2006 Volkswagen Beetle

2006 VW BEETLE, 6-SPD AUTOMATIC WITH 62,000 MILES. CAR BEGAN SLIPPING BETWEEN GEARS ON A TYPICAL TRIP ALONG INTERSTATE 95. CAR WAS TOWED INTO A DEALERSHIP WHERE A TECHNICIAN DETERMINED THAT THERE WAS MOISTURE IN THE TRANSMISSION AND IT WOULD NEED TO BE COMPLETELY REPLACED FOR AN ESTIMATED $7,000. I'VE CALLED SEVERAL PRIVATE TRANSMISSION REPAIR SHOPS AND AM TOLD THAT NEITHER VW NOR ANY AFTERMARKET COMPANIES SELL PARTS TO REPAIR THE TRANSMISSION. THE CAR IS STILL NOT REPAIRED AS THE VALUE OF THE CAR, APPROX $9,000 DOES NOT WARRANTY $7,000 REPAIR. I HAVE BEEN IN CONTACT VIA ONLINE FORUMS WITH SEVERAL OWNERS FROM 2003 TO 2007 WITH THE SAME PROBLEM. ACCORDING TO MANY, VW DEALERSHIP TECH'S SEEM TO SYSTEMATICALLY BLAME THESE PROBLEMS ON MINOR DINGS AND DENTS TO THE UNDERCARRIAGE OF THE CARS THAT "MAY" HAVE CAUSED THE PROBLEMS. *TR

I WAS DRIVING AND THE CLUTCH SEEMED TO BE DIFFERENT. IT IS HARD TO EXPLAIN HOW BUT WHEN YOU ARE THE DRIVER 99% OF THE TIME YOU KIND OF KNOW. ON WEDNESDAY APRIL 22 I DEPRESSED TO CLUTCH COMING TO A STOP AND HEARD A DEFINITE NOISE. THEN AS I WAS PULLING OFF FROM THE STOP IN 1ST GEAR THE CAR DID NOT WANT TO MOVE EASY. THERE WAS ANOTHER NOISE AS I WAS RELEASING THE CLUTCH, AS WELL. THERE IS JUST OVER 29000 MILES ON THE 2006 VW NEW BEETLE. I WAS ABLE TO CONTINUE WITHOUT CAUSING AN INCIDENT. I THANK GOD FOR HELPING ME TO RECOGNIZE A PROBLEM AND MAKE SLOW EASY MOVES. I HOPE THERE DOES NOT NEED TO BE AN ACCIDENT, DEATH, FIRE TO SUSPECT A CONTINUING PROBLEM WITH A CAR TO LODGE A COMPLAINT TO REVIEW THE CAUSE. *TR

MY WIFE WAS DRIVING HER 2006 VW NEW BEETLE ON HIGHWAY, WITHOUT WARNING THE CLUTCH HAD A SUDDEN FAILURE AND SHE WAS UNABLE TO SHIFT GEARS AND ALMOST RESULTED IN A VERY SERIOUS ACCIDENT ON THE EXPRESSWAY. VEHICLE HAD 30,000 MILES AND NO PREVIOUS TROUBLE NOTED ON THIS 1,9L TDI MANUAL TRANSMISSION. SAME ENGINE AND CLUTCH AS LISTED IN A VW SERVICE BULLETIN FOR 2005/2006 JETTA. BULLETIN STATES THAT CLUTCH FRICTION MATERIAL MAY HAVE A DEFECT CAUSING PREMATURE WEAR,BURNING,SHREDDING AND BREAKING AND WARRANTY WAS EXTENDED TO 4YR/50,000 MILES ON THE JETTA. DEALER WOULD NOT HONOR THE WARRANTY AND BLAMED THE SUDDEN FAILURE ON A WEAR AND TEAR ISSUE OR DRIVER ABUSE EVEN THOUGH THERE IS A BULLETIN OUT CONCERNING THE SACHS CLUTCH ASSEMBLY. REPAIR WAS OVER $2200. 6 MONTHS REMAINING ON ORIGINAL WARRANTY. THIS CLUTCH SHOULD BE RECALLED. *TR

THE VEHICLE HAS BEEN EXPERIENCING DIFFICULTY SHIFTING GEARS. AT TIMES WHILE DRIVING THE VEHICLE AUTOMATICALLY GOES INTO 2ND GEAR WHERE IT REMAIN UNTIL THE KEY IS REMOVED. THE DEALER INDICATES THE 'MEGATRONIC' SHIFTING CONTROLLER IS BAD. HOWEVER THE PART IS ON BACK ORDER FROM THE FACTORY AND THERE IS A 7-10 DELAY IN SHIPMENT FROM THE FACTORY. IT SEEMS THIS SEEMS TO BE A COMMON PART FAILURE. *TR

DUAL MASS FLYWHEEL BLEW APART AT 2200 MILES THEN AT 7,800 MILES ON A 2006 BEETLE TDI. I AM NOW ON BOTH TIMES HAPPENED DOWN SHIFTING FROM 5TH TO 4TH GEAR. HAVE DRIVEN MANUAL SHIFTS ALL MY LIFE NEVER HAD THIS HAPPEN. WAS TOLD BY DEALER THAT DMF HAS A HARD TIME HANDLING TORQUE. I WAS STILL LESS THAN 3000 RPM WHEN DROPPING INTO 4TH GEAR WHEN THE FLYWHEEL BROKE. THIS SHOULD NEVER HAPPEN AS IT SHOULD BE ABLE TO HANDLE THIS AMOUNT OF TORQUE AS A STANDARD OPERATING PROCEDURE. LUCKILY I WAS ABLE TO PULL OFF TO THE SIDE OF THE ROAD AS ALL MY TRANSMISSION OPERATION WAS LOST. *NM

DT*: THE CONTACT STATED WHILE ATTEMPTING TO APPLY BRAKE PRESSURE AT ALL SPEEDS, THE BRAKES WENT TO THE FLOOR AND WOULD NOT RETURN TO THE NORMAL UP POSITION. THE DRIVER HAD TO PULL UP ON THE BRAKE PEDAL TO APPLY BRAKE PRESSURE. ALSO, THE TRANSMISSION FAILS TO MAINTAIN ENGAGED WHEN INCLINED. ALTHOUGH THE DEALER WAS ALERTED NO INSPECTIONS HAVE BEEN MADE.