Engine And Engine Cooling. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports4 fire reports2 injury reports

Vehicle Speed Control complaints

1 reports

Clear category filter

31,570 miles · Dec 10, 2004

Electrical SystemService Brakes, HydraulicVehicle Speed Control

Read full complaint

WE HAVE EXPERIENCED REPEATED ELECTRICAL PROBLEMS WITH 2002 VOLKSWAGEN EUROVAN. MANY ELECTRICAL COMPONENTS HAVE BEEN REPLACED, INCLUDING GENERATOR, BATTERY, THROTTLE CONTROLS, AND AN ABS SENSOR. THE PROBLEMS PERSISTS. *AK THE MOST DANGEROUS IS THAT THE BRAKE WARNING LIGHT COMES ON RANDOMLY, APPARENTLY FOR NO REASON. WE CANNOT TELL WHETHER THERE IS A BRAKE FAILURE, OR ERRONEOUS WARNING. THE DEALER HAS LOOKED AT THIS PROBLEM MORE THAN FIVE TIMES, AND HAS NOT BEEN ABLE TO FIX IT. TODAY THE BRAKE WARNING LIGHT CAME ON, AND AT THE SAME TIME BOTH WINDSHIELD WIPERS FAILED. WE HAD TO STOP IN THE MIDDLE OF THE ROAD, DURING A HEAVY RAINSTORM, TURN THE CAR "OFF", THEN RESTART TO GET THE BRAKE WARNING LIGHT TO GO OFF AND THE WINDSHIELD WIPERS TO RUN. OBVIOUSLY IT IS DANGEROUS TO BE DRIVING WITH ZERO VISIBILITY, AND THEN TO HAVE TO STOP IN THE MIDDLE OF TRAFFIC TO RESTART THE CAR. VW NEEDS TO CORRECT SYSTEMWIDE ELECTRICAL PROBLEMS WITH THE 2002 VW EUROVAN.

NHTSA ODI #10102633

Official recalls

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA08002 · Engine Cooling Fan Blade Fracture

Opened Jan 4, 2008 · Closed Mar 14, 2008

Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan

THE SUBJECT VEHICLES ARE BUILT ON A VOLKSWAGEN EUROVAN CHASSIS AND ARE CLASS C MOTOR HOMES. ON SEPTEMBER 5, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AS RQ 07-002 AFTER RECEIVING FOUR CONSUMER REPORTS OF FAN BLADE FAILURE ON MODEL YEAR 2002 WINNEBAGO RIALTA AND VISTA VEHICLES.AS A RESULT OF ADDITIONAL INFORMATION RECEIVED FROM VOLKSWAGEN IN RESPONSE TO RQ 07-002, THE INVESTIGATION WAS UPGRADED TO ENGINEERING ANALYSIS (EA) 08-002.THE SCOPE OF THE EA INVESTIGATION WAS ALSO EXPANDED TO COVER MODEL YEARS 2001 THROUGH 2004 RIALTA AND VISTA, 2002 THROUGH 2004 SUNSTAR, AND 2001 THROUGH 2003 EUROVAN.ALL OF THESE VEHICLES UTILIZE THE SAME ENGINE COOLING FAN.HOWEVER, THE WINNEBAGO VEHICLES ARE LARGER AND HEAVIER THAN THE EUROVAN.AS A CONSEQUENCE, THE COOLING FAN WOULD OPERATE MORE FREQUENTLY IN THE WINNEBAGO VEHICLES COMPARED TO THE EUROVAN FOR THE SAME ON-ROAD OPERATING CONDITIONS.ANALYSIS OF THE AVAILABLE DATA CONCERNING THE PROBLEM EXPERIENCE INDICATES THAT IT PREDOMINATELY AFFECTS THE MY 2002 WINNEBAGO MODELS.WINNEBAGO ACCOUNTS FOR 79% OF ALL THE REPORTS, BUT REPRESENTS ONLY 23% OF THE TOTAL SUBJECT VEHICLE POPULATION.THE MAJORITY OF THE WINNEBAGO REPORTS ARE FOR THE MODEL YEAR 2002 (64%).THE DATA SHOW A DECLINING REPORT TREND, PARTICULARLY FOR THE 2002 WINNEBAGO.REPORTS ON THE 2002 WINNEBAGO REACHED A HIGH OF 11 REPORTS IN CALENDAR YEAR 2005, DROPPING TO THREE REPORTS IN 2006,TWO REPORTS IN 2007, AND ONE REPORT IN 2008.AN EXISTING SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

RQ07002 · Engine Cooling Fan Blade Fracture

Opened Sep 5, 2007 · Closed Jan 4, 2008

Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION BASED ON FOUR REPORTSALLEGING FAILURE OF AN ENGINE COOLING FAN IN THE SUBJECT VEHICLES.THREE OF THE COMPLAINANTS ALLEGED THE FAN DISINTEGRATED AND TWO OF THE THREE ALLEGED THE RADIATOR WAS DAMAGED AS A RESULT.THE FOURTH COMPLAINANT ALLEGED THAT HIS VEHICLE EXPERIENCED VIOLENT SHAKING AND OVERHEATING.WHEN THE VEHICLE WAS INSPECTED, IT WAS NOTED THAT PIECES OF THE FAN WERE MISSING.ALL FOUR VEHICLES WERE CLASS C MOTOR HOMES BUILT ON A VOLKSWAGEN EUROVAN CHASSIS.TWO OF THE VEHICLES ARE RIALTA MODELS AND TWO ARE VISTA MODELS.BASED ONADDITIONAL INFORMATION RECEIVED FROM VOLKSWAGEN ODI IS UPGRADING THIS INVESTIGATION TOENGINEERING ANALYSIS EA 08-002 FOR FURTHER STUDY.