IllustrationTHE ABS PUMP & MODULE ARE DEFECTIVE. SUPPOSEDLY, A SHORT ON THE CIRCUIT BOARD CAUSES THIS MALFUNCTION AND NOW ABS AND ASR ARE NOT FUNCTIONING. REGULAR BRAKES ARE STILL WORKING. THIS SYSTEM PROBLEM SEEMS TO BE COMMON WITH VW AND IS A SAFETY ISSUE. *TR
2000 Volkswagen Golf
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Golf years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
925–50K
1050–75K
975–100K
3100–150K
2150K+
36 reports with mileage · 52 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports1 fire reports3 injury reports
Service Brakes, Hydraulic complaints
12 reports2000 VOLKSWAGEN GOLF CV JOINTS FAILED, RIGHT FRONT CALIPER FROZE, FAULTY STEERING HOSE. *TS THE BATTERY WAS REPLACED TWICE AND THE WHEEL BEARING FAILED AT AN UNUSUAL LOW MILEAGE. THE FRONT SEAT HAD A PIECE OF METAL THAT WAS MOLDED. *JB
2000 VOLKSWAGEN GOLF FRONT AXLE SHAFTS WERE REPLACED DUE TO CV JOINT FAILURE. THE RIGHT FRONT CALIPER FROZE, POWER STEERING HOSE HAD TO BE REPLACED DUE TO LEAKAGE LOCATED NEAR THE REAR OF THE HOSE. *TS ***NAR RECEIVED 10-20-05*** DUE TO THE CALIPERS BEING REPLACED, THE ROTORS HAD TO BE TURNED AND THE BRAKES HAD TO BE REPLACED.…
Read full complaint
2000 VOLKSWAGEN GOLF FRONT AXLE SHAFTS WERE REPLACED DUE TO CV JOINT FAILURE. THE RIGHT FRONT CALIPER FROZE, POWER STEERING HOSE HAD TO BE REPLACED DUE TO LEAKAGE LOCATED NEAR THE REAR OF THE HOSE. *TS ***NAR RECEIVED 10-20-05*** DUE TO THE CALIPERS BEING REPLACED, THE ROTORS HAD TO BE TURNED AND THE BRAKES HAD TO BE REPLACED. THE FRONT WHEEL BEARING WAS REPLACED. THE FRONT SEAT HAD A PIECE OF METAL THAT WAS MOLDED BREAK WHEN THE VEHICLE ONLY HAD 36,600 MILES ON IT. *JB
BOTH REAR OUTSIDE BRAKE PADS WORE DOWN TO THE METAL BACKING, WHILE ALL OTHER PADS WERE STILL SERVICEABLE. DEALERSHIP WAS NOTIFIED. *AK
WHEN DRIVING AT ANY SPEED BRAKE LIGHT APPEARED ON THE DASH. CONSUMER TOOK VEHICLE TO THE DEALERSHIP OVER TEN TIMES, BUT PROBLEM RECURRED. *AK
MY VOLKSWAGEN GOLF TDI HAD TO HAVE THE REAR ROTORS AND BRAKE PADS REPLACED WITH LESS THAN 30,000 MILES. THE FRONT BRAKES WERE STILL IN GOOD SHAPE. THE SERVICE PERSON NOTED THAT BRAKE DUST STICKS TO THE SLIDING PARTS AND CAUSES THE BRAKES TO STICK AND WEAR. THE REAR BRAKE PADS WERE TOTALLY WORN AND THE ROTORS SCORED. AT 36,0…
Read full complaint
MY VOLKSWAGEN GOLF TDI HAD TO HAVE THE REAR ROTORS AND BRAKE PADS REPLACED WITH LESS THAN 30,000 MILES. THE FRONT BRAKES WERE STILL IN GOOD SHAPE. THE SERVICE PERSON NOTED THAT BRAKE DUST STICKS TO THE SLIDING PARTS AND CAUSES THE BRAKES TO STICK AND WEAR. THE REAR BRAKE PADS WERE TOTALLY WORN AND THE ROTORS SCORED. AT 36,000 MILE MY CAR'S BRAKES ARE MAKING A GRINDING NOISES AGAIN WHEN THE BRAKE PEDAL IS NOT DEPRESSED.*AK
1. RUST ON BRAKES PAD GUIDES BLOCKED THE PADS ON THE ROTORS. ROTORS WERE WARPED FROM THE HEAT, BRAKE PAD ON LEFT REAR SIDE WORE FROM 1/2" ALL THE WAY TO THE METAL IN SHORT TIME. VEHICLE WAS INSPECTED TO THE DEALER FOR 30K SERVICE 25 DAYS PRIOR TO INCIDENT. VW CUSTOMER SERVICE CONSIDERS THE INCIDENT DUE TO "ELEMENTS AND NORMAL WE…
Read full complaint
1. RUST ON BRAKES PAD GUIDES BLOCKED THE PADS ON THE ROTORS. ROTORS WERE WARPED FROM THE HEAT, BRAKE PAD ON LEFT REAR SIDE WORE FROM 1/2" ALL THE WAY TO THE METAL IN SHORT TIME. VEHICLE WAS INSPECTED TO THE DEALER FOR 30K SERVICE 25 DAYS PRIOR TO INCIDENT. VW CUSTOMER SERVICE CONSIDERS THE INCIDENT DUE TO "ELEMENTS AND NORMAL WEAR AND TEAR". COST OF REPAIR: $418.74 NOT COVERED BY MANUFACTURER. 2. WINDOW CLAMPS AND CABLE DEFECTIVE, REPAIR COVERED BY THE MANUFACTURER, NO RECALL ON PARTS, HUNDREDS OF CASES EXPERIENCED BY THE DEALERSHIP, AS PER DEALERSHIP EMPLOYEES. NLM
ON MARCH 27, 2002, AT 26,795 MILES, I REQUESTED A 30,000 MILE SERVICE FROM ROSEVILLE VOLKSWAGEN. ROSEVILLE VOLKSWAGEN IS LOCATED AT 830 AUTOMALL DR., ROSEVILLE, CA 95661-3023 AND THE PHONE NUMBER THERE IS (916) 774-2777. DURING THE 30,000 MILE SERVICE, THE TECHNICIAN INDICATED ON THE MAINTENANCE WORKSHEET THAT THE FRONT BRAKE P…
Read full complaint
ON MARCH 27, 2002, AT 26,795 MILES, I REQUESTED A 30,000 MILE SERVICE FROM ROSEVILLE VOLKSWAGEN. ROSEVILLE VOLKSWAGEN IS LOCATED AT 830 AUTOMALL DR., ROSEVILLE, CA 95661-3023 AND THE PHONE NUMBER THERE IS (916) 774-2777. DURING THE 30,000 MILE SERVICE, THE TECHNICIAN INDICATED ON THE MAINTENANCE WORKSHEET THAT THE FRONT BRAKE PADS HAD 95% REMAINING WHILE THE REAR BRAKE PADS HAD ONLY 25% REMAINING, INDICATING A SERIOUS BRAKE SYSTEM ANOMALY. THE TECHNICIAN "INSTALLED NEW BRAKE PADS DUE TO PREMATURE WEAR" AS NOTED ON INVOICE #VWCS28623. I WAS NOT CHARGED FOR THE BRAKE PADS EVEN THOUGH I WAS OVER MY 24,000/2 YEAR WARRANTY. THE PREMATURE REAR BRAKE PAD WEAR NOTED COULD HAVE BEEN A SERIOUS HAZARD FOR ME, MY FAMILY, AND OTHER DRIVERS ON THE ROAD. I BELIEVE THAT THE UNDERLYING PROBLEM THAT RESULTED IN THE PREMATURE BRAKE PAD WEAR WAS NOT ADDRESSED AT THE TIME OF SERVICE AND THAT THIS REMAINS A SERIOUS SAFETY CONCERN IN THE FUTURE. I AM ALSO CONCERNED THAT THERE MAY BE MORE VW GOLF VEHICLES ON THE ROAD THAT MAY BE UNSAFE TO DRIVE DUE TO THIS IRREGULAR BRAKE PAD WEAR. THE DEALERSHIP OFFERED NO EXPLANATION FOR THE IRREGULAR BRAKE PAD WEAR AT THE TIME THE SERVICE WAS COMPLETED. VOLKSWAGEN OF AMERICA HAS BEEN CONTACTED BY PHONE AND IN WRITING IN AN EFFORT TO FIND OUT HOW COMMON THE PROBLEM IS, WHAT THE EXPLANATION FOR THE IRREGULAR BRAKE PAD WEAR IS, ETC. VOLKSWAGEN OF AMERICA HAS RESPONDED TO MY QUESTIONS WITH A LETTER SUGGESTING THAT I TAKE MY QUESTIONS UP WITH MY PREFERRED VOLKSWAGEN DEALER. AS I HAVE NOT MADE ANY PROGRESS IN THIS MATTER, I AM FORWARDING THE INFORMATION TO YOU. IF ANY FURTHER INFORMATION IS REQUIRED, PLEASE DO NOT HESITATE TO CONTACT ME. THANK YOU.*AK
REAR ROTORS AND PADS NEEDED TO BE REPLACED AT 27,830 MILES. WHILE THESE ARE PRIMARILY CIT/LOCAL MILES, I HAVE NEVER EXPERIENCED SUCH A PREMATURE FAILURE OF A BRAKE COMPONENT. THIS IS POSSIBLY A DSIGN FLA AND I WAS WONDERING IF THE NHSTA HAD A SECTION OF THEIR DATABASE THAT REFLECTED A SERIES OF THHESE FAILURES.*AK
I HAVE BEEN COMPLAINING ABOUT MY ABS TO MY DEALER SINCE I BOUGHT THE CAR. I HEARD THERE MAY BE A HIDDEN RECALL ON THEM NOW. PLEASE ADVISE. *AK
Official recalls
507V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
05V154000 · Fuel System, Gasoline:delivery:fuel Pump
Apr 19, 2005
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH GASOLINE ENGINES AND DOUBLE-LAYER FUEL TANKS, TENSION ON THE FUEL SUPPLY LINE MAY CAUSE THE FUEL PUMP SUPPLY NIPPLE TO CRACK WHICH COULD RESULT IN A LEAK.
Consequence & remedy
Consequence: LEAKING FUEL, IN THE PRESENCE OF AN IGNITION SOURCE, MAY CAUSE A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL SUPPLY LINE FOR TENSION, AND INSPECT THE FUEL PUMP SUPPLY NIPPLE FOR CRACKING. IF NECESSARY THE FUEL LINE AND THE FUEL PUMP WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
04V584000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
02V244000 · Equipment:other:owners/service/other Manual
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
00V280000 · Suspension:front:control Arm:upper Arm
Sep 20, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ONE OF TWO BRACKETS USED TO BOLT THE FRONT SUSPENSION CONTROL ARM IN FRONT OF THE VEHICLE TO THE BODY STRUCTURE MAY NOT HAVE BEEN WELDED SUFFICIENTLY.
Consequence & remedy
Consequence: THE CONTROL ARM COULD GRADUALLY LOOSEN AND ULTIMATELY SEPARATE FROM ITS BRACKET IN NORMAL DRIVING WHICH COULD CAUSE THE VEHICLE TO BE DIFFICULT TO CONTROL OR RESULT IN LOSS OF CONTROL. AS THE BRACKET LOOSENS, LOUD METALLIC KNOCKING SOUNDS IN FROM THE VEHICLE WILL BE HEARD.
Remedy: DEALERS WILL INSPECT THE BRACKET AND IF THE WELDING IS INSUFFICIENT, WILL REPLACE THE CONTROL ARM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04079 · Fuel Pump Leaks
Opened Nov 29, 2004 · Closed Apr 19, 2005
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
THIS INVESTIGATION WAS OPENED ON NOVEMBER 29, 2004, BASED ON FIVE CONSUMER REPORTS ALLEGING FUEL LEAKING FROM THE FUEL PUMP.BY LETTER OF APRIL 14, 2004, VOLKSWAGEN OF AMERICA (VOLKSWAGEN) NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 35,000 GOLF AND GTI VEHICLES MANUFACTURED IN WOLFSBURG GERMANY FOR THE NORTH AMERICAN MARKET.THE RECALLED VEHICLES ARE IN MODEL YEARS 1999 AND 2000 AND ARE EQUIPPED WITH GASOLINE ENGINES.VOLKSWAGEN HAS IDENTIFIED A CONDITION IN WHICH THE FUEL SUPPLY LINE FROM THE FUEL DELIVERY MODULE (PUMP) TO THE FUEL FILTER MAY COME UNDER TENSION. IN THIS CONDITION THE FUEL PUMP SUPPLY NIPPLE CAN CRACK, RESULTING IN A GASOLINE LEAK.VOLKSWAGEN DEALERS WILL INSPECT FOR TENSION ON THE FUEL LINE AND CRACKS IN THE FUEL PUMP SUPPLY NIPPLE.IF TENSION IS FOUND IN THE LINE, IT WILL BE REPLACED WITH A REVISED LINE.IF THE FUEL PUMP SUPPLY NIPPLE IS CRACKED, THE LINE AND THE PUMP WILL BE REPLACED.PLEASE SEE SAFETY RECALL 05V154 FOR DETAILS.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
THIS INVESTIGATION WAS OPENED ON NOVEMBER 29, 2004, BASED ON FIVE CONSUMER REPORTS ALLEGING FUEL LEAKING FROM THE FUEL PUMP.BY LETTER OF APRIL 14, 2004, VOLKSWAGEN OF AMERICA (VOLKSWAGEN) NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 35,000 GOLF AND GTI VEHICLES MANUFACTURED IN WOLFSBURG GERMANY FOR THE NORTH AMERICAN MARKET.THE RECALLED VEHICLES ARE IN MODEL YEARS 1999 AND 2000 AND ARE EQUIPPED WITH GASOLINE ENGINES.VOLKSWAGEN HAS IDENTIFIED A CONDITION IN WHICH THE FUEL SUPPLY LINE FROM THE FUEL DELIVERY MODULE (PUMP) TO THE FUEL FILTER MAY COME UNDER TENSION. IN THIS CONDITION THE FUEL PUMP SUPPLY NIPPLE CAN CRACK, RESULTING IN A GASOLINE LEAK.VOLKSWAGEN DEALERS WILL INSPECT FOR TENSION ON THE FUEL LINE AND CRACKS IN THE FUEL PUMP SUPPLY NIPPLE.IF TENSION IS FOUND IN THE LINE, IT WILL BE REPLACED WITH A REVISED LINE.IF THE FUEL PUMP SUPPLY NIPPLE IS CRACKED, THE LINE AND THE PUMP WILL BE REPLACED.PLEASE SEE SAFETY RECALL 05V154 FOR DETAILS.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
THIS INVESTIGATION WAS OPENED ON NOVEMBER 29, 2004, BASED ON FIVE CONSUMER REPORTS ALLEGING FUEL LEAKING FROM THE FUEL PUMP.BY LETTER OF APRIL 14, 2004, VOLKSWAGEN OF AMERICA (VOLKSWAGEN) NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 35,000 GOLF AND GTI VEHICLES MANUFACTURED IN WOLFSBURG GERMANY FOR THE NORTH AMERICAN MARKET.THE RECALLED VEHICLES ARE IN MODEL YEARS 1999 AND 2000 AND ARE EQUIPPED WITH GASOLINE ENGINES.VOLKSWAGEN HAS IDENTIFIED A CONDITION IN WHICH THE FUEL SUPPLY LINE FROM THE FUEL DELIVERY MODULE (PUMP) TO THE FUEL FILTER MAY COME UNDER TENSION. IN THIS CONDITION THE FUEL PUMP SUPPLY NIPPLE CAN CRACK, RESULTING IN A GASOLINE LEAK.VOLKSWAGEN DEALERS WILL INSPECT FOR TENSION ON THE FUEL LINE AND CRACKS IN THE FUEL PUMP SUPPLY NIPPLE.IF TENSION IS FOUND IN THE LINE, IT WILL BE REPLACED WITH A REVISED LINE.IF THE FUEL PUMP SUPPLY NIPPLE IS CRACKED, THE LINE AND THE PUMP WILL BE REPLACED.PLEASE SEE SAFETY RECALL 05V154 FOR DETAILS.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.