ON JUNE 13TH I WAS DRIVING MY CAR AND I WENT TO TURN OFF THE AC AND IT MADE A LOUD CLICKING NOISE, AFTER THE NOISE THE AC WOULDN'T TURN OFF SO I ENDED UP DRIVING 3 HOURS WITH THE AC FULL BLAST. A FEW DAYS AFTER THIS I WAS ABLE TO TURN OFF THE AC, AND LEFT IT LIKE THIS FOR ABOUT 2 WEEKS. AT THIS POINT THE MIDDLE KNOB WAS STUCK AN…
Read full complaint
ON JUNE 13TH I WAS DRIVING MY CAR AND I WENT TO TURN OFF THE AC AND IT MADE A LOUD CLICKING NOISE, AFTER THE NOISE THE AC WOULDN'T TURN OFF SO I ENDED UP DRIVING 3 HOURS WITH THE AC FULL BLAST. A FEW DAYS AFTER THIS I WAS ABLE TO TURN OFF THE AC, AND LEFT IT LIKE THIS FOR ABOUT 2 WEEKS. AT THIS POINT THE MIDDLE KNOB WAS STUCK AND THE AC WOULD RANDOMLY WORK AND NO LONGER WOULD TURN AT ALL. ON JUNE 30TH AS I WAS LEAVING THE PARKING LOT OF MY APARTMENT AND WENT TO TURNED ON THE AC, IT MADE A WEIRD NOISE BUT I CONTINUED DRIVING ANYWAYS. THE AC STOPPED WORKING SO I TURNED THE KNOB AGAIN AND I STARTED GETTING A BURNING SMELL, I LOOKED DOWN AND SAW SMOKE COMING OUT FROM BEHIND THE KNOB SO I DROVE BACK TO MY APARTMENT BECAUSE I DECIDED IT WASN'T SAFE TO DRIVE ON THE FREEWAY. IN A MATTER OF A MINUTE THE SMOKE GOT WORSE AND STARTED COMING OUT FROM THE ENTIRE AREA UNDER MY RADIO. I PARKED MY CAR ONCE I GOT BACK HOME AND STOOD OUTSIDE AS I ALLOWED MY CAR TO AIR OUT, NOT LONG AFTER THIS I SAW FLAMES COMING OUT FROM THE MIDDLE KNOB AND GROWING BIGGER. I WAS LUCKILY ABLE TO PUT IT OUT WITH A CUP OF WATER AND WAS FORCED TO CALL 911 TO MAKE SURE THE FIRE WAS COMPLETELY OUT. THIS IS ONE OF THE WORST EXPERIENCES THAT HAS EVER HAPPENED TO ME AND IT WAS TERRIFYING, IF I DIDN'T HAVE A CUP OF WATER AT THE TIME THE FIRE COULD HAVE EASILY BURNED UP THE REST OF MY CAR IN A MATTER OF SECONDS. *TR
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Exterior Lighting:brake Lights
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
2002 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration