NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
121 reportsClear category filter86,900 miles · Jan 29, 2009
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR MAINTENANCE WORK. WHILE IT WAS BEING TEST DRIVEN AT 30 MPH, THE ENGINE FAILED. THE MECHANIC STATED THAT A SEAL FAILED, WHICH ALLOWED THE ENGINE TO FAIL. THE CONTACT WAS UNAWARE OF WHICH SEAL WAS AFFECTED. THE DEALER REPAIRED THE VEHI…
Read full complaint
TL*THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR MAINTENANCE WORK. WHILE IT WAS BEING TEST DRIVEN AT 30 MPH, THE ENGINE FAILED. THE MECHANIC STATED THAT A SEAL FAILED, WHICH ALLOWED THE ENGINE TO FAIL. THE CONTACT WAS UNAWARE OF WHICH SEAL WAS AFFECTED. THE DEALER REPAIRED THE VEHICLE AND INSTALLED A NEW ENGINE. THE MECHANIC ALSO STATED THAT THEY WERE AWARE OF THE FAILURE DUE TO NUMEROUS OTHERS THAT HAVE EXPERIENCED THE SAME FAILURE. THE FAILURE MILEAGE WAS 86,900 AND CURRENT MILEAGE WAS 89,000. UPDATED 03/05/09 *CN THE ENGINE HAD 2 BROKEN RODS THE #3 AND #4 AND THERE WERE LARGE HOLES IN THE BLOCK. THE FAILURE WAS DUE TO HYDRAULIC LOCK OR A VOLUME OF OIL GETTING IN THE CYLINDER AND STOPPING THE PISTON. UPDATED 03/12/09. *JB
NHTSA ODI #10256832
102,000 miles · Nov 27, 2008
Electrical SystemEngine And Engine CoolingEquipment
I OWN A 2000 VOLKSWAGEN JETTA, THE CAR HAS HAD NUMEROUS PROBLEMS, I REALIZE THE CAR IS OLD AND WAS BOUGHT AS IS IT STILL SHOULD MAINTAIN TO PROPERLY RUN. IT HAS CAUSED A SAFETY HAZARD WHEN THE CARS WATER PUMP FAILED WHILE I WAS ON THE FREEWAY DOING 75MPH, IT STARTED TO STALL I WAS IN THE FAR LEFT LANE, I PULLED OVER THREW HEAVY …
Read full complaint
I OWN A 2000 VOLKSWAGEN JETTA, THE CAR HAS HAD NUMEROUS PROBLEMS, I REALIZE THE CAR IS OLD AND WAS BOUGHT AS IS IT STILL SHOULD MAINTAIN TO PROPERLY RUN. IT HAS CAUSED A SAFETY HAZARD WHEN THE CARS WATER PUMP FAILED WHILE I WAS ON THE FREEWAY DOING 75MPH, IT STARTED TO STALL I WAS IN THE FAR LEFT LANE, I PULLED OVER THREW HEAVY TRAFFIC, IT WAS A 1000 DOLLAR REPAIR, I HAVE RESEARCHED THE PROBLEM AND FOUND NUMEROUS COMPLAINTS ABOUT A FAILED WATER PUMP, ALSO, THE CAR STARTS AND REVS AT 2000 RPMS OR IT HAS TROUBLE STARTING, CHECK ENGINE LIGHT COMES ON FREQUENTLY AND CANT FIND THE PROBLEM, ENGINE MALFUNCTIONS ARE NUMEROUS, I FEEL I SHOULD HAVE SOME COMPENSATION FROM THE VW CORPORATION AND ALL THE OTHER OWNERS OF A VW OF THIS YEAR WITH THE SAME ISSUES. *TR
NHTSA ODI #10250024
107,000 miles · Nov 3, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. SINCE THE VEHICLE WAS PURCHASED IN APRIL OF 2008, IT STALLS AND SHUTS DOWN WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS. THE FAILURE CODE WAS LOCATED AT THE GAS THROTTLE POSITION SENSOR. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 107,000 AND CURRENT MILE…
Read full complaint
TL*THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. SINCE THE VEHICLE WAS PURCHASED IN APRIL OF 2008, IT STALLS AND SHUTS DOWN WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS. THE FAILURE CODE WAS LOCATED AT THE GAS THROTTLE POSITION SENSOR. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 107,000 AND CURRENT MILEAGE WAS 113,770.
NHTSA ODI #10247572
155,000 miles · Jul 15, 2008
Engine And Engine CoolingFire
MY 2000 VW JETTA WAS BEING DRIVEN TODAY BY MY FIANCE ON 295 SOUTH IN RHODE ISLAND. HE NOTICED THE COOLANT LIGHT COME ON, AND SO LOOKED AT THE TEMP GAUGE AND SAW THAT IT HAD NOT RISEN ANY HIGHER THAN NORMAL. AFTER KEEPING AN EYE ON THE GAUGE FOR A FEW MINUTES, HE NOTICED IT SUDDENLY DROP TO 0 AND SO HE PULLED OVER, FIGURING A H…
Read full complaint
MY 2000 VW JETTA WAS BEING DRIVEN TODAY BY MY FIANCE ON 295 SOUTH IN RHODE ISLAND. HE NOTICED THE COOLANT LIGHT COME ON, AND SO LOOKED AT THE TEMP GAUGE AND SAW THAT IT HAD NOT RISEN ANY HIGHER THAN NORMAL. AFTER KEEPING AN EYE ON THE GAUGE FOR A FEW MINUTES, HE NOTICED IT SUDDENLY DROP TO 0 AND SO HE PULLED OVER, FIGURING A HOSE HAD BROKEN OR SOMETHING TO THAT EXTENT. WHEN HE EXITED THE VEHICLE HE NOTICED SOME BLACK SMOKE COMING OUT FROM UNDER THE HOOD, AND THE HOOD ITSELF STARTING TO BUBBLE FROM THE HEAT. THE CAR ITSELF BURST INTO FLAMES AT THAT POINT AND MY FIANCE HAD TO BACK AWAY FROM IT IMMEDIATELY FOR FEAR THAT IT WOULD EXPLODE. THE CAR HAD RECENTLY BEEN INSPECTED AND WAS WORKING PERFECTLY FINE EXCEPT FOR A SMALL COOLANT LEAK UP UNTIL TODAY, SO WE HAVE NO IDEA WHAT CAUSED SUCH A SUDDEN COMBUSTION. NO ONE WAS HURT, THANKFULLY, BUT IT WAS ONLY A MATTER OF MINUTES BEFORE THE CAR WENT FROM OPERATING NORMALLY TO BEING COMPLETELY ENGULFED IN FLAMES, SO HE COULD VERY WELL HAVE BEEN HURT OR WORSE. THE FIRE DEPT AND STATE POLICE ARRIVED AND SECURED THE AREA, WHICH INCLUDED BLOCKING TRAFFIC COMPLETELY ON THE HIGHWAY FOR FEAR OF AN EXPLOSION, AND PUT OUT THE FIRE. THE CAR WAS COMPLETELY BURNED BEYOND RECOGNITION. *TR
NHTSA ODI #10234479
70,000 miles · Mar 7, 2008
Engine And Engine CoolingFire
MY SISTER WAS KILLED IN A FIRE CAUSED BY A 2000 VOLKSWAGEN JETTA. SHE FELL ASLEEP WITH THE CAR ON. THE CAR CAUGHT ON FIRE AND SHE WAS KILLED. THE INVESTIGATED ARE SAYING IT WAS A FAILURE OF THE EXHAUST SYSTEM. *TR
NHTSA ODI #10220390
87,000 miles · Oct 9, 2007
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. WHILE DRIVING 2-60 MPH, THE VEHICLE WOULD NOT ACCELERATE WHEN SHE DEPRESSED THE ACCELERATOR PEDAL. THE CONTACT HAD TO RELEASE THEN REAPPLY THE ACCELERATOR PEDAL. THE REPAIR SHOP STATED THAT THE EGR COOLER CLOGGED THE INTAKE MANIFOLD. THE INTAKE MANIFOLD WAS CLEARED. THE CONTACT D…
Read full complaint
TL*THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. WHILE DRIVING 2-60 MPH, THE VEHICLE WOULD NOT ACCELERATE WHEN SHE DEPRESSED THE ACCELERATOR PEDAL. THE CONTACT HAD TO RELEASE THEN REAPPLY THE ACCELERATOR PEDAL. THE REPAIR SHOP STATED THAT THE EGR COOLER CLOGGED THE INTAKE MANIFOLD. THE INTAKE MANIFOLD WAS CLEARED. THE CONTACT DROVE APPROXIMATELY TWENTY MILES, AND THEN NOTICED SMOKE COMING FROM UNDER THE HOOD. THE CONTACT TOOK THE VEHICLE BACK TO THE REPAIR SHOP AND THEY STATED THAT THE EGR LEAKED. THE FAILURE MILEAGE WAS 87,000 AND THE CURRENT MILEAGE WAS 92,000.
NHTSA ODI #10205231
Mileage unknown · Oct 3, 2007
Electrical SystemEngine And Engine CoolingPower Train
I PURCHASED A USED CERTIFIED 2000 VOLKSWAGEN JETTA IN JANUARY 2004, AFTER ONLY ONE WEEK OF PURCHASING THE VEHICLE, THE ENGINE LIGHT CAME ON, THE ACCELERATOR WAS MAKING A VIBRATING SOUND AND STALLING CONTINUOUSLY. OKAY, THE TRANSMISSION WENT OUT AND IT HAD TO BE REPLACED AT MY EXPENSE - I PURCHASED A USED TRANSMISSION AND THEN T…
Read full complaint
I PURCHASED A USED CERTIFIED 2000 VOLKSWAGEN JETTA IN JANUARY 2004, AFTER ONLY ONE WEEK OF PURCHASING THE VEHICLE, THE ENGINE LIGHT CAME ON, THE ACCELERATOR WAS MAKING A VIBRATING SOUND AND STALLING CONTINUOUSLY. OKAY, THE TRANSMISSION WENT OUT AND IT HAD TO BE REPLACED AT MY EXPENSE - I PURCHASED A USED TRANSMISSION AND THEN THE ENGINE THROTTLE FAILED AND THE CAR WOULDN'T EVEN START ONE DAY - HAD THAT REPLACED AT MY EXPENSE $1700. NO THE OLD PARTS ARE NOT AVAILABLE. OKAY, THERE'S MORE, THE BRAKES HAVE BEEN REPLACED A TOTAL OF FOUR TIMES WITHIN THREE YEARS, THE ENGINE LIGHT IS STILL ON, AIR BAG LIGHT ON, BRAKE LIGHT ON, LIGHTS AND FOG INTERIOR FUSES AND EXTERIOR LIGHTS HAVE BEEN REPLACED I DON'T KNOW HOW MANY TIMES, I HAVE PUT SO MUCH MONEY INTO THIS VEHICLE - AND IT STILL IS RUNNING BADLY. AS OF TODAY, THE CAR WON'T MOVE WITHOUT WARMING IT UP FIRST FOR ABOUT 45 MINUTES FULLY - WHEN YOU PRESS ON THE ACCELERATOR WITHOUT WARMING IT UP FIRST - IT WILL STALL AND MAKE A LOUD EMBARRASSING NOISE AS IF THE ENGINE IS GOING TO EXPLODE - AND YOU HAVE TO LITERALLY MAKE IT MOVE BY PRESSING VERY HARD ON THE ACCELERATOR AND PRAYING THAT IT WON'T JUST SHUT OFF WHILE DRIVING AND NEVER START AGAIN. MY VEHICLE HAS 117,000 MILES ON IT HAD 43,500 WHEN I BOUGHT IT (I KNOW STUPID WASN'T I) IT WAS MY FIRST VEHICLE. I KNOW A CAR IS NOT SUPPOSE TO LAST FOREVER, BUT DAM DOES IT HAVE TO COST SO MUCH TO TRY AND KEEP IT RUNNING UNTIL IT DIES. PLEASE HELP ME WITH ANY INFORMATION YOU MAY HAVE TO ASSIST ME IN THIS MATTER. *JB
NHTSA ODI #10204787
84,000 miles · Aug 24, 2007
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO SHAKE AND THEN SHUT OFF COMPLETELY. THE CHECK ENGINE WARNING INDICATOR LIGHT ILLUMINATED AND THE CONTACT SMELLED SMOKE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE COIL PACK FAILED. THE VEHICLE HAS NOT BEEN REPAIRED. THE…
Read full complaint
TL*THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO SHAKE AND THEN SHUT OFF COMPLETELY. THE CHECK ENGINE WARNING INDICATOR LIGHT ILLUMINATED AND THE CONTACT SMELLED SMOKE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE COIL PACK FAILED. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 84,000.
NHTSA ODI #10200710
142,414 miles · Aug 9, 2007
Engine And Engine Cooling
WHILE DRIVING AT 65 MPH ON A 2 LANE UNDIVIDED HI-WAY; ENGINE CUT OUT, WITHOUT WARNING OF ANY KIND (1.9 LITRE DIESEL-2000 JETTA) THIS OBVIOUSLY CAUSED AN UNSAFE SITUATION. VEHICLE WOULD TURN OVER BUT NOT START. DEALER REPAIRED BY REPLACING POWER RELAY FOR ENGINE CONTROL MODULE (RELAY 109). HAVE RESEARCHED THIS RELAY ON VARIOUS S…
Read full complaint
WHILE DRIVING AT 65 MPH ON A 2 LANE UNDIVIDED HI-WAY; ENGINE CUT OUT, WITHOUT WARNING OF ANY KIND (1.9 LITRE DIESEL-2000 JETTA) THIS OBVIOUSLY CAUSED AN UNSAFE SITUATION. VEHICLE WOULD TURN OVER BUT NOT START. DEALER REPAIRED BY REPLACING POWER RELAY FOR ENGINE CONTROL MODULE (RELAY 109). HAVE RESEARCHED THIS RELAY ON VARIOUS SITES, AND FOUND DOZENS OF FAILED RELAYS, SOME IN SIMILAR CIRCUMSTANCES. APPARENTLY, THE ORIGINAL BLACK RELAY FAILS, NEW RELAY IS A CHANGE UP (GREY IN COLOUR). *TR
NHTSA ODI #10199023
Mileage unknown · Jan 9, 2007
Engine And Engine CoolingFire
OWNER'S SON WAS DRIVING VOLKSWAGEN AND IT STARTED OVERHEATING. DURING THE COURSE OF THE EVENING, HE TRIED A FEW TIMES TO LET CAR COOL DOWN AND THEN CONTINUE DRIVING, BUT THE ENGINE WOULD CONTINUE TO OVERHEAT. HE MANAGED TO CONTINUE DRIVING AND NOTICED SMOKE COMING FROM THE BACK OF THE VOLKSWAGEN. HE SHUT THE ENGINE OFF AND COAST…
Read full complaint
OWNER'S SON WAS DRIVING VOLKSWAGEN AND IT STARTED OVERHEATING. DURING THE COURSE OF THE EVENING, HE TRIED A FEW TIMES TO LET CAR COOL DOWN AND THEN CONTINUE DRIVING, BUT THE ENGINE WOULD CONTINUE TO OVERHEAT. HE MANAGED TO CONTINUE DRIVING AND NOTICED SMOKE COMING FROM THE BACK OF THE VOLKSWAGEN. HE SHUT THE ENGINE OFF AND COASTED TO A STOP. HE GOT OUT AND NOTICED SPARKS DRIPPING FROM UNDERNEATH THE VEHICLE. THE VEHICLE BECAME ENGULFED IN FIRE. CAUSE UNDETERMINED, BUT SPARK PLUGS SHOWED EVIDENCE OF A RICH AIR/FUEL MIXTURE. *NM
NHTSA ODI #10178174
NHTSA investigations
6RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
Illustration