IllustrationCOOLANT LEAK NOTICED UNDERNEAT THE ENGINE. IT RUN DOWN TO THE OIL PAN DRIPPING ON THE DRIVE WAY. TOOK THE CAR TO THE DEALERSHIP FOR DIAGNOSIS. THEY SAID LEAK IS COMING FROM THE THERMOSTAT HOUSING. MILEAGE IS NOW 73700. VW POWERTRAIN WARRANTY COVERS UP TO 72000.
2018 Volkswagen Golf
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Golf years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 29 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports2 injury reports
What owners actually said
29 reportsIMMEDIATELY AFTER BEGINNING TO LEAVE WORK ON NOVEMBER 13, 2019, I NOTICED THE SUNROOF ON MY 2018 VW GOLF WAS SHATTERING AND CRUMBLING AWAY, STARTING TOWARD THE FRONT AND CENTER OF THE SUNROOF. THE INITIAL BREAK MUST HAVE OCCURRED EITHER AS IT WAS SITTING IN THE PARKING LOT AT WORK, OR IMMEDIATELY AFTER BEGINNING TO DRIVE, AT NO …
Read full complaint
IMMEDIATELY AFTER BEGINNING TO LEAVE WORK ON NOVEMBER 13, 2019, I NOTICED THE SUNROOF ON MY 2018 VW GOLF WAS SHATTERING AND CRUMBLING AWAY, STARTING TOWARD THE FRONT AND CENTER OF THE SUNROOF. THE INITIAL BREAK MUST HAVE OCCURRED EITHER AS IT WAS SITTING IN THE PARKING LOT AT WORK, OR IMMEDIATELY AFTER BEGINNING TO DRIVE, AT NO MORE THAN 20MPH, BECAUSE I NOTICED IT ON THE DRIVEWAY LEADING AWAY FROM MY WORKPLACE. THE WEATHER WAS ABOUT 30 DEGREES FAHRENHEIT WITH NO PRECIPITATION AND THERE WAS NO ROAD DEBRIS INVOLVED. OVER THE NEXT FEW DAYS, I TRIED TO LIMIT MY USE OF THE CAR (I SECURED A RENTAL CAR THROUGH MY INSURANCE FOR A FEW DAYS) BUT THE AREA OF BROKEN GLASS EXPANDED SIGNIFICANTLY ANYWAY. TO DATE, VW HAS NOT ACCEPTED ANY RESPONSIBILITY FOR THIS UNDER WARRANTY EVEN THOUGH THE CAR WAS BOUGHT NEW, I AM THE ONLY OWNER, AND IT ONLY HAD ABOUT 20,300 MILES ON IT AT THE TIME OF THE INCIDENT. THEY SUGGESTED I GO THROUGH MY INSURANCE FOR THE REPAIR. THE REPAIR IS IN PROGRESS BUT I AM TOLD BY THE GLASS SHOP THAT IS HANDLING IT THAT ONE OF THE TWO SUNROOF ACTUATORS ACTUALLY APPEARS DAMAGED BY THE FLEXING AND BREAKING OF THE GLASS AND THIS IS MAKING IT DIFFICULT TO REMOVE THE ORIGINAL SUNROOF PANEL.
TL* THE CONTACT OWNS A 2018 VOLKSWAGEN GOLF. ON SEVERAL OCCASIONS, WHILE DRIVING, THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO SUNTRUP VOLKSWAGEN (LOCATED AT 6000 S LINDBERGH BLVD, ST LOUIS, MO 63123, (314) 892-8200) FOUR TIMES, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. DIAGNOSTICS REVEALED A FAU…
Read full complaint
TL* THE CONTACT OWNS A 2018 VOLKSWAGEN GOLF. ON SEVERAL OCCASIONS, WHILE DRIVING, THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO SUNTRUP VOLKSWAGEN (LOCATED AT 6000 S LINDBERGH BLVD, ST LOUIS, MO 63123, (314) 892-8200) FOUR TIMES, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. DIAGNOSTICS REVEALED A FAULTY VALVE, WHICH WAS REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD ALSO ACCELERATE WHILE ON AN INCLINE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 16,000. *BF CONSUMER STATED VOLKSWAGEN IS UNDER NO OBLIGATION TO HONOT THEIR WARRANTY AS LONG AS THEY MAINTAIN THAT MY CAR IS OPERATING NORMALLY. 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB
AFTER CAR HAS BEEN DRIVEN LONG ENOUGH TO BE COMPLETELY WARMED UP AND THEN PARKED, ON RE-ENTERING THE CAR AND BEFORE STARTING IT, THERE IS A STRONG ODOR OF GASOLINE NOTICEABLE TO THE DRIVER AND FRONT-SEAT PASSENGER. ONCE THE ENGINE HAS BEEN STARTED AND THE VENTILATION FAN HAS RUN, THE ODOR DISSIPATES; THE ODOR IS NOT COMING THROU…
Read full complaint
AFTER CAR HAS BEEN DRIVEN LONG ENOUGH TO BE COMPLETELY WARMED UP AND THEN PARKED, ON RE-ENTERING THE CAR AND BEFORE STARTING IT, THERE IS A STRONG ODOR OF GASOLINE NOTICEABLE TO THE DRIVER AND FRONT-SEAT PASSENGER. ONCE THE ENGINE HAS BEEN STARTED AND THE VENTILATION FAN HAS RUN, THE ODOR DISSIPATES; THE ODOR IS NOT COMING THROUGH THE VENTILATION SYSTEM. THE DEALER'S SERVICE DEPARTMENT FOUND ONE ENGINE FUEL LINE CONNECTION WHICH APPEARED TO BE LEAKING AND REPLACED THAT FUEL LINE, BUT THE PROBLEM REMAINS. THIS HAS BEEN AN ONGOING PROBLEM STARTING SHORTLY AFTER WE BOUGHT THE CAR IN JULY 2018.
LESS THAN ONE YEAR INTO OWNERSHIP, THE CAR HAS EXPERIENCED A PANORAMIC SUNROOF LEAK ON BOTH THE DRIVERS SIDE AND PASSENGER SIDE FRONT AREA NEAR THE A-PILLAR AND THE SUNVISOR. THERE HAVE BEEN MULTIPLE REPORTED INCIDENTS ALL OVER VARIOUS SOURCES ON THE INTERNET. THE SUNROOF, VISOR AND DOME LIGHT AREA IS EXACTLY THE SAME DESIGN AS …
Read full complaint
LESS THAN ONE YEAR INTO OWNERSHIP, THE CAR HAS EXPERIENCED A PANORAMIC SUNROOF LEAK ON BOTH THE DRIVERS SIDE AND PASSENGER SIDE FRONT AREA NEAR THE A-PILLAR AND THE SUNVISOR. THERE HAVE BEEN MULTIPLE REPORTED INCIDENTS ALL OVER VARIOUS SOURCES ON THE INTERNET. THE SUNROOF, VISOR AND DOME LIGHT AREA IS EXACTLY THE SAME DESIGN AS THE 2018 TIGUAN THAT HAS NOW BEEN RECALLED DUE TO SUNROOF LEAKS CAUSING SHORT CIRCUITS ON THE DOME LIGHT THUS CAUSING A FIRE. THE FEAR WE HAVE IS THAT THIS IS A LOW VOLUME CAR SO IT'S NOT GETTING THE SAME EXPOSURE VS. THE TIGUAN WHICH IS A HIGH VOLUME CAR AND MANY MORE ARE ON THE ROAD. IN ADDITION, THIS FOLLOWS-UP ON SEVERAL COMPLAINTS MADE OF THE SAME ISSUE ON THE 2017 ALLTRACK MODEL.
THE "FRONT ASSIST" SYSTEM ON A 2018 VW GOLF R IS PRONE TO MAKING UNSAFE ABRUPT STOPS IN TRAFFIC. IF A LEADING CAR MAKES AN ABRUPT STOP, THE FRONT ASSIST SYSTEM APPLIES INSTANT HEAVY BRAKING EVEN WHEN THE DRIVER IS ALREADY BRINGING THE CAR TO A SMOOTH STOP AT A SAFE DISTANCE. THIS DOUBLE-BRAKING RESULTS IN UNEXPECTED SKIDDING…
Read full complaint
THE "FRONT ASSIST" SYSTEM ON A 2018 VW GOLF R IS PRONE TO MAKING UNSAFE ABRUPT STOPS IN TRAFFIC. IF A LEADING CAR MAKES AN ABRUPT STOP, THE FRONT ASSIST SYSTEM APPLIES INSTANT HEAVY BRAKING EVEN WHEN THE DRIVER IS ALREADY BRINGING THE CAR TO A SMOOTH STOP AT A SAFE DISTANCE. THIS DOUBLE-BRAKING RESULTS IN UNEXPECTED SKIDDING AND RISKS A REAR-END COLLISION WITH FOLLOWING CARS. THE MANUAL OVERRIDE TO FRONT ASSIST IS PRESSING HARD ON THE GAS PEDAL. THIS ACTION CAN'T BE PERFORMED WHEN THE DRIVER IS ALREADY BRINGING THE CAR TO A STOP.
OVER TIME, A BUILD-UP OF SILICATE ON THE SHIFT LEVER MICRO SWITCH CONTACTS CAN MAKE IT POSSIBLE TO REMOVE THE KEY FROM THE IGNITION SWITCH WITHOUT THE SHIFT LEVER BEING IN THE "P" PARK POSITION. THIS MAKES THE VEHICLE NONCOMPLIANT WITH 49 CFR 571.114 STANDARD NO. 114 THEFT PROTECTION AND ROLLAWAY PREVENTION. IF THE IGNITION KEY …
Read full complaint
OVER TIME, A BUILD-UP OF SILICATE ON THE SHIFT LEVER MICRO SWITCH CONTACTS CAN MAKE IT POSSIBLE TO REMOVE THE KEY FROM THE IGNITION SWITCH WITHOUT THE SHIFT LEVER BEING IN THE "P" PARK POSITION. THIS MAKES THE VEHICLE NONCOMPLIANT WITH 49 CFR 571.114 STANDARD NO. 114 THEFT PROTECTION AND ROLLAWAY PREVENTION. IF THE IGNITION KEY IS REMOVED WITHOUT THE SHIFT LEVER BEING IN THE "P" PARK POSITION, THERE IS A RISK THAT THE VEHICLE MAY ROLL AWAY, RESULTING IN A CRASH THAT COULD INJURE PEOPLE AND DAMAGE PROPERTY. RECALL STILL NOT FIXED PARTS SUPPOSED TO BE AVAILABLE BEGINNING OF JANUARY VW HAS STILL NOT RELEASED
I HAD TO BRAKE HARD AS THE PERSON IN FRONT OF ME ON THE OFFRAMP STOPPED SHORT. I THINK SOMEONE CUT THE DRIVER IN FRONT OF ME OFF, OR PEOPLE WERE JUST HAVING TROUBLE MERGING. THE ANTI-LOCK BRAKES DID NOT WORK, THE CAR FISH-TAILED FROM RIGHT TO LEFT. I LET UP ON THE BRAKES AND THE CAR STRAIGHTENED OUT AND I DIDN'T GET KILLED BUT I…
Read full complaint
I HAD TO BRAKE HARD AS THE PERSON IN FRONT OF ME ON THE OFFRAMP STOPPED SHORT. I THINK SOMEONE CUT THE DRIVER IN FRONT OF ME OFF, OR PEOPLE WERE JUST HAVING TROUBLE MERGING. THE ANTI-LOCK BRAKES DID NOT WORK, THE CAR FISH-TAILED FROM RIGHT TO LEFT. I LET UP ON THE BRAKES AND THE CAR STRAIGHTENED OUT AND I DIDN'T GET KILLED BUT IT WOULD HAVE BEEN A BAD ACCIDENT. THANKFULLY THE GUY BEHIND ME WAS ABLE TO STOP. THIS IS A CAR I BOUGHT LAST WEEK. THERE IS SOMETHING WRONG WITH THE BRAKES. EVEN MY 10 YEAR OLD CAR WOULD HAVE ACTIVATED ANTI-LOCK.
AFTER RESTARTING HOT ENGINE AFTER A BRIEF STOP, CAR MIGHT STUMBLE DURING FIRST ATTEMPT TO ACCELERATE, FOR EXAMPLE TRYING TO ENTER TRAFFIC FROM A PARKING LOT. THIS HAS HAPPENED SEVERAL TIMES AND HAS BEEN CAUSE FOR ALARM. THE ENGINE IS RUNNING BUT FEELS AS IF IT IS NOT. THIS IS NOT NORMAL TURBO LAG AND THE PROBLEM CLEARS AFTER T…
Read full complaint
AFTER RESTARTING HOT ENGINE AFTER A BRIEF STOP, CAR MIGHT STUMBLE DURING FIRST ATTEMPT TO ACCELERATE, FOR EXAMPLE TRYING TO ENTER TRAFFIC FROM A PARKING LOT. THIS HAS HAPPENED SEVERAL TIMES AND HAS BEEN CAUSE FOR ALARM. THE ENGINE IS RUNNING BUT FEELS AS IF IT IS NOT. THIS IS NOT NORMAL TURBO LAG AND THE PROBLEM CLEARS AFTER THE FIRST INSTANCE. I REPORTED THIS TO THE DEALER AND THEIR RESPONSE IS THAT THEY CAN'T DUPLICATE AND THERE ARE NO DIAGNOSTIC CODES SET.
Official recalls
624V110000 · Fuel System, Gasoline
Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
20V372000 · Equipment:other:labels
Jun 24, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling two 2018 Golf GTI vehicles. The VIN printed on the Federal Certification label may not match the actual VIN on the vehicle. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: If the stamped vehicle identification number (VIN) does not match the VIN on the Vehicle Certification Label, owners may be unable to tell if their vehicle is under an important safety recall, possibly exposing them to an increased risk of a crash, fire or injury.
Remedy: Volkswagen will notify owners, and dealers will install a correct certification label, free of charge. This recall began July 9, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01E7.
19V615000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Steering:column LOCKING:ANTI-THEFT Device
Aug 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
19V188000 · Suspension:rear:springs:coil Springs
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
18V464000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Steering:column LOCKING:ANTI-THEFT Device
Jul 11, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
18V369000 · Service Brakes, Hydraulic:foundation Components:disc:caliper
Jun 1, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas, Passat, Beetle, Beetle Convertible, Golf, Golf SportWagen and GTI and Audi Q5 and SQ5 vehicles. The brake caliper pistons on these vehicles may have insufficient coating, potentially reducing the brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: Volkswagen and Audi will notify their owners. Audi dealers will bleed the rear brakes. Volkswagen dealers will bleed the front and rear brake calipers. Note: Owners are advised not to drive their vehicles until the brake system has been checked. The recall began June 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 47N8, 47N9, and 47N6.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.