THE WATER PUMP HAS A PART THAT GOES INTO THE ENGINE; IT'S MADE OF PLASTIC AND CALLED AN IMPELLER. IT IS PART OF THE WATER PUMP. THE PLASTIC IMPELLER DISINTEGRATED, CAUSING THE ENGINE TO OVERHEAT. THE ENGINE LIGHT ON THE DASHBOARD CAME ON JUST MINUTES BEFORE THE ENGINE CEASED UP. OTHER THAN THAT, THERE WAS NO WARNING THAT THE…
Read full complaint
THE WATER PUMP HAS A PART THAT GOES INTO THE ENGINE; IT'S MADE OF PLASTIC AND CALLED AN IMPELLER. IT IS PART OF THE WATER PUMP. THE PLASTIC IMPELLER DISINTEGRATED, CAUSING THE ENGINE TO OVERHEAT. THE ENGINE LIGHT ON THE DASHBOARD CAME ON JUST MINUTES BEFORE THE ENGINE CEASED UP. OTHER THAN THAT, THERE WAS NO WARNING THAT THE ENGINE WAS RUNNING HOT. NORMALLY WHEN A WATER PUMP GOES OUT, THE WATER LEAKS OUT. IN THIS CASE, THE WATER REMAINED IN AND DID NOT CIRCULATE. REPAIRER HAS ASKED OWNER FOR MONEY TO REPLACE THE ENGINE ENTIRELY. VW WILL NOT STAND BY ITS MANUFACTURER'S WARRANTY, WHICH THE OWNER HAS. THE PLASTIC IMPELLER IS A COMMON DESIGN DEFECT WHICH VW KNOWS HAS A SHORT LIFE, BUT THEY KEEP DESIGNING THEIR VWS WITH A PLASTIC IMPELLER!
NHTSA ODI #10070405
Mileage unknown · Dec 9, 2003
Electrical SystemStructureUnknown Or Other
PROBLEMS WITH VEHICLE'S INSTRUMENT PANEL AND RADIO.*MR THE INSTRUMENT PANEL HAD TO BE REPLACED TWICE. THE RADIO OPERATED ON IT'S OWN AND THE WINDOWS ROLLED DOWN ON THEIR OWN. THE CONSUMER WAS UNABLE TO USE THE POWER CONTROLS TO. HE WROTE A LETTER TO THE VW DEALERSHIP AND HAS NOT RECEIVED ANY RESPONSE. THE CAR WAS TAKEN AND AUCTI…
Read full complaint
PROBLEMS WITH VEHICLE'S INSTRUMENT PANEL AND RADIO.*MR THE INSTRUMENT PANEL HAD TO BE REPLACED TWICE. THE RADIO OPERATED ON IT'S OWN AND THE WINDOWS ROLLED DOWN ON THEIR OWN. THE CONSUMER WAS UNABLE TO USE THE POWER CONTROLS TO. HE WROTE A LETTER TO THE VW DEALERSHIP AND HAS NOT RECEIVED ANY RESPONSE. THE CAR WAS TAKEN AND AUCTIONED OFF. THE CONSUMER WAS TRYING TO FIND A WAY TO MAKE SURE VOLKSWAGEN BE HELD ACCOUNTABLE. *CB THE CONSUMER ALSO STATED THE ODOMETER ROLLED UP APPROXIMATELY 9000 MILES, THE DEALER RAN A COMPUTER CHECK BUT FOUND NOTHING WRONG WITH THE VEHICLE. *JB
NHTSA ODI #10051747
Mileage unknown · Sep 4, 2002
Electrical SystemEquipmentUnknown Or Other
THE CONSUMER STATED THAT 18 MONTHS AFTER THE PURCHASE OF THE VEHICLE, THE VEHICLE NEEDED TO BE JUMP STARTED. THE CONSUMER HAD TAKEN THE VEHICLE TO THE DEALER AND WAS TOLD THAT IT WAS A COMPUTER MALFUNCTION. THE CONSUMER HAD TAKEN THE VEHICLE IN FOR AN INOPERATIVE SPEEDOMETER BUT IT ENDED UP BEING THE INSTRUMENT CLUSTER. THE L…
Read full complaint
THE CONSUMER STATED THAT 18 MONTHS AFTER THE PURCHASE OF THE VEHICLE, THE VEHICLE NEEDED TO BE JUMP STARTED. THE CONSUMER HAD TAKEN THE VEHICLE TO THE DEALER AND WAS TOLD THAT IT WAS A COMPUTER MALFUNCTION. THE CONSUMER HAD TAKEN THE VEHICLE IN FOR AN INOPERATIVE SPEEDOMETER BUT IT ENDED UP BEING THE INSTRUMENT CLUSTER. THE LOW BEAM LIGHTS WOULDN'T WORK BECAUSE OF AN ERROR WITH THE ELECTRONICS. *SCC
NHTSA ODI #567334
Mileage unknown · Aug 23, 2002
Air BagsEquipmentUnknown Or Other
SHORTLY AFTER I BOUGHT THE VEHICLE, ENGINE"CHECK LIGHT CAME ON AND STAYED ON. ALSO, CD PLAYER WAS NOT OPERATING CORRECTLY AND TEMPERATURE DISPLAY (BY REAR VIEW MIRROR) DID NOT WORK. TOOK IN TO DEALER'S SVC DEPT. MANY TIMES, BUT PROBLEMS PERSITED . DEALER SVC. DEPT. CLAIMED EVERYTHING WORKING FINE. RECENTLY, THE WINDOW ON TH…
Read full complaint
SHORTLY AFTER I BOUGHT THE VEHICLE, ENGINE"CHECK LIGHT CAME ON AND STAYED ON. ALSO, CD PLAYER WAS NOT OPERATING CORRECTLY AND TEMPERATURE DISPLAY (BY REAR VIEW MIRROR) DID NOT WORK. TOOK IN TO DEALER'S SVC DEPT. MANY TIMES, BUT PROBLEMS PERSITED . DEALER SVC. DEPT. CLAIMED EVERYTHING WORKING FINE. RECENTLY, THE WINDOW ON THE DRIVER SIDE FAILED AND IT WOULD NOT GO UP. TOOK CAR IN TO DEALER SVC. DEPT. AND GOT REPAIRED. SHORTLY AFTER THAT, CAR DIED. IT WAS NOT THE BATTERY, SO CAR WAS TOWED TO DEALER SERVICE DEPT. ON 8-14-02. DEALER EXAMINED CAR AND SAID IT WAS THE TRI-LOCK SYSTEM AND DIDN'T KNOW HOW TO FIX IT. TRI-LOCK SYSTEM REMOVED BY DEALER BUT CAR STILL NOT WORKING. PROBLEM: POWER WINDOWS DID NOT WORK, PUSH WINDOW BUTTON AND TRUNK WOULD POP OPEN, AIR BAG LIGHT STAYED ON, ETC. ETC. ETC. THE CAR HAS BEEN AT DEALESHIP FOR OVER A WEEK AND DEALER KEEPS TELLING ME IT'S FIXED, BUT WHEN I GO PICK IT UP (3 TIMES), THE CAR IS STILL DOING THE SAME THING, AND THE AIR BAG LIGHT IS STILL ON ALL THE TIME. VERY FRUSTRATED AND DISAPPOINTED.*AK
NHTSA ODI #766098
Mileage unknown · Mar 25, 2002
Air BagsFuel System, OtherPower Train
WHILE DRIVING THE CAR I NOTICED THE SPEEDOMETER & ODOMETER WEREN'T WORKING (MILEAGE FROZE AT 26,139). THE GAS GAUGE WAS NOT WORKING EITHER. THEN THE CHECK ENGINE LIGHT CAME ON AND THE AIRBAG LIGHT. BROUGHT INTO DEALERSHIP AND WAS TOLD THERE WERE 19 FAILURES WHEN IT WAS TESTED ON THEIR COMPUTER. DEALERSHIP CLAIMS THE TRANSMIS…
Read full complaint
WHILE DRIVING THE CAR I NOTICED THE SPEEDOMETER & ODOMETER WEREN'T WORKING (MILEAGE FROZE AT 26,139). THE GAS GAUGE WAS NOT WORKING EITHER. THEN THE CHECK ENGINE LIGHT CAME ON AND THE AIRBAG LIGHT. BROUGHT INTO DEALERSHIP AND WAS TOLD THERE WERE 19 FAILURES WHEN IT WAS TESTED ON THEIR COMPUTER. DEALERSHIP CLAIMS THE TRANSMISSION NEEDS PARTS REPLACED. (WILL BE COVERED UNDER POWERTRAIN WARRANTY POSSIBLY). STILL WAITING ON PARTS. THEY SAID AFTER THEY REPLACE PARTS OF TRANSMISSION THEY WILL LET ME KNOW WHAT ELSE NEEDS TO BE DONE AND HOW MUCH IT WILL COST ME. THE STANDARD WARRANTY ENDED MARCH 2001. THE VEHICLE HAS LOW MILEAGE (26,139). THE BATTERY HAD TO BE REPLACED LAST YEAR. MANY TIMES THE CAR WOULDN'T START AND HAD TO BE JUMPED. THE CHECK ENGINE LIGHT CAME ON THE FIRST YEAR I HAD THE CAR AND THE DEALERSHIP CLAIMED IT WAS A SENSOR PROBLEM.*AK
NHTSA ODI #759766
Mileage unknown · May 19, 2001
Engine And Engine CoolingUnknown Or Other
AFTER DRIVING CAR FOR AN HOUR THE ENGINE LIGHT CAME ON,. DEALER TOOK CAR TO CHECK IT OUT AND IN DOING WHICH DAMAGE THE CAR FURTHER BY DENTING PASSENGER FENDER AND BUMPER. FAILED TO TELL ME ABOUT THIS, HOWEVER ENGINE LIGHT WAS FIXED (O2) SENSOR.*AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Exterior Lighting:brake Lights
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Exterior Lighting
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
1999 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration