NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
59 reports16,000 miles · Mar 10, 2019
Structure
MARCH 10, 2019 BEGINNING ON 12/08/2016, MY VW HAS BEEN TO SERVICE FOR A LEAKING SUNROOF 4 TIMES (THE CAR WAS LESS THAN 3.5 YEARS OLD!). THE WATER HAS FILLED THE SPARE TIRE/SUBWOOFER WELL FULL, DRIPPED THROUGH THE LIGHTING AND ELECTRICAL SWITCHES OF THE ROOF, DRAINED INTO THE DASH AND SHIFTER AS WELL AS MY LAP WHILE DRIVING. A…
Read full complaint
MARCH 10, 2019 BEGINNING ON 12/08/2016, MY VW HAS BEEN TO SERVICE FOR A LEAKING SUNROOF 4 TIMES (THE CAR WAS LESS THAN 3.5 YEARS OLD!). THE WATER HAS FILLED THE SPARE TIRE/SUBWOOFER WELL FULL, DRIPPED THROUGH THE LIGHTING AND ELECTRICAL SWITCHES OF THE ROOF, DRAINED INTO THE DASH AND SHIFTER AS WELL AS MY LAP WHILE DRIVING. AND IT PRESENTS SO MUCH MOISTURE IN THE CAR THE WINDOWS WILL NOT DEFOG WITH THE A/C ON. VW MAINTENANCE DEPARTMENTS ALWAYS BLAME ME FOR DEBRIS CLOGGING THE ROOF DRAINS. I'VE SINCE BEEN INFORMED OF TWO TSBS ON THIS ROOF ADDRESSING THE FLAWED ENGINEERING. ALL THE DEALERSHIPS HAVE DONE IS CLEARED MY DRAIN HOSES AND ON THE 4TH RETURN, PRESENTED A $1,600 BILL FOR REMOVING AND REPLACING MY DRAINS. I REFUSED THE REPAIR AND HAVE DUCT TAPED MY ROOF TO PREVENT FURTHER WATER DAMAGE UNTIL THIS MATTER IS FORMALLY RESOLVED. VW CUSTOMER CARE HAS REFUSED TO PAY FOR THIS SERVICE CLAIMING IT IS A MAINTENANCE ISSUE. GIVEN WHERE I LIVE, THE CALIFORNIA CENTRAL VALLEY, DURING THE FIRST THREE YEARS OF OWNING THIS VEHICLE, WE RARELY HAD RAIN. APPROXIMATELY EVERY 8 MONTHS THE CAR HAS BEEN TAKEN TO A VW DEALERSHIP TO ADDRESS THE LEAKING ROOF.
NHTSA ODI #11185625
52,000 miles · Feb 19, 2019
Air BagsSteeringUnknown Or Other
CLOCK SPRING FAILED AT 52,000 MILES--AFFECTING BOTH THE AIRBAG AND HORN. VW REFUSED TO REIMBURSE ME FOR THE REPAIR, DESPITE THEIR CLOCK SPRING RECALL ON MULTIPLE VW MODELS, THAT WAS INITIATED BY NHTSA INVESTIGATION.
NHTSA ODI #11181182
60,936 miles · Feb 5, 2019
Electrical System
PROBLEM NOTICED DECEMBER 12TH WHEN ONE BY ONE ALL THE WARNING LIGHTS CAME ON INCLUDING THE AIR BAG, THE STABILIZATION SYSTEM, THE HEADLIGHT SYSTEM AND OTHERS. THEN WHEN I STOPPED AT A RED LIGHT, THE CAR WOULD NOT SHIFT OUT OF 1ST GEAR. I ENDED UP HAVING TO HAVE MY VEHICLE TOWED BACK HOME. THE NEXT DAY A MECHANIC SCANNED IT AND S…
Read full complaint
PROBLEM NOTICED DECEMBER 12TH WHEN ONE BY ONE ALL THE WARNING LIGHTS CAME ON INCLUDING THE AIR BAG, THE STABILIZATION SYSTEM, THE HEADLIGHT SYSTEM AND OTHERS. THEN WHEN I STOPPED AT A RED LIGHT, THE CAR WOULD NOT SHIFT OUT OF 1ST GEAR. I ENDED UP HAVING TO HAVE MY VEHICLE TOWED BACK HOME. THE NEXT DAY A MECHANIC SCANNED IT AND SAID THERE WAS A PROBLEM IN THE EMITIONS SYSTEM WHICH DISABLED THE CAR BY MAKING IT NOT ABLE TO DRIVE. I THEN HAD IT TOWED TO THE NEAREST VW DEALER WHO TOLD ME THAT THE WHOLE PROBLEM, INCLUDING THE FAILURE OF THE SAFETY SYSTEMS, WAS CAUSED BY A LEAK IN THE SUNROOF. WATER RAN DOWN THE A-PILLER AND SHORTED SOME WIRING. THEY GAVE ME A PRINT OUT WHERE VW ADMITS THAT THIS IS THE RESULT OF A PRODUCTION DEFECT BUT THEY SAID THAT IF THE DEFECT WAS NOT FOUND BEFORE THE WARRANTY RAN OUT THAT VW WOULD NOT ALLOW IT TO BE FIXED UNLESS I PAID THEM OVER $1,0000. AS IT IS, I HAD TO PAY THEM $240 TO TAKE THE TRIM OFF OF THE A-PILLER AND DRY THE WIRING OUT. THIS MADE THE CAR RUN NORMALLY FOR THE TIME BEING BUT NOW I AM AFRAID THAT IT WILL HAPPEN AGAIN.
NHTSA ODI #11174488
81,000 miles · Jan 1, 2019
Air BagsPower TrainVehicle Speed Control
THE DISPLAY SCREEN SAYS ERROR: AIRBAG, THEN IT SAYS ERROR: TRANSMISSION. ALL THE BOTTONS ON THE STREEING WHEEL DO NOT WORK CURSE CONTROL, BOTTONS FOR CHANGING THE DISPLAY TO SEE INFO ABOUT THE CAR, AND RADIO. THE CAR WAS DRIVING ON CITY STREETS WHEN THE MESSAGES FIRST WHERE NOTICED. I THINK IT HAS SOMETHING TO DO WITH INSIDE THE…
Read full complaint
THE DISPLAY SCREEN SAYS ERROR: AIRBAG, THEN IT SAYS ERROR: TRANSMISSION. ALL THE BOTTONS ON THE STREEING WHEEL DO NOT WORK CURSE CONTROL, BOTTONS FOR CHANGING THE DISPLAY TO SEE INFO ABOUT THE CAR, AND RADIO. THE CAR WAS DRIVING ON CITY STREETS WHEN THE MESSAGES FIRST WHERE NOTICED. I THINK IT HAS SOMETHING TO DO WITH INSIDE THE STEERING WHEEL AND THINK IT MIGHT BE THE CLOCK SPRING. THE FACT THAT IT IS SAYING ERROR: AIRBAG, I AM CONCERNED THAT THE AIRBAG WILL NOT WORK, OR MIGHT JUST GO OFF FOR NO REASON.
NHTSA ODI #11164399
30,100 miles · Nov 20, 2018
Service BrakesCrashInjury
THIS IS A 2015 TDI GOLF THAT SAT ON THE DEALER CAR LOT FOR MORE THAN TWO YEARS. WE BOUGHT IT SPRING 2018. MINIMAL MAINTENANCE DONE ON VEHICLE WHEN CAR WAS PURCHASED. IN FACT, WE BOUGHT THREE. TIRES HAD FLAT SPOTS, AND HAD TO ALL BE REPLACED. MY DAUGHTER'S CAR DEVELOPED SOFT BRAKES. MINE AS WELL, AND NOT STOPPING WELL. HER CAR…
Read full complaint
THIS IS A 2015 TDI GOLF THAT SAT ON THE DEALER CAR LOT FOR MORE THAN TWO YEARS. WE BOUGHT IT SPRING 2018. MINIMAL MAINTENANCE DONE ON VEHICLE WHEN CAR WAS PURCHASED. IN FACT, WE BOUGHT THREE. TIRES HAD FLAT SPOTS, AND HAD TO ALL BE REPLACED. MY DAUGHTER'S CAR DEVELOPED SOFT BRAKES. MINE AS WELL, AND NOT STOPPING WELL. HER CAR FAILED TO STOP, RESULTING IN A CRASH...THIS NEEDS TO BE CHECKED OUT THAT THE BRAKE FLUSH AND FLUID ARE REPLACED EARLIER THAN THE "RECOMMENDED" 30,000 MILE MAINTENANCE. BEFORE OTHERS ARE INJURED. PLEASE
NHTSA ODI #11152664
9,500 miles · Sep 14, 2018
Unknown Or OtherInjury
JUST IN FRONT OF THE SHIFTER AND BEHIND THE CENTER STORAGE CONSOLE, METALLIC TRIM ON PLASTIC PEELED UP LEAVING A RAZOR SHARP EDGE. I DID NOT SEE THIS DEFECT. AS I PULLED MY KEYS OUT OF THE CONSOLE, THE SMALLEST FINGER ON MY RIGHT HAND WAS BADLY SLICED, CAUSING QUITE A LOT OF BLEEDING. HAD I BEEN DRIVING AT THE TIME, THIS COULD H…
Read full complaint
JUST IN FRONT OF THE SHIFTER AND BEHIND THE CENTER STORAGE CONSOLE, METALLIC TRIM ON PLASTIC PEELED UP LEAVING A RAZOR SHARP EDGE. I DID NOT SEE THIS DEFECT. AS I PULLED MY KEYS OUT OF THE CONSOLE, THE SMALLEST FINGER ON MY RIGHT HAND WAS BADLY SLICED, CAUSING QUITE A LOT OF BLEEDING. HAD I BEEN DRIVING AT THE TIME, THIS COULD HAVE CAUSED AN ACCIDENT BECAUSE OF THE SURPRISE, PAIN, AMOUNT OF BLOOD AND THE DISTRACTION CAUSED BY THOSE THINGS. FORTUNATELY, I HAD JUST PARKED AT MY HOME AND WAS ABLE TO RUN INSIDE AND STANCH THE BLOOD FLOW.
NHTSA ODI #11129543
70,500 miles · Feb 21, 2018
Air Bags
LOUD SNAPPING SOUND WHILE TURNING, AIRBAG WARNING LIGHT ILLUMINATED, LOST ALL ELECTRICAL FUNCTIONS OF STEERING WHEEL, INCLUDING HORN & AIRBAG. VEHICLE WAS IN MOTION. HAD VEHICLE EXAMINED, CODES PULLED, DETERMINED IT WAS FAILURE OF THE CLOCK SPRING MECHANISM.
NHTSA ODI #11074193
22,836 miles · Jan 23, 2018
Structure
TL* THE CONTACT OWNS A 2015 VOLKSWAGEN GOLF SPORTWAGEN. WHILE DRIVING UNKNOWN SPEEDS, THE REAR DRIVER AND PASSENGER DOORS OPENED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO VIC BAILEY VOLKSWAGEN (2671 REDVILLE RD, SPARTANBURG, SC 29301). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. T…
Read full complaint
TL* THE CONTACT OWNS A 2015 VOLKSWAGEN GOLF SPORTWAGEN. WHILE DRIVING UNKNOWN SPEEDS, THE REAR DRIVER AND PASSENGER DOORS OPENED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO VIC BAILEY VOLKSWAGEN (2671 REDVILLE RD, SPARTANBURG, SC 29301). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 22,836.
NHTSA ODI #11064477
46,000 miles · Aug 25, 2017
Power Train
I OWN A 2015 VW GOLF SPORTWAGEN WITH A LITTLE OVER 46,000 MILES. THE LEFT FRONT WHEEL BEARING HAS GONE BAD AND WAS DIAGNOSED AND REPLACE (OEM ONLY) BY A VW SPECIALTY GARAGE. I WAS ALSO INFORMED AND CAN HEAR, THE RIGHT FRONT BEARING GOING BAD AS WELL. IT ALL STATED WITH A LOW HUM WHICH CHANGED PITCH WITH THE SPEED OF THE CAR. O…
Read full complaint
I OWN A 2015 VW GOLF SPORTWAGEN WITH A LITTLE OVER 46,000 MILES. THE LEFT FRONT WHEEL BEARING HAS GONE BAD AND WAS DIAGNOSED AND REPLACE (OEM ONLY) BY A VW SPECIALTY GARAGE. I WAS ALSO INFORMED AND CAN HEAR, THE RIGHT FRONT BEARING GOING BAD AS WELL. IT ALL STATED WITH A LOW HUM WHICH CHANGED PITCH WITH THE SPEED OF THE CAR. OVER TIME IT GOT LOUDER AND LOUDER UNTIL I FINALLY TOOK IT IN TO A DIAGNOSIS. I RESEARCHED THE INTERNET AND FOUND MANY GEN 3 LATE MODEL GOLFS WITH THE SAME PROBLEM. DEFECTIVE WHEEL BEARINGS. WHEEL BEARINGS SHOULD NOT FAIL WITH ONLY 40,000 MILES ON THE CAR. I STILL HAVE THE ORIGINAL TIRES! VW CLAIMS ITS NOT COVERED UNDER THE POWER TRAIN WARRANTY, BUT THIS IS A FRONT WHEEL DRIVE CAR AND THE AXLES GO THRU THIS BEARING! PLEASE INVESTIGATE.
NHTSA ODI #11019792
Official recalls
3Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Sep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
Jul 11, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration