AIR BAG SYSTEM HAS BEEN DEFECTIVE SINCE DELIVERY OF THE CAR. THE AIR BAG WARNING LIGHT CAME ON WITH IN DAYS OF PURCHASE, THE CAR HAS BEEN RETURNED TO THE DEALER FOR REPAIR ON AT LEAST 5 OCCASIONS, HAS BEEN IN THE SHOP FOR THE PAST 2.5 WEEKS AND THEY ARE SAYING IT MAY BE AS MUCH AS 3 MORE MONTHS BEFORE THE PROBLEM CAN BE RESOLVED…
Read full complaint
AIR BAG SYSTEM HAS BEEN DEFECTIVE SINCE DELIVERY OF THE CAR. THE AIR BAG WARNING LIGHT CAME ON WITH IN DAYS OF PURCHASE, THE CAR HAS BEEN RETURNED TO THE DEALER FOR REPAIR ON AT LEAST 5 OCCASIONS, HAS BEEN IN THE SHOP FOR THE PAST 2.5 WEEKS AND THEY ARE SAYING IT MAY BE AS MUCH AS 3 MORE MONTHS BEFORE THE PROBLEM CAN BE RESOLVED BECAUSE OF A SOFTWARE PROBLEM WITH THE AIR BAG SYSTEM. IF THIS IS TRUE THEN ALL THE 2005 VW BEETLES WOULD BE AFFECTED BY THE SAME SAFETY ISSUE
VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.
Consequence & remedy
Consequence: IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.
Remedy: DEALERS WILL INSPECT EACH VEHICLE TO DETERMINE THAT THE SPECIFIC DEFECT CRASH SENSOR IS PRESENT ON ONE OR BOTH SIDES OF THE VEHICLE. ALL OF THE DEFECT CRASH SENSORS WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 31, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration