NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
10 reportsClear category filterMileage unknown · May 5, 2026
Electrical SystemEngine
Driving my 2017Golf the check engine light came on. The light was steady. I called my dealer and got it in for service. They report to me that the Thermostat housing needs to be replaced and oxygen sensors need replacing also. I just had the manifold replaced 6 weeks ago. I found on line that this is a common problem . Why isn’…
Read full complaint
Driving my 2017Golf the check engine light came on. The light was steady. I called my dealer and got it in for service. They report to me that the Thermostat housing needs to be replaced and oxygen sensors need replacing also. I just had the manifold replaced 6 weeks ago. I found on line that this is a common problem . Why isn’t this a Recall Repair?
NHTSA ODI #11735790
Mileage unknown · Oct 30, 2025
Electrical System
I have been having rear cameras for quite some time. The first time I took it to the dealer they could not find any issues and told me to take pictures. I did, plenty of them. Monday 10-27 2025 I took it in again for the gas tank issue and camera issue. Being disabled due to serious spine issues I had to minimize waiting time. T…
Read full complaint
I have been having rear cameras for quite some time. The first time I took it to the dealer they could not find any issues and told me to take pictures. I did, plenty of them. Monday 10-27 2025 I took it in again for the gas tank issue and camera issue. Being disabled due to serious spine issues I had to minimize waiting time. The dealer preformed a radio update per 91-19-02 & MIB2 composition & discovered media info system malfunctions. I am currently under VW extended warranty 10 year 100000 mi but they charged me $225.00 for the update. This is exactly the same issue for recall #91SB. Apparently the issue goes back further than the recall, I believe that these issues were swept under the rug. Any help would be appreciated. [XXX] VW [XXX] [XXX] [XXX] [XXX] I believe that the recall is the tip of a very large problem INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11696492
Mileage unknown · Aug 23, 2024
Air BagsElectrical SystemSteering
Failure of wheel speed sensor in front right wheel. This is the THIRD time I have had a wheel speed sensor fail on this car, which has 35,000 miles on it. Failure caused loss of power steering, airbags, abs, etc.
NHTSA ODI #11610366
Mileage unknown · Jan 17, 2023
Electrical SystemEngineFuel/propulsion System
Car will stutter and stall. Usually after multiple short trips (5 stops and starts) in a short period of time (2 hours). 1 min/1000 gauge is fluttering around 0.75 on gauge when stopped. When car stalls it can be when pulling out at a stop sign. It will stall when gas is applied and then I need to coast around a corner. Occasi…
Read full complaint
Car will stutter and stall. Usually after multiple short trips (5 stops and starts) in a short period of time (2 hours). 1 min/1000 gauge is fluttering around 0.75 on gauge when stopped. When car stalls it can be when pulling out at a stop sign. It will stall when gas is applied and then I need to coast around a corner. Occasionally the car will stall out when driving between 20 and 30 miles per hour. When this happens it is extremely dangerous because I am driving in traffic and need to pull over to the side of the road. I had this problem fixed at the dealership once before in 2021 and it cost $559.08 then. I was told at the time that gas sometimes has sediment in it and I should not get gas at grocery store pumps where the price is lower. I should stick to better gas stations. I now am getting my gas at the same two better places all the time hoping that the problem wouldn’t happen again. The problem started two weeks ago and is following the same pattern. I scheduled a service appointment again for them to check my car but it never displays any codes and it is difficult for them to recreate the stalling. My car is almost at 85,000 miles when my warranty runs out.
NHTSA ODI #11502182
Mileage unknown · Dec 8, 2022
Electrical SystemPower Train
This is related to VW recal 37M2. My VIN is not in the recall list, but it has the exact same issue with the shifter assembly. The car does not recognize when the transmission is placed in Park. Unable to lock doors
NHTSA ODI #11496535
Mileage unknown · Jul 27, 2021
Electrical SystemStructure
Front and rear radio speakers are not sealed properly leading to rain leaking into the floor and body of the car. This has been reported significantly and frequently online. VW will fix my car for approximately $4500.
NHTSA ODI #11426639
21,500 miles · May 24, 2019
Electrical SystemSeat BeltsSeats
FOR THE PAST 2+ YEARS, I WILL HAVE HAD THIS CAR 3 YEARS IN NOV.2019, AND FOR THE PAST 2 YRS+ THE DEALER HAS NOT FOUND THE TROUBLE WITH THE DRIVER'S SIDE SEATBELT SENSOR COMING ON FOR NO REASON. IT COMES ON WHILE DRIVING, THE LDRIVER'S SIDE SEATBELT LIGHT COMES ON AND THE SENSOR STARTS BEEPING - THE WORST WAS OVER A HALF HOUR STR…
Read full complaint
FOR THE PAST 2+ YEARS, I WILL HAVE HAD THIS CAR 3 YEARS IN NOV.2019, AND FOR THE PAST 2 YRS+ THE DEALER HAS NOT FOUND THE TROUBLE WITH THE DRIVER'S SIDE SEATBELT SENSOR COMING ON FOR NO REASON. IT COMES ON WHILE DRIVING, THE LDRIVER'S SIDE SEATBELT LIGHT COMES ON AND THE SENSOR STARTS BEEPING - THE WORST WAS OVER A HALF HOUR STRAIGHT WHILE DRIVING HOME. IT HAS HAPPENED ON CITY STREETS- CANNOT RECALL IT ON HIGHWAY DRIVING. IN THE LAST FEW MONTHS THE SEATBELT UNIT WAS REPLACED- BUT THE LIGHTS AND BEEPING HAS RETURNED. I AM NOW THINKING IT MAY BE THE SEAT - SENSOR. NOT THE BELT. I READ/VIEWED VIDEOS THAT THERE WAS A SHORT IN THE ELECTRICAL OF SOME PEOPLE'S SEATBELT HOUSING, FIXED WITH WELDS. MOST RECENTLY IT IS HAPPENING MULTIPLE TIMES WHILE DRIVING. IT HAPPENED 7 TIMES WHILE DRIVING MY CAR FROM WORK TO THE DEALER, <10 MILES CITY STREET DRIVE. IT HAS NEVER BEEN REPRODUCED AND I DO NOT THINK ANY CODE WAS EVER SCANNED. THIS IS MY FIRST LEASE, AND AS SUCH I ONLY LET THE DEALER TACKLE IT. STILL NOT FIXED AND NOW MUCH, MUCH WORSE, WITH MULTIPLE OCCURRENCES AND NO RHYME OR REASON TO IT.
NHTSA ODI #11209670
Mileage unknown · Feb 15, 2019
Electrical SystemSteering
TL* THE CONTACT OWNS A 2017 VOLKSWAGEN GOLF. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V464000 (STEERING, ELECTRICAL SYSTEM). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. VOLKSWAGEN OF CHERRY HILL (2261 MARLTO…
Read full complaint
TL* THE CONTACT OWNS A 2017 VOLKSWAGEN GOLF. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V464000 (STEERING, ELECTRICAL SYSTEM). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. VOLKSWAGEN OF CHERRY HILL (2261 MARLTON PIKE W, CHERRY HILL, NJ 08002, (888) 486-1840) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *BF *TR
NHTSA ODI #11180256
2,500 miles · Jun 18, 2018
Air BagsElectrical SystemSeats
THE SUNROOF LEAKS WATER FROM ALL FOUR COUNTERS INTO THE VEHICLE: HEADLINER, SEATS, CARPET AND DASHBOARD. WARNING SIGNALS/ERRORS MESSAGES: AIR BAG, TRACTION, ENGINE LIGHT. 2500 MILES ON VEHICLE PURCHASED 3/18 NEW. THE VEHICLE WAS PARKED IN A DRIVEWAY DURING A MAJOR RAIN STORM.
NHTSA ODI #11102380
1,300 miles · Apr 13, 2017
Electrical SystemEngine
TL* THE CONTACT OWNS A 2017 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE HAD MISFIRED IN ALL CYLINDERS; HOWEVER, THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE DEALER CLEARED THE SYSTEM AND WARNING SENSORS AND ADVISED THE …
Read full complaint
TL* THE CONTACT OWNS A 2017 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE HAD MISFIRED IN ALL CYLINDERS; HOWEVER, THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE DEALER CLEARED THE SYSTEM AND WARNING SENSORS AND ADVISED THE CONTACT TO ALLOW THE VEHICLE TO WARM UP BEFORE DRIVING. IN ADDITION, THE FAILURE RECURRED TWO WEEKS LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT IT NEEDED A SOFTWARE UPDATE; HOWEVER, AN UPDATE WAS NOT AVAILABLE AT THE TIME. THE FAILURE OCCURRED A TOTAL OF THREE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 1,300. ..UPDATED 05/15/17 *BF *CN
NHTSA ODI #10972264
Official recalls
5Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
May 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Touareg GP, Tiguan, Golf A6, E-Golf GP, CCF, 2016-2017 Passat GP, 2018-2019 Golf R GP, and 2018 Atlas vehicles. These internal-use vehicles were sold without confirmation that they were built to all applicable regulatory requirements and may have been modified prior to sale. As such, these vehicles may fail to comply with the requirements of various Federal Motor Vehicle Safety Standards.
Consequence & remedy
Consequence: Vehicles that do not meet all regulatory requirements may have an increased risk of injury, crash, or fire.
Remedy: Volkswagen will repurchase the vehicles. Owner notification letters were mailed May 20, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01F1.
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Jul 11, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Dec 29, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence & remedy
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Additional source detail variants (4)
Air Bags:side/window
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Air Bags:frontal:driver Side:inflator Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Seat Belts:pretensioner
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Air Bags:frontal:passenger Side:inflator Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration