NHTSA owner reports · September 18, 2026 snapshot.
Tires complaints
8 reportsClear category filterMileage unknown · Aug 18, 2025
Tires
235/50/20 104T MFD: 0223 & 5022 (both on the front) Driven less than 15,000 miles so far. Started having this issue around 10k miles. Will have to swap soon before a major accident occurs due to tire failure and checking almost all the boxes that are below. I have no words to describe and neither does the firestone employee. I …
Read full complaint
235/50/20 104T MFD: 0223 & 5022 (both on the front) Driven less than 15,000 miles so far. Started having this issue around 10k miles. Will have to swap soon before a major accident occurs due to tire failure and checking almost all the boxes that are below. I have no words to describe and neither does the firestone employee. I am attaching pictures. Chunks of tread are coming off from all around the tire. Inside, outside, 360 degree. In the picture you'll see how much tread there is and see how deep the chunks are. This is a major safety issue. I have 2 other tires same model but from 2024 MFD without issue. Please contact ASAP about this at [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11681302
Mileage unknown · Jun 8, 2025
Tires
In Sept. 2024 we noticed that the edges of both front tires (Alenza 235/50 R20) had pieces coming off them so we arranged to have the tires replaced at the original dealer from which we had bought the car. They agreed that the tires were failing and replaced them. At that point the tires had only done 11827 miles so I asked if a…
Read full complaint
In Sept. 2024 we noticed that the edges of both front tires (Alenza 235/50 R20) had pieces coming off them so we arranged to have the tires replaced at the original dealer from which we had bought the car. They agreed that the tires were failing and replaced them. At that point the tires had only done 11827 miles so I asked if a warranty was applicable that would allow me to get back some of the replacement cost for the two tires. The dealer (Hazelwood Volkswagen of Bremerton, WA) said they would make inquiries and I paid the full price in the meantime. Despite numerous follow up inquiries, as well as contact with both VW USA and Bridgestone, I have not received any response. The suggestion seems to be that original equipment supplied with a new car are not covered by any warranty. After the tires were replaced I turned off the lane assist feature on the vehicle as this often seemed overly active due to random road markings. So far we have put about 3500 miles on the new tires and they seem fine. I have pieces that chipped off the old tires, and the dealer said they would hold the old tires pending a warranty response but that was in September 2024.
NHTSA ODI #11665648
22,000 miles · May 15, 2024
Service BrakesTires
The contact owns a 2021 Volkswagen ID.4. The contact stated while parking the vehicle, there was an abnormal odor of smoke coming from the rear of the vehicle. Upon inspection, it was determined that the smoke and burning odor were coming from the rear passenger’s side wheel well. The vehicle was driven to the local dealer who s…
Read full complaint
The contact owns a 2021 Volkswagen ID.4. The contact stated while parking the vehicle, there was an abnormal odor of smoke coming from the rear of the vehicle. Upon inspection, it was determined that the smoke and burning odor were coming from the rear passenger’s side wheel well. The vehicle was driven to the local dealer who stated that the rear passenger’s side drum brake was faulty. The cause of the failure was not yet determined. The manufacturer was not contacted. The contact stated that earlier while driving the "low tire pressure" warning had been displayed. The failure mileage was 22,000.
NHTSA ODI #11588929
Mileage unknown · Dec 16, 2023
Tires
The front tires have excessive wear with treads appear to be peeling. 235/50/20 Please note both front tires have this issue but is worse on passenger side.
NHTSA ODI #11560471
20,000 miles · Jul 12, 2023
Tires
The contact owns a 2021 Volkswagen ID4 equip with Bridgestone Alenza tires size 255/55/R19 DOT 2761004ES. The contact stated that while driving approximately 65 MPH the rear passenger side tire suddenly experienced a blowout. Upon inspection the tires sidewall had separated from the tire. The cause of the failure was not determi…
Read full complaint
The contact owns a 2021 Volkswagen ID4 equip with Bridgestone Alenza tires size 255/55/R19 DOT 2761004ES. The contact stated that while driving approximately 65 MPH the rear passenger side tire suddenly experienced a blowout. Upon inspection the tires sidewall had separated from the tire. The cause of the failure was not determined. The manufacturer and local dealer were not notified. The failure mileage was 20,000.
NHTSA ODI #11531781
20,000 miles · Jul 12, 2023
Tires
The contact owns a 2021 Volkswagen ID.4 equipped with Bridgestone Tires, Tire Line: Alenza, Tire Size: 235/55/R19, DOT Number: 2761004ES. The contact stated that while driving approximately 40 MPH, the contact experienced a front driver’s side tire blowout. Upon inspection, the sidewall of the tire had separated. The cause of th…
Read full complaint
The contact owns a 2021 Volkswagen ID.4 equipped with Bridgestone Tires, Tire Line: Alenza, Tire Size: 235/55/R19, DOT Number: 2761004ES. The contact stated that while driving approximately 40 MPH, the contact experienced a front driver’s side tire blowout. Upon inspection, the sidewall of the tire had separated. The cause of the failure was not yet determined. The manufacturer and local dealer were not notified of the failure. The failure mileage was 20,000.
NHTSA ODI #11531767
Mileage unknown · Jun 13, 2023
Tires
I have purchased a set of Bridgestone Alenza AS Ultra (P 235 / 55 R 19 105 W XL front, P 255 / 50 R 19 107 W XL back) in August 2022 for my 2021 Volkswagen ID.4 Pro S RWD EV. After only 12,000 miles, tire dry rot started showing up in June 2023 on all tires. The tires have a 80,000 miles warranty so I don't know how come they s…
Read full complaint
I have purchased a set of Bridgestone Alenza AS Ultra (P 235 / 55 R 19 105 W XL front, P 255 / 50 R 19 107 W XL back) in August 2022 for my 2021 Volkswagen ID.4 Pro S RWD EV. After only 12,000 miles, tire dry rot started showing up in June 2023 on all tires. The tires have a 80,000 miles warranty so I don't know how come they started to dry rot only after 12,000 miles. If the tires fail while driving, this can be a severe safety hazard as the vehicle may lose control shall the tires fail.
NHTSA ODI #11526866
Mileage unknown · Aug 15, 2022
Tires
Brand new, Volkswagen, ID4, 2021, We were lucky twice that this catastrophic tire failure did not result in an accident. First blow out was on a quiet side road in RI. Second was air leak on the highway that caused me to see a close by dealer about the issue. All 4 tires prematurely wore to the steel belts on the inside of …
Read full complaint
Brand new, Volkswagen, ID4, 2021, We were lucky twice that this catastrophic tire failure did not result in an accident. First blow out was on a quiet side road in RI. Second was air leak on the highway that caused me to see a close by dealer about the issue. All 4 tires prematurely wore to the steel belts on the inside of the tire, the left rear sidewall blew out first at 33,675, Balise VW Warwick, RI did not recognize that it was a tread issue and 4 weeks later, the other 3 were deemed a road hazard by the Mastria VW Raynham, MA where we were stranded. The right rear leaked air due to the tread wearing thin to the steel belt on the inside of the tire. The right rear and two front were replaced at 37,526 mile for the same thin tread issue. Volkswagen and Bridgestone take no responsibility for this unusual tire wear. There needs to be a warning that these tires are dangerous after 30,000 miles on an ID4. I think as these SUVs get older, more reports will materialize. The tire does not support this type of vehicle due to the weight of the battery. This is a safety issue.
NHTSA ODI #11479393
Official recalls
11Feb 27, 2025
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2023 ID.4, 2022-2023 Audi Q4 e-Tron, and Q4 e-Tron Sportback vehicles. The instrument panel may not properly display the transmission gear lever indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence & remedy
Consequence: Failure to display the gear position may result in a vehicle rollaway if the parking brake is not engaged, increasing the risk of a crash.
Remedy: Dealers will update the brake control unit software, free of charge. Owner notification letters were mailed March 14, 2025. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 97H3. Audi's number for this recall is 454R.
Additional source detail variants (2)
Power Train:automatic Transmission:gear Position Indication (prndl)
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2023 ID.4, 2022-2023 Audi Q4 e-Tron, and Q4 e-Tron Sportback vehicles. The instrument panel may not properly display the transmission gear lever indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence: Failure to display the gear position may result in a vehicle rollaway if the parking brake is not engaged, increasing the risk of a crash.
Remedy: Dealers will update the brake control unit software, free of charge. Owner notification letters were mailed March 14, 2025. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 97H3. Audi's number for this recall is 454R.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2023 ID.4, 2022-2023 Audi Q4 e-Tron, and Q4 e-Tron Sportback vehicles. The instrument panel may not properly display the transmission gear lever indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence: Failure to display the gear position may result in a vehicle rollaway if the parking brake is not engaged, increasing the risk of a crash.
Remedy: Dealers will update the brake control unit software, free of charge. Owner notification letters were mailed March 14, 2025. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 97H3. Audi's number for this recall is 454R.
Sep 4, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2024 ID.4 vehicles. The door handles may allow water to enter the circuit board assembly, which can cause the doors to open unexpectedly.
Consequence & remedy
Consequence: A vehicle door that opens unexpectedly while driving increases the risk of injury.
Remedy: Volkswagen dealers will inspect and replace the door handles as necessary, and update the vehicle software, free of charge. Owner notification letters were mailed on December 27, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 57J9. This recall expands previous recall numbers 23V-312 and 23V-213. Vehicles previously repaired under 23V-312 and 23V-213 will need to have the new remedy completed.
May 15, 2024
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence & remedy
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
Additional source detail variants (3)
Equipment:electrical:infotainment:software
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
Back Over Prevention:software
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
Electrical System:instrument Panel:speedometer/odometer
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
May 3, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2022 ID.4 vehicles. The affected vehicles may have been manufactured with door handles that allow water to enter the circuit board assembly, which can cause the doors to open unexpectedly when the vehicle is subject to high lateral forces at speeds below 9 mph/15 kmh.
Consequence & remedy
Consequence: A vehicle door that opens unexpectedly while the vehicle is in motion increases the risk of injury.
Remedy: Dealers will update the vehicle software, and inspect the door handles as necessary, free of charge. Owner notification letters were mailed March 19, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall are 57J5 and 57J8. This recall was replaced by recall number 24V-651
Feb 1, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID.4 vehicles. Software programing may cause the high voltage (HV) battery management control module to restart or the pulse inverter to deactivate.
Consequence & remedy
Consequence: A reset or deactivation may cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the HV battery management control unit and the pulse inverter control unit software, free of charge. Owner notification letters are expected to be mailed March 31, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 97ZZ.
Nov 2, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID4 vehicles. The passenger air bag may be incorrectly folded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An incorrectly folded air bag may not protect the occupant as intended during a crash, increasing the risk of injury.
Remedy: Volkswagen will replace the passenger air bag module, free of charge. Owner notification letters were mailed February 14, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number to this recall is 69EH.
Mar 16, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID4 vehicles. Incorrect soldering of the flexible printed circuit assembled (FPCA), inside the high voltage (HV) battery, may cause an unreliable connection.
Consequence & remedy
Consequence: An unreliable battery connection may cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the battery cell modules, free of charge. Owner notification letters were mailed December 6, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 9302.
Nov 3, 2021
Volkswagen Group of American, Inc. (Volkswagen) is recalling one 2021 ID.4 vehicle. The steering gear may have an incorrectly assembled or missing drive bushing.
Consequence & remedy
Consequence: An incorrectly assembled or missing drive bushing may cause a loss of steering control, increasing the risk of a crash.
Remedy: A dealer will replace the steering gear, free of charge. Owner notification letters were mailed November 5, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 48Q7.
Aug 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen ID4, Audi A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A5 Sportback, A6 Allroad, A6 Sedan, A7, A8, E-Tron Quattro, E-Tron Sportback Quattro, Q3, Q5, Q5 Sportback, Q7, Q8, RS5 Sportback, RS5 Coupe, RS6 Avant, RS7, RSQ8, S4 Sedan, S5 Cabriolet, S5 Coupe, S5 Sportback, S6 Sedan, S7, S8, SQ5, SQ5 Sportback, SQ7, SQ8, and 2021-2022 S3 Sedan vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the middle-rear seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69CR (VW) and 69CS (Audi).
Additional source detail variants (2)
Seat Belts:rear/other:retractor
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen ID4, Audi A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A5 Sportback, A6 Allroad, A6 Sedan, A7, A8, E-Tron Quattro, E-Tron Sportback Quattro, Q3, Q5, Q5 Sportback, Q7, Q8, RS5 Sportback, RS5 Coupe, RS6 Avant, RS7, RSQ8, S4 Sedan, S5 Cabriolet, S5 Coupe, S5 Sportback, S6 Sedan, S7, S8, SQ5, SQ5 Sportback, SQ7, SQ8, and 2021-2022 S3 Sedan vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the middle-rear seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69CR (VW) and 69CS (Audi).
Seat Belts
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen ID4, Audi A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A5 Sportback, A6 Allroad, A6 Sedan, A7, A8, E-Tron Quattro, E-Tron Sportback Quattro, Q3, Q5, Q5 Sportback, Q7, Q8, RS5 Sportback, RS5 Coupe, RS6 Avant, RS7, RSQ8, S4 Sedan, S5 Cabriolet, S5 Coupe, S5 Sportback, S6 Sedan, S7, S8, SQ5, SQ5 Sportback, SQ7, SQ8, and 2021-2022 S3 Sedan vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the middle-rear seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69CR (VW) and 69CS (Audi).
Aug 4, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID4 vehicles. Incorrect rear outboard seat belt assemblies without an automatic locking retractor (ALR) function may have been installed, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the rear outboard seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69CQ.
Additional source detail variants (2)
Seat Belts:rear/other:retractor
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID4 vehicles. Incorrect rear outboard seat belt assemblies without an automatic locking retractor (ALR) function may have been installed, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the rear outboard seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69CQ.
Seat Belts
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID4 vehicles. Incorrect rear outboard seat belt assemblies without an automatic locking retractor (ALR) function may have been installed, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the rear outboard seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69CQ.
Jun 2, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 ID.4 vehicles. Caps were installed on the headlight vertical aim instead of the horizontal aim, allowing for horizontal adjustment of the headlight beam. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Adjusting the horizontal headlight beam can increase glare, reducing visibility for the driver and increasing the risk of a crash.
Remedy: Dealers will remove the caps from the vertical aim and install them on the horizontal aim, free of charge. Owner notification letters were mailed June 18, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 9406.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ24010 · Inadvertent Door Opening
Opened May 16, 2024 · Closed Nov 4, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
On May 16, 2024, the Office of Defects Investigations (ODI) opened Recall Query (RQ) RQ24010 to investigate the remedy and scope of recalls 23V-213 and 23V-312. The affected vehicles by these recalls included model years (MY) 2021 through 2023 Volkswagen ID.4 vehicles. ODI received reports of the vehicle’s doors opening while the vehicle was in motion post recall remedy. ODI, also, received similar allegations on vehicles that were outside the scope of the recalls. Volkswagen issued recall 23V-213 on March 29, 2023, and recall 23V-213 on May 03, 2023. These recalls addressed the defect of water ingress into the circuit board assembly of the door handle. Water ingress can cause communication issues between the door handle and the door control until. This malfunction resulted in the vehicle door inadvertently opening while the vehicle was in motion. Over the course of the investigation, ODI received 17 unique VIN VOQ complaints of the vehicle doors opening while the vehicle was in motion occurring either post recall remedy or on a vehicle that was outside the recall scope. Volkswagen submitted 190 unique VIN complaints reporting the same circumstances. On September 4, 2024, Volkswagen submitted recall 24V-651 to address the issue of inadvertent opening of the door while the vehicle is in motion. The scope of this recall expands the affected vehicles to include all MY2021-2024 Volkswagen ID.4 models, including those remedied under the subject recalls. The recall remedy consists of replacement of the door handle assembly on all four doors as well as a software update. The software update is performed to update the door handle parameters. The new door handle will have the membrane relocated to the back of the handle to avoid standing water within the handle. Also, a protective coating will be on the front and back of the circuit board to avoid direct moisture formation. In view of the action being taken by Volkswagen, Recall 24V-651, ODI is closing this Recall Query. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration