2002 Volkswagen Eurovan

THE FRONT PASSENGER SEAT HEATER BURNED THROUGH THE SEAT FABRIC. THE BURN-THROUGH LOCATION IS ON THE VERTICAL SURFACE OF THE SEAT, MID-LINE, AT ABOUT THE LUMBAR HEIGHT. PLEASE REFER TO THE ATTACHED PHOTOGRAPH. A PASSENGER WAS SEATED IN THE AFOREMENTIONED SEAT WHEN THE BURN-THROUGH OCCURRED. THE VEHICLE WAS IN MOTION AT HIGHWAY SPEED AT THE TIME OF THE BURN-THROUGH, BUT THE PASSENGER WAS NOT INJURED.

I WAS DRIVING MY DAUGHTER TO SCHOOL TODAY AND WE HAD PUT THE HEATED SEATS ON IN MY 2002 VW EUROVAN. AS WE APPROACHED THE SCHOOL MY DAUGHTER YELLED OUCH AND GRABBED HER BACK. WE DISCOVERED A HOLE IN THE SEAT THAT HAD BURNED THROUGH THE SEAT FABRIC AND BURNED A HOLE IN HER NORTH FACE JACKET. IT HAD STARTED TO HEAT UP HER SHIRT BUT LUCKILY SHE FELT IT BEFORE IT GOT EVEN HOTTER. THIS COULD HAVE CAUSED A SEVERE BURN TO HER BACK. SHE HAD A LARGE RED PATCH ON HER LOWER BACK BUT NOTHING MORE. THIS IS A MAJOR HAZARD TO THE PASSENGER AND DRIVER - AS BOTH SEATS ARE HEATED AND COULD HAVE THIS PROBLEM AT ANY TIME. I HAVE READ MULTIPLE COMPLAINTS ONLINE AND THERE ARE SOME AS RECENT AS THIS YEAR ALREADY. IT SOUNDS TO ME THAT VW WILL NOT DO ANYTHING TO REMEDY THE SITUATION, WHICH IS RIDICULOUS AS IT IS A SAFETY ISSUE. I HAVE NEVER RECEIVED A RECALL FOR SUCH A PROBLEM AND IT SOUNDS TO ME LIKE MANY OTHERS HAVE NOT EITHER. *TR

HEATED FRONT PASSENGER SEAT SMOLDERING. NO FIRE. MANUFACTURER WILL NOT CORRECT. OUT OF WARRANTY. PASSENGER SEAT HEATING ELEMENT PREVIOUSLY REPLACED UNDER EXTENDED VEHICLE WARRANTY. HEATING ELEMENT BURNED THROUGH CLOTH FABRIC. I BELIEVE THIS TO BE A MANUFACTURER DEFECT THAT DOES PRESENT A FIRE DANGER AND THERE SHOULD BE A RECALL. *TR

TL*THE CONTACT OWNS A 2002 VOLKSWAGEN EUROVAN. WHILE DRIVING AT 30 MPH THE VEHICLE STALLED. THE CONTACT STATED THAT THIS FAILURE OCCURRED ON SEVERAL OCCASIONS. ALSO, THE CONTACT STATED THAT THE GENERATOR AND BATTERY INDICATORS REMAINED ILLUMINATED ON THE INSTRUMENT PANEL. ON FEBRUARY 23, 2006, THE ENGINE FAN WAS REPAIRED ON THE VEHICLE AND COST THE CONTACT $977. THE DEALER STATED THAT THE CONTACT NEEDED TO PAY AN ADDITIONAL $92 FOR THE DIAGNOSTICS OF THE GENERATOR. THE CONTACT WAS ISSUED CASE # 60034264 BY THE MANUFACTURER. THE CURRENT MILEAGE IS 37,000 AND FAILURE MILEAGE WAS 15,000.*AK

WE HAVE EXPERIENCED REPEATED ELECTRICAL PROBLEMS WITH 2002 VOLKSWAGEN EUROVAN. MANY ELECTRICAL COMPONENTS HAVE BEEN REPLACED, INCLUDING GENERATOR, BATTERY, THROTTLE CONTROLS, AND AN ABS SENSOR. THE PROBLEMS PERSISTS. *AK THE MOST DANGEROUS IS THAT THE BRAKE WARNING LIGHT COMES ON RANDOMLY, APPARENTLY FOR NO REASON. WE CANNOT TELL WHETHER THERE IS A BRAKE FAILURE, OR ERRONEOUS WARNING. THE DEALER HAS LOOKED AT THIS PROBLEM MORE THAN FIVE TIMES, AND HAS NOT BEEN ABLE TO FIX IT. TODAY THE BRAKE WARNING LIGHT CAME ON, AND AT THE SAME TIME BOTH WINDSHIELD WIPERS FAILED. WE HAD TO STOP IN THE MIDDLE OF THE ROAD, DURING A HEAVY RAINSTORM, TURN THE CAR "OFF", THEN RESTART TO GET THE BRAKE WARNING LIGHT TO GO OFF AND THE WINDSHIELD WIPERS TO RUN. OBVIOUSLY IT IS DANGEROUS TO BE DRIVING WITH ZERO VISIBILITY, AND THEN TO HAVE TO STOP IN THE MIDDLE OF TRAFFIC TO RESTART THE CAR. VW NEEDS TO CORRECT SYSTEMWIDE ELECTRICAL PROBLEMS WITH THE 2002 VW EUROVAN.

I CAN NOT FIND THE COMPLAINT WHERE I ALREADY DESCRIBED A DANGEROUS EVENT WHICH CAUSED THE ENGINE TO RACE, BUCK, LURCH THE CAR FORWARD AT AN INTERSECTION, BUT PLEASE CROSS REFERENCE THIS INFORMATION WITH THE VIN NUMBER OF THE PREVIOUS COMPLAINT. I HAVE NOW PROVIDED MORE INFO ABOUT PREVIOUS ELECTRICAL AND MECHANICAL FAILURES IN THIS CAR. WE BELIEVE IT IS UNSAFE TO DRIVE, A DANGER TO US AND THE PUBLIC AT LARGE. WE WANT VW TO TAKE THIS CAR OUT OF SERVICE AND PROVIDE A REPLACEMENT VEHICLE. THANK YOU FOR INVESTIGATING. THE CAR IS PRESENTLY IN OUR POSSESSION AND THEY HAVE BEEN UNABLE TO DIAGNOSE OR FIX THE ENGINE RACING PROBLEM AND ELECTRICAL PROBLEMS HAVE PLAGUED THE CAR FROM THE BEGINNING! DT

THIS VEHICLE HAD PREVIOUSLY HAD MANY ELECTRICAL PROBLEMS AND OTHER DEFECTS, THOUGH THIS HAS BEEN THE WORST, THE MOST SCARY THING THAT HAPPENED WITH THIS CAR, AND THE THINK THAT COULD HAVE CAUSED A SERIOUS ACCIDENT, POTENTIALLY INJURING OR KILLING OURSELVES OR OTHERS. FORTUNATELY, IT HAPPENED AT A DESERTED INTERSECTION ON A RURAL ROAD. BUT THE ENGINE DID NOT STOP RACING, BUCKING, WITH THE CAR LURCHING FORWARD UNTIL THE KEY WAS TURNED SO THAT ENGINE STOPPED ALTOGETHER. UPON STARTING THE CAR AGAIN, THE SAME THING HAPPENED. WE THEREFORE HAD TO SIT AT THE INTERSECTION, PARTWAY OUT INTO TRAFFIC UNTIL TRYING AGAIN, THE ENGINE STARTED NORMALLY. WE HAVE CONMPLAINED ABOUT THIS OVER AND OVER AND ARE TOLD THAT THE ENGINE IS WORKING ACCORDING TO SPECIFICATIONS. I FORGOT TO INCLUDE THE DATE. IT WAS THURSDAY EVENING SEPTEMBER 26TH, 2002. WE WERE IN CANADA AND PREVIOUS PROBLEMS WITH THE CAR HAD YIELDED THE INFORMATION THAT WE COULD NOT GET SERVICE FOR OUR VEHICLE IN CANADA AS IT WAS NOT SOLD THERE. THUS, FAR FROM HOME, WE NEVERTHELESS HAD TO RETURN TO MILWAUKEE AFTER THE INCIDENT. WE HAVE DRIVEN THE CAR VERY LITTLE SINCE THAT DAY AND HAVE REPEATEDLY TRIED TO GET SOMEONE TO UNDERSTAND THAT THIS VEHICLE IS NOT SAFE TO DRIVE AND NOT SAFE TO BE ON THE ROAD. THE INCIDENT OCCURED FOLLOWING GOING DOWN A VERY STEEP HILL (A 12% GRADE AS I RECALL) IN LOW GEAR AND THEN SHIFTING BACK INTO DRIVE AND NEEDING TO COME TO A STOP AT A "T". IT WAS AT THE "T" THAT THIS OCCURRED. EVEN THOUGH NO PROBLEM HAS BEEN DIAGNOSED WHICH MIGHT HAVE LED TO THIS INCIDENT, IT OCCURRED ONCE! ONCE WAS ENOUGH. MIND YOU, WE WERE NEAR THE END OF A 24 DAY CAMPING TRIP AND WE HAD GONE UP AND DOWN MANY MOUNTAINS, USING THE LOW GEAR REPEATEDLY WITH SUCH A PROBLEM. IT COULD HAVE HAPPENED WHILE PASSING OR ON A MOUNTAIN CURVE. WE WANT THE CAR TAKEN OUT OF SERVICE IF NOTHING CAN BE EXPLAINED OR FIXED! DT