2002 Volkswagen Eurovan

FOR THE SECOND TIME THE COOLING FAN ASSEMBLY ON MY VOLKSWAGEN VANAGON (WINNEBAGO RIALTA CONVERSION) HAS FAILED CATASTROPHICALLY. THE FAN BLADE SHATTERED BOTH TIMES LEAVING ME STRANDED ON THE SIDE OF THE ROAD WHEN THE VAN BEGAN SHAKING VIOLENTLY. VOLKSWAGEN REFUSED TO OFFER ANY ASSISTANCE WHATSOEVER. I NOTICE THAT YOU HAVE AN OPEN INVESTIGATION ON THIS ISSUE. I WOULD LIKE TO JOIN THAT INVESTIGATION AS A CO-COMPLAINANT. IN BOTH CASES THIS HAPPENED ON ONE OF THE HOTTEST DAYS OF THE YEAR. IN ALABAMA, THIS TIME , THE HEAT INDEX WAS OVER 110 DEGREES. THE PREVIOUS TIME WAS IN TENNESSEE WHEN THE HEAT INDEX WAS ALSO OVER 100 DEGREES, AND 3 OF MY GRANDCHILDREN WERE IN THE CAR WITH ME. IN BOTH CASES I WAS STRANDED WITH PASSENGERS ON THE SIDE OF THE ROAD. WHILE THIS IS NOT THE SAME AS A BRAKE FAILURE, IT CLEARLY REPRESENTS A MANUFACTURING AND/OR DESIGN DEFECT THAT COULD HAVE SERIOUS CONSEQUENCES. VOLKSWAGEN IS OF COURSE THE SOLE SUPPLIER OF THE NECESSARY PARTS AND REFUSES TO DISCUSS ANY POTENTIAL PROBLEMS OTHER THAN TO SAY " NO ONE CAN PREDICT THE LIFE OF A PART ", WHICH IS NEITHER TRUE NOR RELEVANT. A CURSORY SEARCH OF THE INTERNET TURNED UP A HOST OF SIMILAR COMPLAINTS - ALL OF WHICH VW REFUSED TO AMELIORATE IN ANY WAY. I APPRECIATE YOUR ATTENTION TO THIS PROBLEM ON BEHALF OF AMERICAN CONSUMERS. THANK YOU. *TR

I WAS DRIVING MY 2002 VW EUROVAN OVER A CAUSEWAY GOING APPROXIMATELY 55 MPH. A WARNING LIGHT FLASHED SEVERAL TIMES THEN WENT OFF. I BELIEVE IT WAS A COOLANT LIGHT. THEN A STRANGE THUMP, THUMP, THUMP NOISE CAME FROM UNDER THE HOOD FOLLOWED BY SMOKE. SMELLED LIKE BURNING RUBBER AND SOUNDED LIKE A BELT BREAKING. I PULLED OFF AS SOON AS POSSIBLE (ANOTHER MINUTE OR 2) AND CAR DIED AS I COASTED OFF THE RAMP. I OPENED THE HOOD, BUT COULDN'T SEE PAST THE BLACK PLASTIC ENGINE COVER AND DIDN'T KNOW HOW TO REMOVE IT. AFTER SEVERAL PHONE CALLS, ABOUT 10 - 15 MINUTES LATER, SMOKE STARTED BILLOWING FROM UNDER HOOD. MY CHILDREN AND I DASHED AWAY FROM VEHICLE AND STOOD BY AND WATCHED IT BURN. CAR WAS IN GOOD REPAIR. I HAVE NO IDEA WHAT HAPPENED. BUT IT IS TOASTED LIKE A MARSHMALLOW. *TR

WE JUST EXPERIENCED A EXPENSIVE ($4500) PROBLEM WITH THE VOLKSWAGEN EUROVAN/WINNEBAGO RIALTA. ACTUALLY THE PROBLEM WAS RELATIVELY MINOR BUT BECAME MAJOR BECAUSE OF THE VW ENGINEERING. A SPROCKET THAT PART OF THE CAMSHAFT CHAIN DRIVE ASSEMBLY WAS WORN TO THE POINT THAT IT WAS ALMOST COMPLETELY ROUNDED. THIS CAUSED THE TIMING CHAIN TO JUMP. THE WARRANTY IS 50,000 MILES. THE PROBLEM STARTED AT 52, 000 MILES. I HAD IT REPAIRED AT 55,000 MILES. A LITTLE RESEARCH ON THE WEB SHOWS IT TO BE A KNOWN PROBLEM. THE SPROCKET APPARENTLY WAS NOT PROPERLY HARDENED ON A FEW OF THE VR-6 ENGINES. THE ABNORMAL WEAR STARTED FROM THE DAY THE ENGINE WAS ASSEMBLED BUT TOOK 52,000 MILES TO SHOW-UP. A DESCRIPTION OF THE PROBLEM WITH PHOTOS CAN BE VIEWED ON MY WEB PAGE AT: HTTP://WWW.REESPHOTOS.COM/VW/VW.HTM *JB

TL*THE CONTACT OWNS A 2002 VOLKSWAGEN EUROVAN. THE CONTACT NOTICED VIBRATION IN THE STEERING WHEEL AND HEARD A NOISE COMING FROM THE ENGINE COMPARTMENT. THE FAILURES WOULD OCCUR ONLY WHEN THE ENGINE WAS RUNNING. THE COOLING FAN FAILED, BUT THE VEHICLE DID NOT OVERHEAT. THE SPEED WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 112,000.

WHILE TRAVELING ON A UPHILL PAVED ROAD GRADE AROUND 11 AM GOING AT A SLOW SPEED, APPROXIMATELY 25 MPH AND THE BLADE ON THE COOLING FAN ON THE 2002 VOLKSWAGEN EUROVAN BROKE OFF. FAN WAS UNBALANCED AND BEGAN TO VIOLENTLY SHAKE. ENGINE WAS TURNED OFF AND THE FAN STILL CONTINUED TO RUN VIOLENTLY SHAKING THE VAN, FINALLY STOPPED AND IN ABOUT 5 MINUTES THE FAN TURNED ON AGAIN VIOLENTLY SHAKING THE VAN. RIALTA HAS A RECALL FOR THE SAME VOLKSWAGEN PROBLEM WITH FAN BLADES SEPARATING FROM COOLING FAN. NHTSA RECALL. 04V107000/VOLKSWAGEN RECALL NO. WB NHTSA CASE NUMBER PE0315 OPENED ON APRIL 2003 AND CLOSED AUGUST 2003. WHAT WAS THE FINAL OUT COME OF THE INVESTIGATION? THIS IS A ON GOING SAFETY ISSUE, THERE ARE OTHER CASES POSTED ON YAHOO WEB SITE. VOLKSWAGEN ISSUE FAN WARNING LABELS (LABEL WAS ISSUED A FEW YEARS AGO, WHEN I ASKED FOR DATE OF ISSUE VW DID NOT HAVE ANY DATE ON RECORD! I RECEIVED THIS LABEL A FEW YEARS AGO.) TO BE AFFIXED TO THE ENGINE COMPARTMENT WARNING OF FAN BLADE HAZARDS. LABEL STATES "DO NOT PROP ANYTHING AGAINST RADIATOR FAN, PUSH AGAINST THEM IN ANY OTHER WAY. A DAMAGED RADIATOR FAN COULD BREAK WHEN TURNING AT HIGH SPEED AND CUASE SEROIUS PERSONAL INJURY. SEE REPAIR MANUAL . CONTACTED VW CORPORATE ,, CASE NUMBER HAS BEEN FILED) AND DAN WILDER PORT ANGLES WAS WHERE VAN WAS PURCHASED. VAN WAS STILL UNDER POWER TRAIN WARRANTLY 5 YRS AND 60,000 MILES. NEITHER WOULD TELL ME IF FAN WAS COVERED BY WARRANTY. FAN HAS NOT BEEN REPAIRED YET. *AK

TL*THE CONTACT OWNS A 2002 VOLKSWAGEN EUROVAN. WHILE DRIVING AT 30 MPH THE VEHICLE STALLED. THE CONTACT STATED THAT THIS FAILURE OCCURRED ON SEVERAL OCCASIONS. ALSO, THE CONTACT STATED THAT THE GENERATOR AND BATTERY INDICATORS REMAINED ILLUMINATED ON THE INSTRUMENT PANEL. ON FEBRUARY 23, 2006, THE ENGINE FAN WAS REPAIRED ON THE VEHICLE AND COST THE CONTACT $977. THE DEALER STATED THAT THE CONTACT NEEDED TO PAY AN ADDITIONAL $92 FOR THE DIAGNOSTICS OF THE GENERATOR. THE CONTACT WAS ISSUED CASE # 60034264 BY THE MANUFACTURER. THE CURRENT MILEAGE IS 37,000 AND FAILURE MILEAGE WAS 15,000.*AK