NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
332 reportsMileage unknown · Sep 28, 2023
Electrical System
There is a warning that repeatedly comes on while driving: " Warnings and information not available. Drive with greater care!" While this warning light is on I am unable to see my speed, the time, and miles driven. The temperature gage turns to Celsius, the touchscreen works sporadically and the rear camera does not work at all.…
Read full complaint
There is a warning that repeatedly comes on while driving: " Warnings and information not available. Drive with greater care!" While this warning light is on I am unable to see my speed, the time, and miles driven. The temperature gage turns to Celsius, the touchscreen works sporadically and the rear camera does not work at all. The only information that I have been given is to turn the car off and let it sit for 5 minutes. After doing that the warning will come on for about 15 min, turn off for a few minutes and then turn on again.
NHTSA ODI #11547148
Mileage unknown · Sep 27, 2023
Electrical SystemStructure
The contact owns a 2021 Volkswagen ID.4. The contact received notification of NHTSA Campaign Numbers: 23V040000 (Electrical System) and 23V312000 (Structure) however, the parts to do the recall repairs were not yet available. The local dealer was contacted and determined that the parts were not yet available. The contact stated …
Read full complaint
The contact owns a 2021 Volkswagen ID.4. The contact received notification of NHTSA Campaign Numbers: 23V040000 (Electrical System) and 23V312000 (Structure) however, the parts to do the recall repairs were not yet available. The local dealer was contacted and determined that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11546906
Mileage unknown · Sep 25, 2023
Electrical SystemStructure
The contact owns a 2021 Volkswagen ID4. The contact received notification of NHTSA Campaign Numbers: 23V312000 (Structure) and 23V040000 (Electric System) however, the part to do the recall repairs was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of …
Read full complaint
The contact owns a 2021 Volkswagen ID4. The contact received notification of NHTSA Campaign Numbers: 23V312000 (Structure) and 23V040000 (Electric System) however, the part to do the recall repairs was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11546443
Mileage unknown · Sep 25, 2023
Lane DepartureSteering
I have had two episodes in which the Lane Keeping Assistance put me at risk of running into a barrier on the freeway. Both happened when traveling in a middle freeway lane that split to an off-ramp (three lanes splitting to two groups of two lanes). In the first, I was taking the left ramp. The car, I think wanting to keep the …
Read full complaint
I have had two episodes in which the Lane Keeping Assistance put me at risk of running into a barrier on the freeway. Both happened when traveling in a middle freeway lane that split to an off-ramp (three lanes splitting to two groups of two lanes). In the first, I was taking the left ramp. The car, I think wanting to keep the lane line on my right close, suddenly steered me back to the right and toward the dividing barrier. I was able to overcome it and stay on my planned route but it was close. In the second, there was a car to my right in the right-most lane. I was taking the right exit and used my turn signal to indicate this. As I started to take the exit, turning the wheel to the right, the car forced the wheel back to straight because it thought I was trying to steer into the car to my right (in the next lane, also exiting), and again steered me toward the barrier splitting the ramp from the freeway. I was able to overcome the wheel, but again it was close. In both cases, I think the car is doing what it is designed to do (i.e. nothing is broken) but the design is dangerous. I have talked to the dealer about this problem - they have acknowledged the issue and said a new car would not have this problem. No warning lamps or messages appeared.
NHTSA ODI #11546345
Mileage unknown · Sep 23, 2023
Electrical System
I am writing because VW has been unable to fix the recalls associated with my car. The earliest they say they can fix the major recall associated with the car battery is December 2024. This is unacceptable and I hoping the NHTSA can put pressure on VW to fix this problem.
NHTSA ODI #11546191
Mileage unknown · Sep 21, 2023
Unknown Or Other
Volkswagen cannot address my recall 93P7. I have called multiple dealerships and the battery cannot be addressed.
NHTSA ODI #11545813
Mileage unknown · Sep 15, 2023
Fuel/propulsion System
My VW id4 2021 has been recalled for High Voltage battery issues. My local dealer, FLOW vw of Asheville NC cannot perform the work as they do not have a certified technician. The closest tech I can find is in Bristol TN. VW will only tow my car to the closest dealer, FLOW in Asheville. Should VW be responsible to get my car to a…
Read full complaint
My VW id4 2021 has been recalled for High Voltage battery issues. My local dealer, FLOW vw of Asheville NC cannot perform the work as they do not have a certified technician. The closest tech I can find is in Bristol TN. VW will only tow my car to the closest dealer, FLOW in Asheville. Should VW be responsible to get my car to a dealer that can perform this work? How can we make this happen? Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11544700
Mileage unknown · Sep 12, 2023
Forward Collision AvoidanceService Brakes
While traveling at highway speeds I suddenly got multiple warnings of the parking brake becoming inoperative, Auto Hold Error, and Travel Assist and Cruise Control no longer available. When trying to park the vehicle's parking brake would not engage and a loud warning sound and red warning message with "Do not park vehicle on an…
Read full complaint
While traveling at highway speeds I suddenly got multiple warnings of the parking brake becoming inoperative, Auto Hold Error, and Travel Assist and Cruise Control no longer available. When trying to park the vehicle's parking brake would not engage and a loud warning sound and red warning message with "Do not park vehicle on an incline" came up on the dash. The vehicle was not able to be parked on any surface without it potentially rolling away. When trying to take the car into the dealership on Monday, 9/11/2023 the vehicle would not move out of "Park" and had be dragged out of the garage it was parked in.
NHTSA ODI #11544099
Mileage unknown · Sep 6, 2023
Structure
The contact owns a 2021 Volkswagen ID.4. The contact received notification of NHTSA Campaign Number: 23V312000 (Structure) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the …
Read full complaint
The contact owns a 2021 Volkswagen ID.4. The contact received notification of NHTSA Campaign Number: 23V312000 (Structure) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11542927
22,000 miles · Sep 5, 2023
Electrical SystemInjury
The contact owns a 2021 Volkswagen ID.4. The contact stated that while his wife was opening the driver's side rear door, she was shocked by an electrical discharge. The contact stated that his wife's hand hurt for several days, however she was not burned by the discharge. The contact had not taken the vehicle to a local dealer o…
Read full complaint
The contact owns a 2021 Volkswagen ID.4. The contact stated that while his wife was opening the driver's side rear door, she was shocked by an electrical discharge. The contact stated that his wife's hand hurt for several days, however she was not burned by the discharge. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 22,000.
NHTSA ODI #11542780
Official recalls
11Feb 27, 2025
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2023 ID.4, 2022-2023 Audi Q4 e-Tron, and Q4 e-Tron Sportback vehicles. The instrument panel may not properly display the transmission gear lever indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence & remedy
Consequence: Failure to display the gear position may result in a vehicle rollaway if the parking brake is not engaged, increasing the risk of a crash.
Remedy: Dealers will update the brake control unit software, free of charge. Owner notification letters were mailed March 14, 2025. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 97H3. Audi's number for this recall is 454R.
Additional source detail variants (2)
Power Train:automatic Transmission:gear Position Indication (prndl)
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2023 ID.4, 2022-2023 Audi Q4 e-Tron, and Q4 e-Tron Sportback vehicles. The instrument panel may not properly display the transmission gear lever indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence: Failure to display the gear position may result in a vehicle rollaway if the parking brake is not engaged, increasing the risk of a crash.
Remedy: Dealers will update the brake control unit software, free of charge. Owner notification letters were mailed March 14, 2025. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 97H3. Audi's number for this recall is 454R.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2023 ID.4, 2022-2023 Audi Q4 e-Tron, and Q4 e-Tron Sportback vehicles. The instrument panel may not properly display the transmission gear lever indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence: Failure to display the gear position may result in a vehicle rollaway if the parking brake is not engaged, increasing the risk of a crash.
Remedy: Dealers will update the brake control unit software, free of charge. Owner notification letters were mailed March 14, 2025. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 97H3. Audi's number for this recall is 454R.
Sep 4, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2024 ID.4 vehicles. The door handles may allow water to enter the circuit board assembly, which can cause the doors to open unexpectedly.
Consequence & remedy
Consequence: A vehicle door that opens unexpectedly while driving increases the risk of injury.
Remedy: Volkswagen dealers will inspect and replace the door handles as necessary, and update the vehicle software, free of charge. Owner notification letters were mailed on December 27, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 57J9. This recall expands previous recall numbers 23V-312 and 23V-213. Vehicles previously repaired under 23V-312 and 23V-213 will need to have the new remedy completed.
May 15, 2024
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence & remedy
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
Additional source detail variants (3)
Equipment:electrical:infotainment:software
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
Back Over Prevention:software
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
Electrical System:instrument Panel:speedometer/odometer
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
May 3, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2022 ID.4 vehicles. The affected vehicles may have been manufactured with door handles that allow water to enter the circuit board assembly, which can cause the doors to open unexpectedly when the vehicle is subject to high lateral forces at speeds below 9 mph/15 kmh.
Consequence & remedy
Consequence: A vehicle door that opens unexpectedly while the vehicle is in motion increases the risk of injury.
Remedy: Dealers will update the vehicle software, and inspect the door handles as necessary, free of charge. Owner notification letters were mailed March 19, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall are 57J5 and 57J8. This recall was replaced by recall number 24V-651
Feb 1, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID.4 vehicles. Software programing may cause the high voltage (HV) battery management control module to restart or the pulse inverter to deactivate.
Consequence & remedy
Consequence: A reset or deactivation may cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the HV battery management control unit and the pulse inverter control unit software, free of charge. Owner notification letters are expected to be mailed March 31, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 97ZZ.
Nov 2, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID4 vehicles. The passenger air bag may be incorrectly folded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An incorrectly folded air bag may not protect the occupant as intended during a crash, increasing the risk of injury.
Remedy: Volkswagen will replace the passenger air bag module, free of charge. Owner notification letters were mailed February 14, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number to this recall is 69EH.
Mar 16, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID4 vehicles. Incorrect soldering of the flexible printed circuit assembled (FPCA), inside the high voltage (HV) battery, may cause an unreliable connection.
Consequence & remedy
Consequence: An unreliable battery connection may cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the battery cell modules, free of charge. Owner notification letters were mailed December 6, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 9302.
Nov 3, 2021
Volkswagen Group of American, Inc. (Volkswagen) is recalling one 2021 ID.4 vehicle. The steering gear may have an incorrectly assembled or missing drive bushing.
Consequence & remedy
Consequence: An incorrectly assembled or missing drive bushing may cause a loss of steering control, increasing the risk of a crash.
Remedy: A dealer will replace the steering gear, free of charge. Owner notification letters were mailed November 5, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 48Q7.
Aug 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen ID4, Audi A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A5 Sportback, A6 Allroad, A6 Sedan, A7, A8, E-Tron Quattro, E-Tron Sportback Quattro, Q3, Q5, Q5 Sportback, Q7, Q8, RS5 Sportback, RS5 Coupe, RS6 Avant, RS7, RSQ8, S4 Sedan, S5 Cabriolet, S5 Coupe, S5 Sportback, S6 Sedan, S7, S8, SQ5, SQ5 Sportback, SQ7, SQ8, and 2021-2022 S3 Sedan vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the middle-rear seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69CR (VW) and 69CS (Audi).
Additional source detail variants (2)
Seat Belts:rear/other:retractor
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen ID4, Audi A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A5 Sportback, A6 Allroad, A6 Sedan, A7, A8, E-Tron Quattro, E-Tron Sportback Quattro, Q3, Q5, Q5 Sportback, Q7, Q8, RS5 Sportback, RS5 Coupe, RS6 Avant, RS7, RSQ8, S4 Sedan, S5 Cabriolet, S5 Coupe, S5 Sportback, S6 Sedan, S7, S8, SQ5, SQ5 Sportback, SQ7, SQ8, and 2021-2022 S3 Sedan vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the middle-rear seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69CR (VW) and 69CS (Audi).
Seat Belts
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen ID4, Audi A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A5 Sportback, A6 Allroad, A6 Sedan, A7, A8, E-Tron Quattro, E-Tron Sportback Quattro, Q3, Q5, Q5 Sportback, Q7, Q8, RS5 Sportback, RS5 Coupe, RS6 Avant, RS7, RSQ8, S4 Sedan, S5 Cabriolet, S5 Coupe, S5 Sportback, S6 Sedan, S7, S8, SQ5, SQ5 Sportback, SQ7, SQ8, and 2021-2022 S3 Sedan vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the middle-rear seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69CR (VW) and 69CS (Audi).
Aug 4, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID4 vehicles. Incorrect rear outboard seat belt assemblies without an automatic locking retractor (ALR) function may have been installed, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the rear outboard seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69CQ.
Additional source detail variants (2)
Seat Belts:rear/other:retractor
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID4 vehicles. Incorrect rear outboard seat belt assemblies without an automatic locking retractor (ALR) function may have been installed, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the rear outboard seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69CQ.
Seat Belts
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID4 vehicles. Incorrect rear outboard seat belt assemblies without an automatic locking retractor (ALR) function may have been installed, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the rear outboard seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69CQ.
Jun 2, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID.4 vehicles. Caps were installed on the headlight vertical aim instead of the horizontal aim, allowing for horizontal adjustment of the headlight beam. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Adjusting the horizontal headlight beam can increase glare, reducing visibility for the driver and increasing the risk of a crash.
Remedy: Dealers will remove the caps from the vertical aim and install them on the horizontal aim, free of charge. Owner notification letters were mailed June 18, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 9406.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ24010 · Inadvertent Door Opening
Opened May 16, 2024 · Closed Nov 4, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
On May 16, 2024, the Office of Defects Investigations (ODI) opened Recall Query (RQ) RQ24010 to investigate the remedy and scope of recalls 23V-213 and 23V-312. The affected vehicles by these recalls included model years (MY) 2021 through 2023 Volkswagen ID.4 vehicles. ODI received reports of the vehicle’s doors opening while the vehicle was in motion post recall remedy. ODI, also, received similar allegations on vehicles that were outside the scope of the recalls. Volkswagen issued recall 23V-213 on March 29, 2023, and recall 23V-213 on May 03, 2023. These recalls addressed the defect of water ingress into the circuit board assembly of the door handle. Water ingress can cause communication issues between the door handle and the door control until. This malfunction resulted in the vehicle door inadvertently opening while the vehicle was in motion. Over the course of the investigation, ODI received 17 unique VIN VOQ complaints of the vehicle doors opening while the vehicle was in motion occurring either post recall remedy or on a vehicle that was outside the recall scope. Volkswagen submitted 190 unique VIN complaints reporting the same circumstances. On September 4, 2024, Volkswagen submitted recall 24V-651 to address the issue of inadvertent opening of the door while the vehicle is in motion. The scope of this recall expands the affected vehicles to include all MY2021-2024 Volkswagen ID.4 models, including those remedied under the subject recalls. The recall remedy consists of replacement of the door handle assembly on all four doors as well as a software update. The software update is performed to update the door handle parameters. The new door handle will have the membrane relocated to the back of the handle to avoid standing water within the handle. Also, a protective coating will be on the front and back of the circuit board to avoid direct moisture formation. In view of the action being taken by Volkswagen, Recall 24V-651, ODI is closing this Recall Query. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration