TL* THE CONTACT OWNS A 2003 VOLKSWAGEN BEETLE. WHILE THE VEHICLE WAS AT A STOP LIGHT, THE BRAKE PEDAL WAS APPLIED; HOWEVER, THE VEHICLE FAILED TO STOP AND ROLLED BACK. IN ADDITION, WHILE DRIVING AT UNKNOWN SPEEDS, THE ACCELERATOR PEDAL WAS APPLIED; HOWEVER, THE VEHICLE FAILED TO RESPOND AND THE SAFE MODE ENGAGED. THERE WERE NO W…
Read full complaint
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN BEETLE. WHILE THE VEHICLE WAS AT A STOP LIGHT, THE BRAKE PEDAL WAS APPLIED; HOWEVER, THE VEHICLE FAILED TO STOP AND ROLLED BACK. IN ADDITION, WHILE DRIVING AT UNKNOWN SPEEDS, THE ACCELERATOR PEDAL WAS APPLIED; HOWEVER, THE VEHICLE FAILED TO RESPOND AND THE SAFE MODE ENGAGED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 133,437.
NHTSA ODI #11156761
79,000 miles · Dec 21, 2014
Service Brakes
EPC LIGHT ILLUMINATED. BRAKE LIGHTS INOP. REPLACED BRAKE LIGHT SWITCH. VOLKSWAGEN CUSTOMER SERVICE STATED THE SWITCH HAD BEEN REPLACED UNDER RECALL IN 2007. *TR
VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.
Consequence & remedy
Consequence: IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.
Remedy: DEALERS WILL INSPECT EACH VEHICLE TO DETERMINE THAT THE SPECIFIC DEFECT CRASH SENSOR IS PRESENT ON ONE OR BOTH SIDES OF THE VEHICLE. ALL OF THE DEFECT CRASH SENSORS WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 31, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08012 · Front Air Bag Crash Sensor Failure
Opened Feb 15, 2008 · Closed Apr 24, 2008
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CERTAIN SUBJECT VEHICLES, MODEL YEAR (MY) 2003 CONVERTIBLE AND MY 2004 SEDAN AND CONVERTIBLE VEHICLES ARE EQUIPPED WITH AN ADVANCED DUAL-STAGE AIR BAG SYSTEM.THE AIR BAG CRASH SENSORS (#1F0 909 606) CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS.IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE CONTROL MODULE WILL ENABLE A FALLBACK ALGORITHM THAT WILL ENSURE THAT THE FRONT AIR BAG ALWAYS DEPLOYS IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.HOWEVER, IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.VOLKSWAGEN WILL INSPECT FOR THE DEFECTIVE CRASH SENSOR AND REPLACE WITH AN UPDATED DESIGN.IN ADDITION, 16,177 EARLY-MY 2005 NEW BEETLE SEDAN AND CONVERTIBLE VEHICLES (BUILT THROUGH OCT 31, 2004) ARE ALSO INCLUDED IN THE RECALL CAMPAIGN.THIS PRELIMINARY EVALUATION IS CLOSED (SEE RECALL 08V-178)
2003 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration