Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 29 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports2 injury reports
What owners actually said
29 reports
Mileage unknown · May 31, 2026
Fuel/propulsion SystemStructureUnknown Or Other
Vehicle brought in for Recall 20UF (fuel tank suction pump fire risk) on 04/15/2026. Upon pickup after approximately one week of dealer service, a strong chemical odor was present in the cabin that did not exist prior to service. Odor persists despite cabin air filter replacement with activated charcoal filter, professional carp…
Read full complaint
Vehicle brought in for Recall 20UF (fuel tank suction pump fire risk) on 04/15/2026. Upon pickup after approximately one week of dealer service, a strong chemical odor was present in the cabin that did not exist prior to service. Odor persists despite cabin air filter replacement with activated charcoal filter, professional carpet shampooing, and extended airing out over several weeks. Dealer dismissed concerns and suggested owner pay for cabin filter replacement which had no effect. VW's own Recall 20UF documentation acknowledges that fuel odor may be noticed by occupants when the recall condition exists. Requesting investigation into whether recall repair was fully completed and whether odor is related to incompletely resolved recall condition. A neighbor experienced identical odor issue after bringing their Tiguan to a different Westchester dealer for service.
NHTSA ODI #11741116
Mileage unknown · May 26, 2026
Fuel/propulsion System
SUPPLEMENTAL INFORMATION OF ODI COMPLAINT NUMBER 11740201. I am submitting critical supplemental information to my active safety complaint regarding a 2018 Volkswagen Golf SportWagen (1.8T engine). My primary safety issues are a severe drop in fuel efficiency (cut completely in half), heavy vehicle hesitation/jerking during a…
Read full complaint
SUPPLEMENTAL INFORMATION OF ODI COMPLAINT NUMBER 11740201. I am submitting critical supplemental information to my active safety complaint regarding a 2018 Volkswagen Golf SportWagen (1.8T engine). My primary safety issues are a severe drop in fuel efficiency (cut completely in half), heavy vehicle hesitation/jerking during acceleration, and a powerful raw gasoline smell inside the cabin immediately after fueling. These symptoms heavily align with the known physical failures covered under Volkswagen's Suction Jet Pump safety campaigns. I took my vehicle to the Volkswagen dealership today for a diagnostic inspection. The service manager initially dismissed my complaints, refused to physically check the EVAP charcoal canister or suction pump, and claimed that my 50% drop in fuel economy was merely due to my 'driving style.' However, upon forcing me to pay a $136 diagnostic fee to retrieve my keys, the official paperwork provided by the dealership directly contradicted the manager. The technician documented finding a physical fuel leak. Alarmingly, this is the exact same 'small fuel leak' that this specific dealership claimed to have fully repaired a few months ago. That previous visit occurred because my steering wheel completely locked up while driving, nearly causing a severe accident—an issue the dealership also dismissed at the time because it 'failed to throw an error code.' The dealership has demonstrated a reckless pattern of ignoring severe mechanical safety hazards—including steering failures and active, recurring fuel leaks—solely because the vehicle's computer does not register a digital fault code. I am trapped driving a vehicle that is actively leaking fuel, smelling of raw gas inside the passenger cabin, and suffering from dangerous acceleration hesitation due to an unresolved fuel-system defect. I request a formal investigation into this ongoing safety hazard and the dealer's failure to remedy it.
NHTSA ODI #11740222
Mileage unknown · May 26, 2026
Fuel/propulsion System
Took my car into VW in Johnson City TN because my millage has been dropping drastically. Went from about 420 miles to a tank, down to less than 300. There is hesitation and jerking when I accelerate as well as a gasoline odor in the cab of the vehicle after refueling. Service manager said there was no code thrown and when he too…
Read full complaint
Took my car into VW in Johnson City TN because my millage has been dropping drastically. Went from about 420 miles to a tank, down to less than 300. There is hesitation and jerking when I accelerate as well as a gasoline odor in the cab of the vehicle after refueling. Service manager said there was no code thrown and when he took it for a drive her drove “conservatively” and the mpg was normal. They did not physically inspect the fuel pump jet and gaslit me saying it was how I’m driving. Refused to actually look at the problem and then threatened that if I wanted them to look they would charge me for the labor. They did not seem concerned that a safety hazard of smelling fuel in the cab and poor fuel efficiency was an issue.manager said he knew of the active extended recall but hid behind the no code from their scanner instead of listening to the customer who voiced concerns. They didn’t want to do the work if they had to pay for it.
NHTSA ODI #11740201
Mileage unknown · Dec 15, 2025
Unknown Or Other
Sunroof Glass Implosion While Driving (2018 Volkswagen Golf) While driving my 2018 Volkswagen Golf at normal highway speed, my sunroof suddenly and violently imploded without any warning or external impact. The sound was extremely loud—similar to a gunshot or an explosion—and initially I believed something had struck the vehicle…
Read full complaint
Sunroof Glass Implosion While Driving (2018 Volkswagen Golf) While driving my 2018 Volkswagen Golf at normal highway speed, my sunroof suddenly and violently imploded without any warning or external impact. The sound was extremely loud—similar to a gunshot or an explosion—and initially I believed something had struck the vehicle or that a large object had landed on the sunroof.Glass shattered and fell into the interior of the vehicle, sending shards throughout the cabin. The incident was extremely frightening and caused me to momentarily lose focus while driving. I narrowly avoided a potential car accident due to the sudden noise, falling glass, and shock of the event. There were no visible objects, debris, or overpasses that could explain the breakage, and no other vehicles were involved. This appears to be a spontaneous sunroof glass failure. The incident poses a serious safety risk, as it could easily lead to a crash or cause injury to occupants. I am reporting this issue to raise awareness and request investigation, as spontaneous sunroof implosions while driving are dangerous and should not occur under normal driving conditions.
NHTSA ODI #11704994
Mileage unknown · Nov 14, 2024
StructureInjury
There is an issue with the gear shift cover trim. The piece that goes around the gear shift has a chrome coating that has been pealing off. Over multiple occasions that pealed off piece of metal has cut my finger causing bleeding. There seems to be a recall on the DSG GTI for this, but not the MT. I am having the same exact…
Read full complaint
There is an issue with the gear shift cover trim. The piece that goes around the gear shift has a chrome coating that has been pealing off. Over multiple occasions that pealed off piece of metal has cut my finger causing bleeding. There seems to be a recall on the DSG GTI for this, but not the MT. I am having the same exact issue as the DSG and the replacement part is the exact same (likely same original part). The safety issue is that this has cut my finger multiple times with bleeding and can be quite painful. I called VW and was told my car was not part of the DSG recall 34J7/34L9, but clearly it has the same issue. Here is the case number from that call: VW Customer CARE [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11625316
Mileage unknown · Jul 15, 2024
Fuel/propulsion System
Cannot fill gas tank. Recall issued February 2024 no remedy available still. 24V110
NHTSA ODI #11602381
Mileage unknown · Jul 9, 2024
Fuel/propulsion System
I have a recall for the jet pump in the fuel tank of my vehicle. I have had fuel leaking from my charcoal canister. The vehicle is at the dealership right now, and they have confirmed this. Yet they will not make a repair on it and have been without my vehicle for over a week now. I am stuck in limbo with no date when anything w…
Read full complaint
I have a recall for the jet pump in the fuel tank of my vehicle. I have had fuel leaking from my charcoal canister. The vehicle is at the dealership right now, and they have confirmed this. Yet they will not make a repair on it and have been without my vehicle for over a week now. I am stuck in limbo with no date when anything will be done. I am unable to drive my vehicle due to he leak as it is unsafe and a fire hazard. The vehicle will also cut off while driving and will not start, even though it says there is still fuel in it. This should be due to the leak, and the dealer will do nothing to fix my problem until they are notified by Volkswagen themselves. This is ridiculous as i am without a vehicle, which i am still paying a loan on and insurance every month. Yet i have called Volkswagen and have been offered no solution on this matter. I have been told to wait for the recall, but this issue has been known about since February. Am i just supposed to wait indefinitely for a solution while i can't work or drive anywhere, while i continue to pay for this vehicle? I need a solution and Volkswagen to fix my issue and to be help responsible.
NHTSA ODI #11600571
Mileage unknown · Feb 7, 2024
Steering
There is a peeling plastic/metal chrome trim piece on the steering wheel that cause a finger laceration.
NHTSA ODI #11570664
Mileage unknown · Jan 17, 2024
Electrical SystemSteeringSuspension
I was coming back from work and was driving on the highway at around 80 mph. All of a sudden, literally out of nowhere, the car started shaking violently, and the steering wheel was shaking super fast violently (vibrating) and was very heavy and hard to move. Also, the D started flashing. I was struggling to control the car. I n…
Read full complaint
I was coming back from work and was driving on the highway at around 80 mph. All of a sudden, literally out of nowhere, the car started shaking violently, and the steering wheel was shaking super fast violently (vibrating) and was very heavy and hard to move. Also, the D started flashing. I was struggling to control the car. I noticed that the Abs light, steering light, suspension light for DCC, and a whole bunch of other lights except the engine light. The car was in custom mode. Sport steering and sport Suspension, Normal for powertrain. All windows and sunroof were fully open, and music was playing. When all this occurred, I could hear outside the car something that sounded like metal tinging or metal contact. idk. This was while the car was still moving. When I pulled over, all the lights went away. I turned off the car for a few minutes and turned it back on. The lights did not come back, and it drove like nothing ever happened. The car is currently at VW Dealership awaiting a response from VW helpline (VTA) as of 1/17/24. I have been doing research on this issue and I have found multiple VW GTI/R owners who are currently and/or have experienced this issue. A Golf R (Model year 2018) owner with about 19.5k miles said "The real problem was the electric power assist motor, the part that controls how heavy the steering is when you change modes. But it can't be serviced. So the whole thing has to be swapped. It needed the entire power steering rack assembly replaced". He took this to a VW dealership and was covered under warranty. I strongly believe VW needs to release a recall for this as it is very dangerous to happen while driving especially at highway speeds like it did to me and many others.
NHTSA ODI #11565903
Mileage unknown · Sep 15, 2023
Exterior Lighting
Hello my left front headlamp failed. Initially both my headlights were sweaty/foggy, which started early 2021 but no light present. This is a safety issue especially when driving at night. It is available for inspection. The vehicle was inspected at the dealer Galpin VW. AFS light came on when system failed.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Volkswagen Group of America, Inc. (Volkswagen) is recalling two 2018 Golf GTI vehicles. The VIN printed on the Federal Certification label may not match the actual VIN on the vehicle. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: If the stamped vehicle identification number (VIN) does not match the VIN on the Vehicle Certification Label, owners may be unable to tell if their vehicle is under an important safety recall, possibly exposing them to an increased risk of a crash, fire or injury.
Remedy: Volkswagen will notify owners, and dealers will install a correct certification label, free of charge. This recall began July 9, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01E7.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas, Passat, Beetle, Beetle Convertible, Golf, Golf SportWagen and GTI and Audi Q5 and SQ5 vehicles. The brake caliper pistons on these vehicles may have insufficient coating, potentially reducing the brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: Volkswagen and Audi will notify their owners. Audi dealers will bleed the rear brakes. Volkswagen dealers will bleed the front and rear brake calipers. Note: Owners are advised not to drive their vehicles until the brake system has been checked. The recall began June 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 47N8, 47N9, and 47N6.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2018 Volkswagen Golf Problems, Complaints & Recalls | Skip That Year
Illustration