IllustrationWENT TO BUCKLE UP AND HEARD A NOISE. LOSS AT TENSION ON SEAT BELT.
2000 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2000 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
3925–50K
3850–75K
3375–100K
31100–150K
13150K+
180 reports with mileage · 259 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 121 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports14 fire reports24 injury reports
Seat Belts complaints
10 reports2000 VOLKSWAGEN JETTA I REARENDED A CAR AT 40 MPH MY FRONT BUMPER IS HANGING OFF AND SEATBELTS DID NOT WORK. VOLKSWAGEN WAS NOTIFIED AND IS HAVING A VW MEMBER LOOK AT THE CAR IN BELLIVILL AUTO SALVAGE 310 OAKHILL RD EXETER RI. DUE TO FAULTY AIR BAGS MY HEAD HIT WINDSHIELD AND CHEST HIT WHEEL DUE TO SEATBELTS. *TR
ENTERED MY 2000 VW JETTA GLS, WENT TO PUT THE SEAT BELT ON AND THE SEAT BELT WAS BROKEN. THE SEAT BELT DOES NOT RETRACT. THIS WAS WORKING FINE WHEN I HAD ENTERED THE VEHICLE 30 MINUTES BEFORE ON THE SAME DAY. IN READING THE MANUAL FOR MY VEHICLE IT STATED THAT THIS IS A THREE-POINT SAFETY BELT AND THAT THEY ARE EQUIPPED WITH …
Read full complaint
ENTERED MY 2000 VW JETTA GLS, WENT TO PUT THE SEAT BELT ON AND THE SEAT BELT WAS BROKEN. THE SEAT BELT DOES NOT RETRACT. THIS WAS WORKING FINE WHEN I HAD ENTERED THE VEHICLE 30 MINUTES BEFORE ON THE SAME DAY. IN READING THE MANUAL FOR MY VEHICLE IT STATED THAT THIS IS A THREE-POINT SAFETY BELT AND THAT THEY ARE EQUIPPED WITH BELT TENSIONERS. SENSORS ACTIVATE THE BELT TENSIONERS IN FRONTAL COLLISIONS. THIS TENSIONER CAN ONLY BE ACTIVATED ONCE AND THEN NEEDS TO BE REPLACED. MY VEHICLE HAS NEVER BEEN INVOLVED IN AN ACCIDENT BY ME OR ACCORDING TO THE CARFAX REPORT. UNLESS IT WASN'T REPORTED. THIS HAS NOT BEEN REPLACED AS IT WILL COST $300 TO REPLACE THIS PART. ONLY AUTHORIZED DEALERSHIPS CAN REPLACE THIS AS IT CANNOT BE REPAIRED WITHOUT USING SPECIAL PROCEDURES THAT ARE REQUIRED. THIS CAR IS TOO NEW TO BE HAVING A PROBLEM WITH AN IMPORTANT SAFETY DEVICE. *NM
HI, IT SEEMS AS IF MANY 2000+ VW JETTAS HAVE DEFECTIVE REAR CENTER SEAT BELTS. WHEN YOU FOLD DOWN THE REAR SEATS, THE CENTER SEAT BELTS WILL RETRACT IN SUCH A WAY THAT IT IS IMPOSSIBLE TO MOVE THE SEAT BACK TO THE UPRIGHT POSITION WITHOUT DISCONNECTING THE SEAT BELT. MANY PEOPLE, MYSELF INCLUDED, JUST PERMANENTLY DISCONNECT …
Read full complaint
HI, IT SEEMS AS IF MANY 2000+ VW JETTAS HAVE DEFECTIVE REAR CENTER SEAT BELTS. WHEN YOU FOLD DOWN THE REAR SEATS, THE CENTER SEAT BELTS WILL RETRACT IN SUCH A WAY THAT IT IS IMPOSSIBLE TO MOVE THE SEAT BACK TO THE UPRIGHT POSITION WITHOUT DISCONNECTING THE SEAT BELT. MANY PEOPLE, MYSELF INCLUDED, JUST PERMANENTLY DISCONNECT THE CENTER SEAT BELT TO AVOID SUCH PROBLEMS. I HAVE EXPERIENCED SEVERAL OTHER RECALLS THAT SEEMED LESS DANGEROUS THAN THIS PROBLEM COULD POTENTIALLY BE WITH 5 PEOPLE IN THE CAR. COULD YOU INVESTIGATE HOW FREQUENT THIS SAFETY ISSUE OCCURS AND POSSIBLY INITIATE A RECALL? I HAD THIS FIXED ONCE BEFORE, BUT APPARENTLY THE FIX DIDN'T LAST. THANKS, NEIL KUMPERS. *NM
I THOUGHT MY FIRST NEW CAR PURCHASE (A 2000 JETTA VR6 GLS) WAS A LEMON. I, LIKE MANY OTHERS, HAVE EXPERIENCED SEVERAL PROBLEMS. PROBLEMS SUCH AS: - REAR CUP HOLDERS BROKEN - MIDDLE/REAR SEATBELT LOCKED, CANNOT BE USED - 02 SENSORS BOTH REPLACED SINCE MIL LIGHT KEPT ILLUMINATING - MAS SENSOR REPLACED (AND LATER RECALLED) …
Read full complaint
I THOUGHT MY FIRST NEW CAR PURCHASE (A 2000 JETTA VR6 GLS) WAS A LEMON. I, LIKE MANY OTHERS, HAVE EXPERIENCED SEVERAL PROBLEMS. PROBLEMS SUCH AS: - REAR CUP HOLDERS BROKEN - MIDDLE/REAR SEATBELT LOCKED, CANNOT BE USED - 02 SENSORS BOTH REPLACED SINCE MIL LIGHT KEPT ILLUMINATING - MAS SENSOR REPLACED (AND LATER RECALLED) - BOTH FRONT WINDOWS HAVE FALLEN TO THE "BLACK HOLE" (AND LATER RECALLED; INCLUDING A RECALL TO THE RECALL B/C THEY WENT FROM METAL CLIPS TO PLASTIC OR VICE VERSA) - PAINT PEELING FROM INSIDE DOOR HANDLES - ALARM SYSTEM FAULTY ON PASSENGER SIDE DOOR (DEALER TOLD ME THAT UNLESS THE CAR BEEPS AT ME, THE ALARM IS NOT SECURED. SO, I MUST LOCK THE DOOR. STAND BY FOR 15 SECONDS, LOCK THE DOOR AGAIN AND THIS TIME WHEN THE CAR BEEPS, THE PASSENGER DOOR IS SECURED. AND, FURTHERMORE, (THIS IS GOOD - KEEP READING) I WAS TOLD THAT IF I DRIVE TOO CLOSE TO A JEA BUS, THEIR BUS COMPUTER SYSTEMS ARE RUN ON THE SAME CHANNEL AS MY JETTA'S COMPUTER SYSTEM AND SOMETIMES BEING TOO CLOSE TO A JEA BUS WILL CAUSE MY CARS COMPUTER SYSTEM TO SCRAMBLE). COMPUTER SYSTEM CAN BE RESET, AND DID YOU KNOW THAT WHILE RESETTING, VW CAN MAKE YOUR CAR BEEP IN DIFFERENT PATTERNS? THAT'S PROBABLY A "FEATURE"! - CENTER CONSOLE/ARMREST LATCH BROKEN - LARGE SPRING SITS UNDERNEATH MY PASSENGER SIDE FRONT SEAT - SEAT BELT NO LONGER CLICK, INDICATING LOCKED IN POSITION (DEALER TOLD ME IT STILL WORKS. SO, NOW I HAVE TO PUSH IT DOWN AND THEN TUG ON IT, HOPING THAT IT REALLY IS LOCKED -- IF NOT, I MAY FLY OUT THAT RECALLED WINDOW.) - CHILD RESTRAIN SEAT LOCKS RECALLED - TRUNK LOCK WOULDN'T STAY LATCHED - FRONT FENDER SEPARATING FROM BODY OF CAR - GRINDS GOING INTO SECOND GEAR (MANUAL TRANSMISSION) - WHEN CAR IS PUT INTO 1ST GEAR, IT WAITS A FEW SECOND BEFORE IT GETS ENOUGH POWER TO FULLY ACCELERATE - BRAKE DUST COVERS ALLOY WHEEL, IN JUST HOURS OF CLEANING DRIVERS WANTED...BUT THEY'RE ALL IN THE DEALER WAITING ROOM! *AK
REPLACED REAR BRAKE LIGHT 4 TIMES; EMERGENCY FLASHER & TURN SIGNALS FAIL TO WORK RANDOMLY. TWICE HAD REAR BRAKE PADS REPLACED; ROTORS TURNED SECOND TIME -- TOTAL COST $550. REPEATED SENSOR FAILURES -- KNOCK SENSOR, MASS AIR FLOW SENSOR, COOLANT TEMPERATURE SENSOR; INDUCTION COIL FAILURE & VEHICLE IMBOLIZED. DRIVER MIRROR REPAIRE…
Read full complaint
REPLACED REAR BRAKE LIGHT 4 TIMES; EMERGENCY FLASHER & TURN SIGNALS FAIL TO WORK RANDOMLY. TWICE HAD REAR BRAKE PADS REPLACED; ROTORS TURNED SECOND TIME -- TOTAL COST $550. REPEATED SENSOR FAILURES -- KNOCK SENSOR, MASS AIR FLOW SENSOR, COOLANT TEMPERATURE SENSOR; INDUCTION COIL FAILURE & VEHICLE IMBOLIZED. DRIVER MIRROR REPAIRED TWICE; PASSENGER P/WINDOW STUCK DOWN; DRIVER WINDOW LOCK TWICE; SEAT BELT CRACKED
SEAT BELT EQUIPMENT DID NOT WORK PROPERLY DURING AN ACCIDENT.*MR THE AIR BAGS FAILED TO DEPLOY WHEN THE CONSUMERS VEHICLE WAS HIT ON THE RIGHT PASSENGER SIDE. *PH *JB
SEATBELT WOULD NOT RELEASE TENSION; 6 YEAR OLD DAUGHTER WAS SITTING IN THE FRONT PASSENGER SEAT AND WAS TRAPPED IN THE SEATBELT. MY HUSBAND ATTEMPTED TO PULL THE SEATBELT TO GET RELEASE THE TENSION BUT IT WAS UNSUCCESSFUL. THIS ACTION JUST MADE THE SEATBELT TIGHTER. THE SEATBELT HAD TO FINALLY BE CUT OFF OF MY DAUGHTER. …
Read full complaint
SEATBELT WOULD NOT RELEASE TENSION; 6 YEAR OLD DAUGHTER WAS SITTING IN THE FRONT PASSENGER SEAT AND WAS TRAPPED IN THE SEATBELT. MY HUSBAND ATTEMPTED TO PULL THE SEATBELT TO GET RELEASE THE TENSION BUT IT WAS UNSUCCESSFUL. THIS ACTION JUST MADE THE SEATBELT TIGHTER. THE SEATBELT HAD TO FINALLY BE CUT OFF OF MY DAUGHTER. MR
WHILE DRIVING 55 MPH VEHICLE HAD A FRONTAL IMPACT WITH A STALLED VEHICLE, AND DRIVER'S/PASSENGER'S AIRBAGS DID NOT DEPLOY, WHICH DID NOT PROTECT THE OCCUPANT IN THIS CRASH. ALSO, THE SEATBELT DID NOT RETRACT, CAUSING DRIVER TO FLY INTO THE STEERING WHEEL AND SUSTAIN INJURIES. DEALER DID INSPECT THE VEHICLE, AND DETERMINED …
Read full complaint
WHILE DRIVING 55 MPH VEHICLE HAD A FRONTAL IMPACT WITH A STALLED VEHICLE, AND DRIVER'S/PASSENGER'S AIRBAGS DID NOT DEPLOY, WHICH DID NOT PROTECT THE OCCUPANT IN THIS CRASH. ALSO, THE SEATBELT DID NOT RETRACT, CAUSING DRIVER TO FLY INTO THE STEERING WHEEL AND SUSTAIN INJURIES. DEALER DID INSPECT THE VEHICLE, AND DETERMINED NO PROBLEM WITH AIRBAG SYSTEM AND SEATBELT. *AK
RT REAR AND LEFT REAR WINDOWS HAVE PINCH PROTECTION THAT ACTIVATE SOMETIMES WHEN THERE IS NOTHING IN THE WINDOW BLOKING IT AND I HAVE TO PUSH THE BUTTON 3 TIMES TO CLOSE IT AND AFTER THE SECOND TIME THE PINCH PROTECTION TURNS OFF. ...(2) THE RT FRONT SEAT BELT WILL NOT PULL DOWN ALL THE TIME IT FEELS LIKE IT IS LOCKED IN TH…
Read full complaint
RT REAR AND LEFT REAR WINDOWS HAVE PINCH PROTECTION THAT ACTIVATE SOMETIMES WHEN THERE IS NOTHING IN THE WINDOW BLOKING IT AND I HAVE TO PUSH THE BUTTON 3 TIMES TO CLOSE IT AND AFTER THE SECOND TIME THE PINCH PROTECTION TURNS OFF. ...(2) THE RT FRONT SEAT BELT WILL NOT PULL DOWN ALL THE TIME IT FEELS LIKE IT IS LOCKED IN THE POSITION YOU MUST PULL HARD SEVERAL TIMES TO GET IT TO WORK AND MOST OF THE TIME IT WON'T COME DOWN AT ALL. DRIVERS SIDE WORKS FINE, BUT PASS SIDE DOES NOT WORK AT ALL SOMETIMES. TOOK TO DEALER AND IT DIDN'T HAPPEN TO TE SERVICE WORKER BUT THE SERVICE ADVISOR COULD NOT GET IT TO PULL DOWN, SERVICE WORKER TOOK APART AND FOUND NOTHING WRONG, BUT IT DID NOT WORK FOR ME THAT NIGHT I GOT IT HOME.
Official recalls
406V183000 · Exterior Lighting:brake Lights:switch
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
04V584000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
04V096000 · Exterior Lighting:brake Lights:switch
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
02V244000 · Equipment:other:owners/service/other Manual
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.