COVERING. THE HEATER LEFT A BURN ON MY PANTS THE SIZE OF A DIME. THIS ALSO CAUSED ME SOME DISCOMFORT. (3) I CONTACTED VW OF AMERICA AND THEY INSTRUCTED ME THAT I WOULD HAVE TO BRING THE CAR IN AND HAVE IT FIXED AT MY EXPENSE. I OWN A 2000 VW JETTA. …
Read full complaint
(2) THE SEAT WARMER ON THE DRIVER'S SEAT FAILED AND BURNED THROUGH THE SEAT COVERING. THE HEATER LEFT A BURN ON MY PANTS THE SIZE OF A DIME. THIS ALSO CAUSED ME SOME DISCOMFORT. (3) I CONTACTED VW OF AMERICA AND THEY INSTRUCTED ME THAT I WOULD HAVE TO BRING THE CAR IN AND HAVE IT FIXED AT MY EXPENSE. I OWN A 2000 VW JETTA. *NM
NHTSA ODI #10164655
Mileage unknown · Feb 1, 2006
Seats
I STARTED NOTICING A BURNING SMELL IN THE CAR WHEN I TURNED ON THE HEATED SEATS AND THE DRIVERS SIDE SEAT WOULD GET VERY HOT, EVEN WHEN SET ON A LOW SETTING. ONE DAY I DECIDED TO TRY IT OUT TO SEE IF IT WAS WORKING PROPERLY OR NOT AND THE HEAT BURNT HOLES THROUGH THE MATERIAL COVERING THE SEAT . *JB
NHTSA ODI #10149170
Mileage unknown · Dec 18, 2005
SeatsFire
1) I'M NOT EXACTLY SURE WHEN THE INCIDENT OCCURRED, SEE #2 AND YOU WILL UNDERSTAND WHY. 2) TODAY I FOUND THAT THERE WAS SOME KIND OF SHORT CIRCUIT IN THE DRIVERS SIDE SEAT. IT LEFT A PEA-SIZED BURN IN THE UPHOLSTERY. LUCKILY, I USE A SMALL DRIVING PILLOW FOR MY LOWER BACK WHICH BORE THE BRUNT OF THE FIRE INSTEAD OF MY BUTT.…
Read full complaint
1) I'M NOT EXACTLY SURE WHEN THE INCIDENT OCCURRED, SEE #2 AND YOU WILL UNDERSTAND WHY. 2) TODAY I FOUND THAT THERE WAS SOME KIND OF SHORT CIRCUIT IN THE DRIVERS SIDE SEAT. IT LEFT A PEA-SIZED BURN IN THE UPHOLSTERY. LUCKILY, I USE A SMALL DRIVING PILLOW FOR MY LOWER BACK WHICH BORE THE BRUNT OF THE FIRE INSTEAD OF MY BUTT. I HAD FOUND THE PILLOW WAS STUCK TO THE SEAT, AND WHEN I PULLED IT OFF THE BURN WAS REVEALED. THE PILLOW WAS DAMAGED. 3) I HAVE DONE NOTHING TO CORRECT THE FAILURE AS OF YET. I AM RESEARCHING MY OPTIONS TO DETERMINE IF THE MANUFACTURER WILL REPLACE IT FOR ME. *NM
NHTSA ODI #10145557
Official recalls
4May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
Illustration