NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
10 reportsClear category filterMileage unknown · Jun 8, 2026
Air BagsCrashInjury
I am reporting a severe safety system failure regarding the airbag deployment force on a 2016 Volkswagen Golf SE. The vehicle was involved in a collision where the frontal/side air bag safety systems engaged. While the impact speed was moderate, the airbag deployment was violently disproportionate, resulting in severe, direct in…
Read full complaint
I am reporting a severe safety system failure regarding the airbag deployment force on a 2016 Volkswagen Golf SE. The vehicle was involved in a collision where the frontal/side air bag safety systems engaged. While the impact speed was moderate, the airbag deployment was violently disproportionate, resulting in severe, direct injuries to the occupant rather than providing the intended safety cushioning or protection. The force of the deployment appeared heavily uncalibrated, acting as a primary source of trauma rather than an emergency restraint. In contrast, the secondary vehicle involved in the identical impact matrix sustained similar property damage but experienced a completely stable, non-injurious environment with no air bag enaged at all. I am requesting that NHTSA review this incident against existing vehicle data logs for 2016 Volkswagen Golf models to determine if there is an active trend of excessive pyrotechnic deployment force or uncalibrated SRS module sensors.
NHTSA ODI #11742727
Mileage unknown · May 11, 2023
Air BagsElectrical SystemForward Collision Avoidance
Airbag light came on, then all electrics to steering wheel failed, including the horn. Clock spring failed. Safety issue with no airbag and no horn. Known that VWs have a problem with clock spring failure. Should be a recall.
NHTSA ODI #11521624
Mileage unknown · Feb 2, 2023
Air Bags
The contact owns a 2016 Volkswagen Golf. The contact received notification of the NHTSA Campaign Number: 22V543000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact mentione…
Read full complaint
The contact owns a 2016 Volkswagen Golf. The contact received notification of the NHTSA Campaign Number: 22V543000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact mentioned that a recall notice was received confirming the remedy was available and to contact a local dealer however, the dealer informed that the part was not available for the recall remedy. The manufacturer was notified of the issue and confirmed that parts were unavailable. The contact had not experienced a failure. Parts distributions disconnect.
NHTSA ODI #11505133
Mileage unknown · Jan 24, 2023
Air BagsElectrical SystemVehicle Speed Control
First, the airbag warning light came on, then followed by the horn not working and cruise control was lost. I also suspecting the power steering is also gone. This is related to the clock spring failure from my research online. This should have been recall because this is a safety hazard.
NHTSA ODI #11503331
Mileage unknown · Oct 6, 2022
Air Bags
Takata recall. The contact owns a 2016 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 22V543000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made awa…
Read full complaint
Takata recall. The contact owns a 2016 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 22V543000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA ODI #11488155
70,000 miles · Dec 14, 2020
Air BagsElectrical SystemForward Collision Avoidance
ALL STEERING WHEEL CONTROLS INOPERATIVE. THIS INCLUDES AIRBAG, HORN, CRUISE CONTROL, RADIO CONTROLS, ETC.
NHTSA ODI #11383440
92,589 miles · Oct 22, 2019
Air BagsElectrical SystemStructure
SUNROOF DRAIN REINFORCEMENT STEEL HAS DEVELOPED STRESS CRACKS. WHICH HAS LET WATER LEAK INSIDE VEHICLE, ONTO HEADLINER AND DOWN A-PILLARS SATURATING FRONT SIDE CURTAIN AIRBAGS MAKING THEM DEFECTIVE. VEHICLE CAN BE STATIONARY OR OPERATED, IT WILL LEAK EITHER WAY. VOLKSWAGEN REFUSES TO ADDRESS ISSUE WITH AIRBAGS AND LEAK SAYING …
Read full complaint
SUNROOF DRAIN REINFORCEMENT STEEL HAS DEVELOPED STRESS CRACKS. WHICH HAS LET WATER LEAK INSIDE VEHICLE, ONTO HEADLINER AND DOWN A-PILLARS SATURATING FRONT SIDE CURTAIN AIRBAGS MAKING THEM DEFECTIVE. VEHICLE CAN BE STATIONARY OR OPERATED, IT WILL LEAK EITHER WAY. VOLKSWAGEN REFUSES TO ADDRESS ISSUE WITH AIRBAGS AND LEAK SAYING THERE IS NOT A SAFETY ISSUE SO THEY WONT COVER REPAIR WHICH COULD COST GREATER THAN $2,500. VEHICLE HAS ALSO DEVELOPED BLACK MOLD BETWEEN ROOF AND HEADLINER WHICH IS HAZARDOUS TO BREATH. TECHNICAL BULLETIN #60-17-01(V601701) IS THE REPAIR INSTRUCTIONS FOR DEALERSHIP ONLY REPAIR BUT DOES NOT INCLUDE AIRBAG REPLACE OR HEADLINER REPLACEMENT. I ADDRESSED ISSUE WITH VOLKSWAGEN MULTIPLE TIMES WHICH THEY DENY ANY SAFETY ISSUES. *TR
NHTSA ODI #11270298
44,500 miles · Aug 14, 2018
Air BagsElectronic Stability Control (esc)Service Brakes
THE LEFT REAR WHEEL SPEED SENSOR MALFUNCTIONED RESULTING IN FALSE WARNINGS OF AIR BAG, STABILIZATION CONTROL, ABS SYSTEM, AND TIRE PRESSURE FAILURES. A REPLACEMENT PART IS ON BACK ORDER AND/OR UNAVAILABLE. THIS WILL RESULT IN DISREGARD OF ANY OF THE ABOVE WARNINGS IN THE FUTURE EVEN IF THEY ARE GENUINE. THIS PROBLEM OCCURS RANDO…
Read full complaint
THE LEFT REAR WHEEL SPEED SENSOR MALFUNCTIONED RESULTING IN FALSE WARNINGS OF AIR BAG, STABILIZATION CONTROL, ABS SYSTEM, AND TIRE PRESSURE FAILURES. A REPLACEMENT PART IS ON BACK ORDER AND/OR UNAVAILABLE. THIS WILL RESULT IN DISREGARD OF ANY OF THE ABOVE WARNINGS IN THE FUTURE EVEN IF THEY ARE GENUINE. THIS PROBLEM OCCURS RANDOMLY AT ANY SPEED.
NHTSA ODI #11119886
46,000 miles · Jul 10, 2018
Air Bags
THE CLOCK SPRING ON MY CAR WENT BAD AFTER 46,000 MILES. MAKES AIRBAG UNUSEABLE AND STEERING COLUMN CONTROLS DO NOT WORK EITHER
NHTSA ODI #11110420
54,000 miles · Jun 5, 2018
Air BagsElectrical SystemSteering
DESPITE A 2015 RECALL, 2016 GOLFS ARE STILL BEING AFFECTED BY FAULTY CLOCK SPRING SETUPS AND A LACK OF SOME TYPE OF COVER THAT IS PREVENTING DEBRIS FROM GETTING INSIDE AND BREAKING THEM. WHILE DRIVING THE CAR, THE AIRBAG WARNING LIGHT WENT ON. I THEN NOTICED THAT NONE OF THE CONTROL FEATURES ON THE STEERING WHEEL WORKED..…
Read full complaint
DESPITE A 2015 RECALL, 2016 GOLFS ARE STILL BEING AFFECTED BY FAULTY CLOCK SPRING SETUPS AND A LACK OF SOME TYPE OF COVER THAT IS PREVENTING DEBRIS FROM GETTING INSIDE AND BREAKING THEM. WHILE DRIVING THE CAR, THE AIRBAG WARNING LIGHT WENT ON. I THEN NOTICED THAT NONE OF THE CONTROL FEATURES ON THE STEERING WHEEL WORKED.. NO CRUISE CONTROL, NOT HORN, NO SYSTEM DATA, ETC. UPON FURTHER INVESTIGATION I DISCOVERED THAT THE CLOCK SPRING WAS THE REASON FOR THE PROBLEM AND THAT THIS HAS BEEN AN ONGOING PROBLEM THAT VW HAS KNOWN ABOUT SINCE 2011. ONLY AFTER AN INVESTIGATION WAS VW FORCED INTO DOING A RECALL IN 2015. THE PROBLEM OBVIOUSLY STILL EXISTS SINCE THERE ARE A NUMBER OF CONTINUED COMPLAINTS STILL BEING FILED.
NHTSA ODI #11099933
Official recalls
9Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Jul 27, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2016 Audi TT Roadster, TT Coupe, S3 Sedan, R8 Coupe, A3 Sedan, A3 Etron, A3 Cabriolet, 2016 Golf Sportwagen, Golf R, Golf GTI, Golf A7, and E Golf vehicles. During air bag deployment, the front passenger air bag may explode or deploy improperly.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking occupants, resulting in serious injury or death. An improper air bag deployment may not properly restrain the occupant, increasing their risk of injury in a crash.
Remedy: Dealers will replace the front-passenger air bag module, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Audi's customer service at 1-800-253-2834. Volkswagen's number for this recall is 69DY and 61C1.
Aug 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Jul 11, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
May 16, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2016 Eos, 2012 Passat, 2012-2016 CC, 2015-2016 e-Golf, 2011-2015 Touareg, 2012-2015 and 2017 Tiguan, and 2011-2016 Golf and 2011-2013 GTI vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners, and dealers will repair the vehicles to make them fully compliant or Volkswagen will repurchase them if necessary, free of charge. The recall began November 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298.
Sep 7, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence & remedy
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Additional source detail variants (2)
Fuel System, Gasoline
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Engine And Engine Cooling:exhaust System:emission Control
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Jun 6, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2016 Jetta vehicles manufactured October 31, 2015, to January 21, 2016, 2016 Passat vehicles, equipped with 1.8T engines manufactured November 13, 2015, to December 9, 2015, and 2016 Golf vehicles manufactured November 5, 2015, to November 11, 2015. In the affected vehicles, the fuel rail may detach from the cylinder head and result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
Remedy: Volkswagen will notify owners, and dealers will replace the cylinder heads, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 15F7.
Oct 26, 2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.
Consequence & remedy
Consequence: If the camshaft lobe shears off there would be a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Volkswagen dealer will update the engine control module (ECM) software. The recall began March 2016. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 23R1.
Additional source detail variants (2)
Engine And Engine Cooling:engine
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.
Consequence: If the camshaft lobe shears off there would be a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Volkswagen dealer will update the engine control module (ECM) software. The recall began March 2016. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 23R1.
Service Brakes, Hydraulic:power Assist:vacuum
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.
Consequence: If the camshaft lobe shears off there would be a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Volkswagen dealer will update the engine control module (ECM) software. The recall began March 2016. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 23R1.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration