NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
18 reportsClear category filterMileage unknown · Jul 7, 2021
Engine
The thermostat housing and water pump are leaking due to a known manufacturing defect. I had the water pump and thermostat housing replaced around 65,000 miles from an independent Volkswagen mechanic. He informed me that it appears the water pump had been replaced prior to my ownership of the vehicle. (41,000 miles). Again, I ha…
Read full complaint
The thermostat housing and water pump are leaking due to a known manufacturing defect. I had the water pump and thermostat housing replaced around 65,000 miles from an independent Volkswagen mechanic. He informed me that it appears the water pump had been replaced prior to my ownership of the vehicle. (41,000 miles). Again, I have to replace the thermostat housing and water pump, for a leak. The failure causes a leak in the pressurized cooling system. The leak is small while parked so there is no noticeable puddle but as the system warms up, the leak happens faster. Because of this issue, I have had multiple warning messages while driving, low coolant level, check engine light, and EPC (Electronic Power Control, which disables activate cruise control and front collision detection systems). On multiple occasions, I was stranded waiting on help because of the failure. As stated, this is a known issue from the manufacturer, as they have had at least 7 revisions to the part. The manufacturer is currently on revision “M”, I am only aware of revisions “F, G, H, J, K, L” and the current revision “M”. As previously stated, this is the second time I personally have had to pay out of pocket for this repair.
NHTSA ODI #11423690
24,000 miles · May 11, 2021
Engine
2016 VW GOLF GTI MK7 ENGINE COOLANT BEGAN TO SLOWLY LEAK FROM THERMOSTAT HOUSING SEAL AT 25,000 MILES. DEALER REPLACED HOUSING WITH REV M PART JUST BEFORE MY WARRANTY EXPIRED. HAS THIS EVERY 25K MILE PROBLEM BEEN RESOLVED YET?
NHTSA ODI #11416209
37,000 miles · Mar 13, 2019
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2016 VOLKSWAGEN GOLF GTI. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THERE WAS A FUEL LEAK. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2016 VOLKSWAGEN GOLF GTI. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THERE WAS A FUEL LEAK. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 37,000.
NHTSA ODI #11186523
17,000 miles · Jun 3, 2018
Engine
CONSUMING OIL
NHTSA ODI #11099415
Mileage unknown · Jun 2, 2017
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2016 VOLKSWAGEN GOLF. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V647000 (FUEL SYSTEM, ENGINE AND ENGINE COOLING). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE VEHICLE DID NOT RECEIVE ADEQUATE FUEL MILEAGE AND THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT…
Read full complaint
TL* THE CONTACT OWNS A 2016 VOLKSWAGEN GOLF. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V647000 (FUEL SYSTEM, ENGINE AND ENGINE COOLING). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE VEHICLE DID NOT RECEIVE ADEQUATE FUEL MILEAGE AND THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE LOCAL DEALER (OURISMAN VOLKSWAGEN OF BETHESDA LOCATED AT 7001 ARLINGTON RD, BETHESDA, MARYLAND 20814) WAS CONTACTED AND INFORMED THE CONTACT THAT THEY HAD NOT RECEIVED PARTS FROM THE MANUFACTURER AND THAT THE CONTACT WAS PLACED ON A WAITING LIST. THE MANUFACTURER WAS MAKING FLORIDA AND PUERTO RICO A PRIORITY FIRST. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10992847
2,658 miles · Aug 23, 2016
Engine
ENGINE MISFIRED AND CAUSE THE CAR TO STUTTER WITH LOSS OF PERFORMANCE. THIS HAPPENED TO ME WHEN MAKING A LEFT HAND TURN NEARLY CAUSING AN ACCIDENT BECAUSE THE CAR WAS NOT MOVING AT THE NORMAL SPEED DUE TO LOSS OF PERFORMANCE. THIS IS THE 3RD TIME THE ENGINE HAS MISFIRED SINCE I BOUGHT THE CAR. IT HAS LESS THAN 2,800 MILES ON …
Read full complaint
ENGINE MISFIRED AND CAUSE THE CAR TO STUTTER WITH LOSS OF PERFORMANCE. THIS HAPPENED TO ME WHEN MAKING A LEFT HAND TURN NEARLY CAUSING AN ACCIDENT BECAUSE THE CAR WAS NOT MOVING AT THE NORMAL SPEED DUE TO LOSS OF PERFORMANCE. THIS IS THE 3RD TIME THE ENGINE HAS MISFIRED SINCE I BOUGHT THE CAR. IT HAS LESS THAN 2,800 MILES ON IT.
NHTSA ODI #10897865
800 miles · Jul 25, 2016
EngineFuel/propulsion SystemUnknown Or Other
SUDDEN VIOLENT SHAKING WHILE DRIVING. THEY REPLACED ALL FOUR FUEL INJECTORS, SECOND TIME HAPPENED A MONTH LATER. SHAKING WHILE DRIVING. THEY CANNOT FIX. MILES JUST UNDER 2000 ON SECOND OCCURRENCE.
NHTSA ODI #10888512
975 miles · Dec 29, 2015
Electrical SystemEngineFuel/propulsion System
SAFETY ISSUE - 2016 EGOLF WOULD NOT MOVE AFTER A ROUTINE TRAFFIC STOP WITH "MAIN CHARGING FAILED" ERROR. DURING A NORMAL COMMUTE AFTER 3, 4 MILES OF DRIVING 30 - 40 MPH, CAR WOULDN'T MOVE AFTER A ROUTINE TRAFFIC STOP RIGHT AFTER A TRAFFIC LIGHT. THIS IS EVENING 6PM RUSH HOUR TRAFFIC, CAR JUST STOPPED IN THE MIDDLE OF THE ROAD. W…
Read full complaint
SAFETY ISSUE - 2016 EGOLF WOULD NOT MOVE AFTER A ROUTINE TRAFFIC STOP WITH "MAIN CHARGING FAILED" ERROR. DURING A NORMAL COMMUTE AFTER 3, 4 MILES OF DRIVING 30 - 40 MPH, CAR WOULDN'T MOVE AFTER A ROUTINE TRAFFIC STOP RIGHT AFTER A TRAFFIC LIGHT. THIS IS EVENING 6PM RUSH HOUR TRAFFIC, CAR JUST STOPPED IN THE MIDDLE OF THE ROAD. WHILE REST OF THE SYSTEMS SEEM TO BE FUNCTIONING, THE CAR IGNITION IS ON, PRESSING ACCELERATOR PEDAL DOESN'T DO ANYTHING WITH "ELECTRICAL ERROR , STOP" MESSAGE ON THE DASH. AFTER GETTING STUCK IN A LANE FOR AN HOUR IN RUSH HOUR TRAFFIC, GOT THE CAR TOWED TO NEARBY VW DEALER. DEALER INFORMED THAT THE MAIN CHARGING MODULE THAT CHARGES BATTERY FAILED, WHICH NEEDS TO BE REPLACED WITH NEW PART FORM GERMANY. IT COULD TAKE UP TO TWO WEEKS. SAFETY ISSUE - THE FACT THAT CAR JUST STOPS WHILE DRIVING EVEN THOUGH THE BATTERY HAS PLENTY OF CHARGE LEFT POSES A SERIOUS AND SIGNIFICANT SAFETY RISK. A SERIOUS ACCIDENT IS JUST WAITING TO HAPPEN.I WAS TOLD THAT THE DESIGN PROTECTS DRIVERS AGAINST GETTING STRANDED AFTER BATTERY IS DISCHARGED, SINCE THE CHARGING MODULE FAILED. THIS SEEMS TOTALLY ILLOGICAL THAT THE DESIGN IS TRYING TO PROTECT YOU FROM STRANDED WHEN BATTERY RUNS OUT, SO IT RATHER STOP IN THE MIDDLE OF THE ROAD TO GET THE MODULE FIXED BEFORE YOU CAN DRIVE IT TO A SAFE PLACE. THERE ARE QUITE A FEW INCIDENTS REPORTED LIKE THIS, SO VW HAS A SERIOUS SAFETY ISSUE TO FIX ON 2016 EGOLF IMMEDIATELY. MAYBE IT REQUIRES A DESIGN FIX TO LET DRIVERS DRIVE TO A DEALER TO GET THE FAULTY PART TO BE FIXED, INSTEAD OF STRANDING IN THE MIDDLE OF THE ROAD.
NHTSA ODI #10816865
Official recalls
9Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Jul 27, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2016 Audi TT Roadster, TT Coupe, S3 Sedan, R8 Coupe, A3 Sedan, A3 Etron, A3 Cabriolet, 2016 Golf Sportwagen, Golf R, Golf GTI, Golf A7, and E Golf vehicles. During air bag deployment, the front passenger air bag may explode or deploy improperly.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking occupants, resulting in serious injury or death. An improper air bag deployment may not properly restrain the occupant, increasing their risk of injury in a crash.
Remedy: Dealers will replace the front-passenger air bag module, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Audi's customer service at 1-800-253-2834. Volkswagen's number for this recall is 69DY and 61C1.
Aug 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Jul 11, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
May 16, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2016 Eos, 2012 Passat, 2012-2016 CC, 2015-2016 e-Golf, 2011-2015 Touareg, 2012-2015 and 2017 Tiguan, and 2011-2016 Golf and 2011-2013 GTI vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners, and dealers will repair the vehicles to make them fully compliant or Volkswagen will repurchase them if necessary, free of charge. The recall began November 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298.
Sep 7, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence & remedy
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Additional source detail variants (2)
Fuel System, Gasoline
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Engine And Engine Cooling:exhaust System:emission Control
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Jun 6, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2016 Jetta vehicles manufactured October 31, 2015, to January 21, 2016, 2016 Passat vehicles, equipped with 1.8T engines manufactured November 13, 2015, to December 9, 2015, and 2016 Golf vehicles manufactured November 5, 2015, to November 11, 2015. In the affected vehicles, the fuel rail may detach from the cylinder head and result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
Remedy: Volkswagen will notify owners, and dealers will replace the cylinder heads, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 15F7.
Oct 26, 2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.
Consequence & remedy
Consequence: If the camshaft lobe shears off there would be a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Volkswagen dealer will update the engine control module (ECM) software. The recall began March 2016. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 23R1.
Additional source detail variants (2)
Engine And Engine Cooling:engine
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.
Consequence: If the camshaft lobe shears off there would be a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Volkswagen dealer will update the engine control module (ECM) software. The recall began March 2016. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 23R1.
Service Brakes, Hydraulic:power Assist:vacuum
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.
Consequence: If the camshaft lobe shears off there would be a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Volkswagen dealer will update the engine control module (ECM) software. The recall began March 2016. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 23R1.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration