Vehicle brought in for Recall 20UF (fuel tank suction pump fire risk) on 04/15/2026. Upon pickup after approximately one week of dealer service, a strong chemical odor was present in the cabin that did not exist prior to service. Odor persists despite cabin air filter replacement with activated charcoal filter, professional carp…
Read full complaint
Vehicle brought in for Recall 20UF (fuel tank suction pump fire risk) on 04/15/2026. Upon pickup after approximately one week of dealer service, a strong chemical odor was present in the cabin that did not exist prior to service. Odor persists despite cabin air filter replacement with activated charcoal filter, professional carpet shampooing, and extended airing out over several weeks. Dealer dismissed concerns and suggested owner pay for cabin filter replacement which had no effect. VW's own Recall 20UF documentation acknowledges that fuel odor may be noticed by occupants when the recall condition exists. Requesting investigation into whether recall repair was fully completed and whether odor is related to incompletely resolved recall condition. A neighbor experienced identical odor issue after bringing their Tiguan to a different Westchester dealer for service.
NHTSA ODI #11741116
Mileage unknown · May 26, 2026
Fuel/propulsion System
SUPPLEMENTAL INFORMATION OF ODI COMPLAINT NUMBER 11740201. I am submitting critical supplemental information to my active safety complaint regarding a 2018 Volkswagen Golf SportWagen (1.8T engine). My primary safety issues are a severe drop in fuel efficiency (cut completely in half), heavy vehicle hesitation/jerking during a…
Read full complaint
SUPPLEMENTAL INFORMATION OF ODI COMPLAINT NUMBER 11740201. I am submitting critical supplemental information to my active safety complaint regarding a 2018 Volkswagen Golf SportWagen (1.8T engine). My primary safety issues are a severe drop in fuel efficiency (cut completely in half), heavy vehicle hesitation/jerking during acceleration, and a powerful raw gasoline smell inside the cabin immediately after fueling. These symptoms heavily align with the known physical failures covered under Volkswagen's Suction Jet Pump safety campaigns. I took my vehicle to the Volkswagen dealership today for a diagnostic inspection. The service manager initially dismissed my complaints, refused to physically check the EVAP charcoal canister or suction pump, and claimed that my 50% drop in fuel economy was merely due to my 'driving style.' However, upon forcing me to pay a $136 diagnostic fee to retrieve my keys, the official paperwork provided by the dealership directly contradicted the manager. The technician documented finding a physical fuel leak. Alarmingly, this is the exact same 'small fuel leak' that this specific dealership claimed to have fully repaired a few months ago. That previous visit occurred because my steering wheel completely locked up while driving, nearly causing a severe accident—an issue the dealership also dismissed at the time because it 'failed to throw an error code.' The dealership has demonstrated a reckless pattern of ignoring severe mechanical safety hazards—including steering failures and active, recurring fuel leaks—solely because the vehicle's computer does not register a digital fault code. I am trapped driving a vehicle that is actively leaking fuel, smelling of raw gas inside the passenger cabin, and suffering from dangerous acceleration hesitation due to an unresolved fuel-system defect. I request a formal investigation into this ongoing safety hazard and the dealer's failure to remedy it.
NHTSA ODI #11740222
Mileage unknown · May 26, 2026
Fuel/propulsion System
Took my car into VW in Johnson City TN because my millage has been dropping drastically. Went from about 420 miles to a tank, down to less than 300. There is hesitation and jerking when I accelerate as well as a gasoline odor in the cab of the vehicle after refueling. Service manager said there was no code thrown and when he too…
Read full complaint
Took my car into VW in Johnson City TN because my millage has been dropping drastically. Went from about 420 miles to a tank, down to less than 300. There is hesitation and jerking when I accelerate as well as a gasoline odor in the cab of the vehicle after refueling. Service manager said there was no code thrown and when he took it for a drive her drove “conservatively” and the mpg was normal. They did not physically inspect the fuel pump jet and gaslit me saying it was how I’m driving. Refused to actually look at the problem and then threatened that if I wanted them to look they would charge me for the labor. They did not seem concerned that a safety hazard of smelling fuel in the cab and poor fuel efficiency was an issue.manager said he knew of the active extended recall but hid behind the no code from their scanner instead of listening to the customer who voiced concerns. They didn’t want to do the work if they had to pay for it.
NHTSA ODI #11740201
Mileage unknown · Jul 15, 2024
Fuel/propulsion System
Cannot fill gas tank. Recall issued February 2024 no remedy available still. 24V110
NHTSA ODI #11602381
Mileage unknown · Jul 9, 2024
Fuel/propulsion System
I have a recall for the jet pump in the fuel tank of my vehicle. I have had fuel leaking from my charcoal canister. The vehicle is at the dealership right now, and they have confirmed this. Yet they will not make a repair on it and have been without my vehicle for over a week now. I am stuck in limbo with no date when anything w…
Read full complaint
I have a recall for the jet pump in the fuel tank of my vehicle. I have had fuel leaking from my charcoal canister. The vehicle is at the dealership right now, and they have confirmed this. Yet they will not make a repair on it and have been without my vehicle for over a week now. I am stuck in limbo with no date when anything will be done. I am unable to drive my vehicle due to he leak as it is unsafe and a fire hazard. The vehicle will also cut off while driving and will not start, even though it says there is still fuel in it. This should be due to the leak, and the dealer will do nothing to fix my problem until they are notified by Volkswagen themselves. This is ridiculous as i am without a vehicle, which i am still paying a loan on and insurance every month. Yet i have called Volkswagen and have been offered no solution on this matter. I have been told to wait for the recall, but this issue has been known about since February. Am i just supposed to wait indefinitely for a solution while i can't work or drive anywhere, while i continue to pay for this vehicle? I need a solution and Volkswagen to fix my issue and to be help responsible.
NHTSA ODI #11600571
Mileage unknown · Aug 13, 2023
Fuel/propulsion System
During refueling after low fuel indicator, fuel tank was not able to accept any fuel. During a second attempt, vehicle accepted 0.25 gallons but all of this fuel came gushing out of the tank from the inlet and from the passenger side rear wheel well. Fuel kept leaking for another 20miles until vehicle was taken to the Rochester …
Read full complaint
During refueling after low fuel indicator, fuel tank was not able to accept any fuel. During a second attempt, vehicle accepted 0.25 gallons but all of this fuel came gushing out of the tank from the inlet and from the passenger side rear wheel well. Fuel kept leaking for another 20miles until vehicle was taken to the Rochester Hills, MI VW dealership. The vehicle continued to leak fuel at the dealership and I was requested to park outside due to the risk of a fire. During this 20mile trip, engine was very hesitant and spluttered and almost stalled. No warning lights on dash. My personal safety was at risk since any ignition source would cause a fire due to this fuel leak, vehicle did not show any warning lights besides low fuel. VW dealership information was that the fuel tank suction jet pump needs replacement. No information was shared if the component will be sent to the manufacturer for inspection. No information how this new pump will not cause a repeat event.
NHTSA ODI #11538196
Mileage unknown · Jul 6, 2023
Electrical SystemFuel/propulsion System
I have owned the 2018 VW GTI since new. With 105,000 miles, following a 30 minute highway drive, the EPC light came on and the vehicle entered limp mode. After turning car off, letting it sit 5 minutes, and restarting, EPC light went off and no limp mode. Drove car daily for another week with no observed issues until appointm…
Read full complaint
I have owned the 2018 VW GTI since new. With 105,000 miles, following a 30 minute highway drive, the EPC light came on and the vehicle entered limp mode. After turning car off, letting it sit 5 minutes, and restarting, EPC light went off and no limp mode. Drove car daily for another week with no observed issues until appointment. Brought car to dealer. They identified the fuel injector wiring harness was faulty and needed to be replaced, and fuel injector #3 was dirty and needed to be replaced, at total cost of $1,756. Online search turned up VWP-23-03, a FUEL INJECTOR WIRING HARNESS LIMITED WARRANTY EXTENSION up to 10 years or 120,000 miles for similar VW cars: 2018-2019 Tiguan 2018-2019 Beetle 2018-2020 Passat So the same exact part, on thousands of other VW models produced at the same time, is covered by a warranty extension. The dealer declined to cover this repair. VW Customer Care declined to cover this repair or offer partial coverage. The car has been repaired by dealer (harness was shorted). I am not asking for special treatment. I am looking for fairness. If VW has identified a given component as defective on three different models, and the same component fails on my GTI, then VW should also cover the GTI under the Warranty Extension.
NHTSA ODI #11530629
Mileage unknown · Jul 29, 2022
Fuel/propulsion System
Fuel leaking from charcoal canister next to exhaust can lead to fire. Fuel leaking on to ground by passenger side rear wheel. Strong smell of gasoline outside and inside car. Caused dizziness while driving can harm children. No warning or any lights other then strong odour of gasoline from inside/outside of vehicle Similar to …
Read full complaint
Fuel leaking from charcoal canister next to exhaust can lead to fire. Fuel leaking on to ground by passenger side rear wheel. Strong smell of gasoline outside and inside car. Caused dizziness while driving can harm children. No warning or any lights other then strong odour of gasoline from inside/outside of vehicle Similar to safety recall 20Y6 Parts requested for repair by dealer -EVAP can system -Fuel Tank
NHTSA ODI #11476551
6,000 miles · Jan 29, 2021
Fuel/propulsion System
RIGHT FRONT (PASSENGER) SIDE HAS A VERY LOUD CONSISTENT RATTLING NOISE AT AROUND 2000-3500 ENGINE RPM RANGE. READING ALONE AND CONFIRMING WITH OTHER OWNERS OF THE SAME VEHICLE, IT IS A LOOSE FUEL LINE GOING UNDER THE FRONT PASSENGER SIDE RATTLING AGAINST THE CHASSIS. COULD BE A HIGH RISK, NOT SURE, CHECK AND ADVISE.
NHTSA ODI #11390636
500 miles · Mar 9, 2019
Fuel/propulsion System
AFTER CAR HAS BEEN DRIVEN LONG ENOUGH TO BE COMPLETELY WARMED UP AND THEN PARKED, ON RE-ENTERING THE CAR AND BEFORE STARTING IT, THERE IS A STRONG ODOR OF GASOLINE NOTICEABLE TO THE DRIVER AND FRONT-SEAT PASSENGER. ONCE THE ENGINE HAS BEEN STARTED AND THE VENTILATION FAN HAS RUN, THE ODOR DISSIPATES; THE ODOR IS NOT COMING THROU…
Read full complaint
AFTER CAR HAS BEEN DRIVEN LONG ENOUGH TO BE COMPLETELY WARMED UP AND THEN PARKED, ON RE-ENTERING THE CAR AND BEFORE STARTING IT, THERE IS A STRONG ODOR OF GASOLINE NOTICEABLE TO THE DRIVER AND FRONT-SEAT PASSENGER. ONCE THE ENGINE HAS BEEN STARTED AND THE VENTILATION FAN HAS RUN, THE ODOR DISSIPATES; THE ODOR IS NOT COMING THROUGH THE VENTILATION SYSTEM. THE DEALER'S SERVICE DEPARTMENT FOUND ONE ENGINE FUEL LINE CONNECTION WHICH APPEARED TO BE LEAKING AND REPLACED THAT FUEL LINE, BUT THE PROBLEM REMAINS. THIS HAS BEEN AN ONGOING PROBLEM STARTING SHORTLY AFTER WE BOUGHT THE CAR IN JULY 2018.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Volkswagen Group of America, Inc. (Volkswagen) is recalling two 2018 Golf GTI vehicles. The VIN printed on the Federal Certification label may not match the actual VIN on the vehicle. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: If the stamped vehicle identification number (VIN) does not match the VIN on the Vehicle Certification Label, owners may be unable to tell if their vehicle is under an important safety recall, possibly exposing them to an increased risk of a crash, fire or injury.
Remedy: Volkswagen will notify owners, and dealers will install a correct certification label, free of charge. This recall began July 9, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01E7.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas, Passat, Beetle, Beetle Convertible, Golf, Golf SportWagen and GTI and Audi Q5 and SQ5 vehicles. The brake caliper pistons on these vehicles may have insufficient coating, potentially reducing the brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: Volkswagen and Audi will notify their owners. Audi dealers will bleed the rear brakes. Volkswagen dealers will bleed the front and rear brake calipers. Note: Owners are advised not to drive their vehicles until the brake system has been checked. The recall began June 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 47N8, 47N9, and 47N6.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2018 Volkswagen Golf Problems, Complaints & Recalls | Skip That Year
Illustration