IllustrationTHE BRUSHED ALUMINUM TRIM AROUND THE GEARSHIFT SELECTOR PEELS UP LEAVING A RAZOR SHARP EDGE , THIS HAS CUT MY HAND ON MORE THAN ON OCCASION AS I REACHED INTO THE STORAGE COMPARTMENT BELOW THE INFOTAINMENT CENTER. THIS HAS HAPPENED WHILE DRIVING ON THE HIGHWAY AND ON CITY STREETS. THE GEARSHIFT TRIM WAS REPLACED @35,000 MILES
2015 Volkswagen Golf Sportwagen
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2015 Volkswagen Golf Sportwagen do not stand out strongly from the model-year median of 25.
About this comparison →How this year compares
Owner complaints by model year
Compare all Golf Sportwagen years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
825–50K
850–75K
475–100K
1100–150K
0150K+
27 reports with mileage · 32 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports5 injury reports
What owners actually said
59 reportsINFORMATION SCREEN / RADIO, STOP WORKING PROPERLY BACK UP BACK UP CMERA SCREEN DOESN'T WORK.
THIS CAR WAS PURCHASED AS A CERTIFIED VEHICLE AFTER RECEIVING THE EMISSIONS FIX. AFTER LESS THAN 10,000 MILES AND ONLY ONE YEAR OF OWNERSHIP, ALL MY DASHBOARD WARNING LIGHTS CAME ON (INCLUDING AIRBAG ERROR) AND THE FLOOR MATS WERE SOAKED WHEN I STARTED MY CAR AFTER A SEVERE RAIN STORM. I WAS TOLD THE SUNROOF DRAINS WERE PLUGG…
Read full complaint
THIS CAR WAS PURCHASED AS A CERTIFIED VEHICLE AFTER RECEIVING THE EMISSIONS FIX. AFTER LESS THAN 10,000 MILES AND ONLY ONE YEAR OF OWNERSHIP, ALL MY DASHBOARD WARNING LIGHTS CAME ON (INCLUDING AIRBAG ERROR) AND THE FLOOR MATS WERE SOAKED WHEN I STARTED MY CAR AFTER A SEVERE RAIN STORM. I WAS TOLD THE SUNROOF DRAINS WERE PLUGGED AND CAUSED THE ELECTRICAL ISSUES. THE DRAIN BEING PLUGGED WITH DEBRIS IS CONSIDERED AN EXTERNAL FACTOR AND THEREFORE THE REPAIRS ARE NOT COVERED BY THE WARRANTY OF THIS CERTIFIED CAR. THE OWNER'S MANUAL INDICATES THAT MAINTENANCE ON THE SUN ROOF DRAINS IS RECOMMENDED AT 40,000 MILES. AS NOTED, THE CAR WAS BELOW THE 40,000 MARK BUT HAD SAT IDLE FOR OVER A YEAR BETWEEN THE TIME IT WAS BOUGHT BACK FROM THE ORIGINAL CUSTOMER TO WHEN IT WAS SOLD AS A CERTIFIED VEHICLE.
TL* THE CONTACT OWNS A 2015 VOLKSWAGEN GOLF SPORTWAGEN. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED AN INCH OF WATER INSIDE THE SUN ROOF. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO NORTH PENN VOLKSWAGEN (LOCATED AT 165 BETHLEHEM PIKE, COLMAR, PA 18915, (215) 822-1361) WHERE IT WAS DIAGNOSED …
Read full complaint
TL* THE CONTACT OWNS A 2015 VOLKSWAGEN GOLF SPORTWAGEN. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED AN INCH OF WATER INSIDE THE SUN ROOF. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO NORTH PENN VOLKSWAGEN (LOCATED AT 165 BETHLEHEM PIKE, COLMAR, PA 18915, (215) 822-1361) WHERE IT WAS DIAGNOSED THAT THE DRAIN HOSES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,000. THE VIN WAS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2015 VOLKSWAGEN GOLF SPORTWAGEN. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT SPOKE WITH EAST COAST VOLKSWAGEN (8756-C, US HIGHWAY 17 BYPASS SOUTH, MYRTLE BEACH, SC 29588, (843) 353-1118) AND WAS INFORMED TO BRING THE VEHICLE IN TO BE DIAGNOSED. WHILE DRIVING TO THE DEALER…
Read full complaint
TL* THE CONTACT OWNS A 2015 VOLKSWAGEN GOLF SPORTWAGEN. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT SPOKE WITH EAST COAST VOLKSWAGEN (8756-C, US HIGHWAY 17 BYPASS SOUTH, MYRTLE BEACH, SC 29588, (843) 353-1118) AND WAS INFORMED TO BRING THE VEHICLE IN TO BE DIAGNOSED. WHILE DRIVING TO THE DEALER, THE CRUISE CONTROL AND HORN FAILED TO OPERATE. THE DEALER DIAGNOSED THE VEHICLE WITH A DEFECTIVE CLOCKSPRING. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 15V483000 (AIR BAGS), BUT THE VIN WAS EXCLUDED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 77,000.
STEERING COLUMN CONTROL MODULE WITH CLOCK SPRING FAILED,/ MILES ON CAR 54302. ALL BUTTONS ON STEERING WHEEL STOPPED WORKING. NO HORN, AIR BAG LIGHT ON AS MALFUNCTION, REPORTS STATE HAZARDOUS TO DRIVE... TOOK IT IN FOR REPLACEMENT--COST 668.52. OTHER VW HAVE HAD THIS PROBLEM AS A RECALL.. PLEASE ADD TO LIST OF V…
Read full complaint
STEERING COLUMN CONTROL MODULE WITH CLOCK SPRING FAILED,/ MILES ON CAR 54302. ALL BUTTONS ON STEERING WHEEL STOPPED WORKING. NO HORN, AIR BAG LIGHT ON AS MALFUNCTION, REPORTS STATE HAZARDOUS TO DRIVE... TOOK IT IN FOR REPLACEMENT--COST 668.52. OTHER VW HAVE HAD THIS PROBLEM AS A RECALL.. PLEASE ADD TO LIST OF VW HAVING THIS PROBLEM AND INSIST VW PAY OR RECALL TO HAVE THEM FIX THIS DANGEROUS PROBLEM. I PULLED INTO PARKING SPOT WHEN IT ALL STOPPED. GOOD THIS I WAS BACK HOME AND NOT STILL UP IN THE SIERRAS
TODAY WITH ONLY 16000 MILES THE POWER BRAKES STOPPED WORKING AND REQUIRED THAT I USE THE EBRAKE AND USE BOTH FEET ON THE BRAKE PEDAL, THE ENGINE WAS STILL RUNNING I SUSPECT THERE IS A BRAKE BOOSTER PROBLEM
THE PUSH START BUTTON NOT WORKING NEED PRESS MULTIPLE TIME JUST TO START THE CAR ALSO APPLY WHEN I NEED TURN THE CAR OFF . I NEED PRESS PUSH AND START MULTIPLE TIME JUST TO TURN OFF THE CAR.
LEAKING SUNROOF - VOLKSWAGEN WILL NOT WARRANTY. PURCHASED MY VEHICLE 2 YEAR AGO AS A BRAND NEW VEHICLE. THIS VW GOLF SPORTWAGEN WAS PART OF THE DIESEL EMISSION RECALL AND I PURCHASED IT AFTER THEY RELEASED THE VEHICLES AS A BRAND NEW VEHICLE. LESS THAN 200 MILES ON THE VEHICLE. HAD A HEADLINER STAIN FROM WATER LEAKAGE. VEHICLE S…
Read full complaint
LEAKING SUNROOF - VOLKSWAGEN WILL NOT WARRANTY. PURCHASED MY VEHICLE 2 YEAR AGO AS A BRAND NEW VEHICLE. THIS VW GOLF SPORTWAGEN WAS PART OF THE DIESEL EMISSION RECALL AND I PURCHASED IT AFTER THEY RELEASED THE VEHICLES AS A BRAND NEW VEHICLE. LESS THAN 200 MILES ON THE VEHICLE. HAD A HEADLINER STAIN FROM WATER LEAKAGE. VEHICLE SAT IN A LOT FOR 2 YEARS UNMOVED NEAR TREES WHICH LIKELY CAUSED THE LEAK. DEALERSHIP REPLACED HEADLINER. 1 YEAR LATER I NOTICED A LARGE STAIN IN THE BACK NEAR REAR HATCH. RESEARCHED ISSUE AND MAY WITH SAME MK7 BODY HAVING SAME ISSUES. TOOK BACK TO A DEALER AND THEY SAID LEAK WAS DUE TO "OUTSIDE INFLUENCE". VW OF AMERICA TOLD ME THEY WILL NOT WARRANTY HEADLINER DUE TO OUTSIDE CIRCUMSTANCES. I DO NOT PARK UNDER TREES AND THE "OUTSIDE INFLUENCE" IS FAULTY DRAIN LINES AND DAMAGES OCCURRED AT THE DEALERSHIP. VW WILL NOT WARRANTY LEAK. VEHICLE HAS BEEN IN A DEALER 4 TIMES SINCE MAY 2017 FOR THE SAME ISSUE WITH NO RESOLVE OTHER THAN " WE CAN NOT DUPLICATE THE ISSUE" WHILE THERE IS OBVIOUSLY A LEAK! I FEEL COMPLETELY STABBED IN THE BACK BY VW AND CAN NOT BELIEVE THIS HAS NOT BEEN A RECALL WITH SO MANY PEOPLE HAVING THE SAME ISSUE, AND VW BUYING BACK ALLTRACKS FOR THE SAME PROBLEM (SAME MK7 BODY) VERY DISAPPOINTED IN SPENDING SO MUCH MONEY ON A BROKEN VEHICLE.. LOVE THE CAR, DO NOT LOVE WATER INSIDE MY CAR.
TL* THE CONTACT OWNS A 2015 VOLKSWAGEN GOLF SPORTWAGEN. WHILE BACKING INTO THE DRIVEWAY, THE AIR BAG INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO PRESTIGE VOLKSWAGEN (321-309-8989, LOCATED AT 1416 S HARBOR CITY BLVD, MELBOURNE, FL 32901) WHERE IT WAS DIAGNOSED THAT THE CLOCKSPRING NEEDED TO BE REPLACED. THE MANUFACTURER WAS N…
Read full complaint
TL* THE CONTACT OWNS A 2015 VOLKSWAGEN GOLF SPORTWAGEN. WHILE BACKING INTO THE DRIVEWAY, THE AIR BAG INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO PRESTIGE VOLKSWAGEN (321-309-8989, LOCATED AT 1416 S HARBOR CITY BLVD, MELBOURNE, FL 32901) WHERE IT WAS DIAGNOSED THAT THE CLOCKSPRING NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 44,784. *BF CONSUMER STATED OTHER MODELS OF VW HAVE BEEN RECALLED FOR THIS SAME THING. THIS MODEL SHOULD HAVE BEEN AS WELL, ESTIMATE FROM PRESTIAGE VW $135.00 DIAGNOSIS, $727.54 REPAIR/TAX/ X CHARGES. AIR BAG FAILURE LIGHT CAME ON AS I WAS BACKING INTO THE DRIVEWAY AT ABOUT 1 MPH. 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB
Official recalls
324V110000 · Fuel System, Gasoline
Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
19V679000 · Unknown Or Other
Sep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
18V464000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Steering:column LOCKING:ANTI-THEFT Device
Jul 11, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.