IllustrationRECALL 98V160000; WHILE DRIVING 70MPH, THE HOOD SNAPPED, FLEW UP INTO THE WINDSHIELD AND CRACKED THE WINDSHIELD, HOOD STAYED UP. WHEN ASSISTED FORCED THE HOOD BACK DOWN, RECALL NOTICE RECEIVED AFTER THE FACT, MANUFACTURER CONTACTED AND NO RESPONSE BACK AS OF YET. *AK
1994 Volkswagen Jetta
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Volkswagen Jetta do not stand out strongly from the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 117 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Equipment. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports5 fire reports7 injury reports
What owners actually said
117 reportsON TH LEFT SIDE ON THE DRIVER'S SEAT, NEAR THE BACKREST ADJUSTER KNOW, THE WELD THAT CONNECTS THE MAIN LEFT SIDE SUPPORT OF THE SEAT BACK TO THE SEAT'S BOTTOM COMPLETELY SHEARED OFF WITH NO ABNORMAL USE OR IMPACT.
MASS OIL FLOW METER FAILED. DEALER STATED THAT TOO MUCH OIL WAS ADDED DURING THE LAST OIL CHANGE.
AIR CONDITIONING FAILED AT 24000 MILES. FOUND NO LEAKS AND THE SYSTEM WAS RECHARGED. SIX MONTHS LATER IT FAILED AGAIN.
SUNROOF ASSEMBLY FAILS TO OPERATE. IT WILL NOT OPEN OR CLOSE DUE TO MISALIGNMENT OR IMPROPER TRACKS. IT ALWAYS MAKES A CLICKING OR POPPING SOUND WHEN OPEN OR CLOSE.
IN COLD CLIMATE THE POWER DOOR LOCKS MALFUNCTED, CAUSING THE LOCKS TO BE IN A "LOCKED POSTION," AND WON'T BE ABLE TO GET OUT OF THE VEHICLE. TOOK DEALER 3 TIMES, DEALER CANNOT DETERMINE PROBLEM. *AK
VEHICLE HESITATES/STALLS AND SHUTS DOWN WITHOUT ANY WARNING WHILE DRIVING AT ANY SPEED. *AK
THE DRIVER'S SIDE SEAT BROKE WHILE DRIVING DOWN THE ROAD, CAUSING THE SEAT TO GO BACKWARDS. THE METAL FRAME THAT HOLDS THE SEAT TOGETHER HAD BROKEN. *AK
VEHICLE HESITATES AND THEN COMPLETELY SHUTS DOWN, WITHOUT WARNING, AT ANY SPEED AND UNDER ANY CONDITIONS. VEHICLE ALWAYS RESTARTS.
WHILE DRIVING AT ANY SPPED, VEHICLE HESITATES AND THEN SHUTS DOWN WITHOUT ANY WARNING. VEHICLE HAS TO BE RESTARTED TO REGAIN POWER.
Official recalls
598V195000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Aug 17, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR BRAKE LINE ON THE PASSENGER SIDE WAS ROUTED TOO CLOSE TO THE CORNER OF THE FUEL TANK. THE LINE COULD BE DAMAGED BY CHAFING AGAINST THE FUEL TANK.
Consequence & remedy
Consequence: REPEATED CHAFING COULD EVENTUALLY RESULT IN A LEAKING BRAKE LINE CAUSING DIMINISHED BRAKING IN ONE BRAKE CIRCUIT INCREASING THE VEHICLE'S STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE LINE AND REPLACE ANY DAMAGED LINES.
98V160000 · Latches/locks/linkages:hood:latch
Jul 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BOLTS SECURING THE FRONT HOOD LATCH CAN LOOSEN OVER TIME. THE LATCH WOULD MOVE CAUSING DISENGAGEMENT OF THE HOOD STRIKER FROM THE LATCH.
Consequence & remedy
Consequence: UNEXPECTED OPENING OF THE HOOD COULD OCCUR OBSTRUCTING THE DRIVER'S VIEW OF THE ROAD WHILE DRIVING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE HOOD LATCH AND SECURING BOLTS AND REPLACE THEM IF NECESSARY.
96V128000 · Visibility:power Window Devices And Controls
Jul 8, 1996
THE SHEET METAL PANELS OF BOTH REAR DOORS HAVE OPENINGS FOR THE ROUTING OF THE ELECTRICAL WINDOW REGULATOR WIRING. THE PANEL OPENINGS HAVE SHARP EDGES THAT CAN DAMAGE THE INSULATION OF THE WIRING HARNESS.
Consequence & remedy
Consequence: AN ELECTRICAL SHORT IN THE WIRING CAN OCCUR RESULTING IN A POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL A PROTECTIVE EDGE COVER IN BOTH REAR DOOR INNER PANEL OPENINGS.
95V178000 · Engine And Engine Cooling:cooling System:fan
Sep 20, 1995
IMPROPER MATERIAL WAS USED IN MANUFACTURING THE RADIATOR FAN MOTOR SHAFT CAUSING THE SHAFT TO WEAR AND BECOME NOISY.
Consequence & remedy
Consequence: A WORN AND NOISY FAN MOTOR SHAFT CAN SEIZE RENDERINGTHE FAN MOTOR INOPERATIVE, EVENTUALLY CAUSING THE ENGINE TO OVERHEAT AND STALL. A STALLED VEHICLE IN TRAFFIC CAN INCREASE THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE COMPLETE COOLING FAN ASSEMBLY ON VEHICLE HAVING THE POTENTIAL SHAFT MATERIAL PROBLEM. DEALERS WILL INSTALL A NEW FAN BLADE INCLUDING A NEW LOCK NUT ON VEHICLE WITH LOOSE FAN BLADE LOCK NUTS.
95V054000 · Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift; Equipment:mechanical:integrated Jack/leveler/stabilizer
Mar 13, 1995
THE JACKS SUPPLIED WITH THESE VEHICLES WERE ASSEMBLED WITH AN IMPROPERLY MACHINED SPINDLE, SO THAT A SHARP RIDGE ON THE EDGE OF SPINDLE'S THREAD WOULD HAVE REMAINED.
Consequence & remedy
Consequence: THIS RIDGE CAN DAMAGE THE INSIDE THREAD OF THE JACK'S SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING CLOSE TO THE VEHICLE COULD BE INJURED.
Remedy: OWNERS WILL BE PROVIDED WITH A NEW JACK.
Additional source detail variants (2)
Equipment:mechanical:integrated Jack/leveler/stabilizer
THE JACKS SUPPLIED WITH THESE VEHICLES WERE ASSEMBLED WITH AN IMPROPERLY MACHINED SPINDLE, SO THAT A SHARP RIDGE ON THE EDGE OF SPINDLE'S THREAD WOULD HAVE REMAINED.
Consequence: THIS RIDGE CAN DAMAGE THE INSIDE THREAD OF THE JACK'S SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING CLOSE TO THE VEHICLE COULD BE INJURED.
Remedy: OWNERS WILL BE PROVIDED WITH A NEW JACK.
Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
THE JACKS SUPPLIED WITH THESE VEHICLES WERE ASSEMBLED WITH AN IMPROPERLY MACHINED SPINDLE, SO THAT A SHARP RIDGE ON THE EDGE OF SPINDLE'S THREAD WOULD HAVE REMAINED.
Consequence: THIS RIDGE CAN DAMAGE THE INSIDE THREAD OF THE JACK'S SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING CLOSE TO THE VEHICLE COULD BE INJURED.
Remedy: OWNERS WILL BE PROVIDED WITH A NEW JACK.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.