TL*THE CONTACT OWNS A 1998 VOLKSWAGEN BEETLE. THE CONTACT WAS NOT THE DRIVER AT THE TIME OF THE INCIDENT. WHILE DRIVING APPROXIMATELY 55 MPH ON A SNOW COVERED ROAD, THE DRIVER NOTICED AN 18-WHEELER HEADING TOWARDS THE VEHICLE. THE DRIVER APPLIED PRESSURE TO THE BRAKES IN ORDER TO AVOID A CRASH. THE BRAKES FAILED AND THE DRIV…
Read full complaint
TL*THE CONTACT OWNS A 1998 VOLKSWAGEN BEETLE. THE CONTACT WAS NOT THE DRIVER AT THE TIME OF THE INCIDENT. WHILE DRIVING APPROXIMATELY 55 MPH ON A SNOW COVERED ROAD, THE DRIVER NOTICED AN 18-WHEELER HEADING TOWARDS THE VEHICLE. THE DRIVER APPLIED PRESSURE TO THE BRAKES IN ORDER TO AVOID A CRASH. THE BRAKES FAILED AND THE DRIVER REAR ENDED THE PRECEDING VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A BODY SHOP AND AN INSURANCE AGENT INFORMED THE OWNER THAT THE VEHICLE WAS DESTROYED. THE DEALER AND THE MANUFACTURER WERE NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 100,000.
NHTSA ODI #10253389
50,000 miles · Aug 25, 2007
Electrical SystemEngine And Engine CoolingEquipment
SINCE I PURCHASED MY BEETLE IN 2001, IT HAS BEEN AN ONGOING MONEY DRAIN. IN 6 YRS. I HAVE REPLACED THE MANUAL TRANSMISSION TWICE, HAD THE BRAKES WORKED ON A NUMBER OF TIMES, BEEN UNABLE TO OPEN THE GAS "DOOR" ON THE CAR W/ THE GAS CAP LATCH, HAD TO REPLACE THE HOOD OPENING LATCH, HAD REPEATED ELECTRICAL FAILURES, PROBLEMS W/ FR…
Read full complaint
SINCE I PURCHASED MY BEETLE IN 2001, IT HAS BEEN AN ONGOING MONEY DRAIN. IN 6 YRS. I HAVE REPLACED THE MANUAL TRANSMISSION TWICE, HAD THE BRAKES WORKED ON A NUMBER OF TIMES, BEEN UNABLE TO OPEN THE GAS "DOOR" ON THE CAR W/ THE GAS CAP LATCH, HAD TO REPLACE THE HOOD OPENING LATCH, HAD REPEATED ELECTRICAL FAILURES, PROBLEMS W/ FRONT & REAR LIGHT WIRING, HAD DOOR LOCKS/ALARM FAIL & SUBSEQUENTLY HAD MY LAPTOP STOLEN FROM THE CAR, THE RADIO HAS NOT WORKED FOR 1+ YEAR, & IT'S COVER PANEL IS LOOSE & FALLING BACK INTO THE DASH, THE REAR-VIEW MIRROR SWITCHES HAVE FAILED, THE POWER WINDOW SWITCHES HAVE HAD TO BE REPLACED, THE DRIVERS SIDE DOOR FELL OFF (!) OF ITS TOP HINGE WHEN THE HINGE BROKE WHILE OPENING THE DOOR NORMALLY AT A GAS STATION, THE AIR COMPRESSOR HAS FAILED MANY TIMES, THE A/C IS CURRENTLY NOT WORKING, THE DRIVERS SIDE DOOR LOCK FELL OUT OF THE HANDLE(!!!!), THE CATALYTIC CONVERTER HAS BEEN REPLACED TWICE, & THE LIST GOES ON. CURRENTLY I HAVE NOT BEEN DRIVING THE CAR FOR SEVERAL WKS B/C THOUGH ONLY A WEEK OR TWO OUT OF THE SHOP, AGAIN IT IS HAVING TRANSMISSION PROBLEMS. I AM AT MY WITS END WITH THIS CAR & HAVING RECENTLY GRADUATED FROM COLLEGE, AM NOT IN THE GREATEST POSITION TO HAVE TO BUY A NEW CAR. MOREOVER, I AM SO DISPLEASED W/ THE CAR THAT I WOULD LITERALLY FEEL GUILTY ABOUT TRADING IT IN TO BE SOLD TO SOME OTHER UNSUSPECTING PERSON. VW SHOULD BE SO ASHAMED OF THEMSELVES, & SHOULD BE REIMBURSING OWNERS OF THE 1998 BEETLE IN FULL FOR ALL OF THE STRIFE & TROUBLE THAT THEY HAVE CAUSED. IN FACT, AFTER WRITING THIS & REALIZING HOW MANY PROBLEMS THIS CAR HAS HAD, I MAY TRY TO TAKE LEGAL ACTION - THIS IS TOTALLY UNACCEPTABLE! FINALLY, OUR LOCAL VW DEALER IS TERRIBLE, KEEPING MY CAR FOR WKS. LONGER THAN EXPECTED, ONE TIME LEAVING A CANDY BAR STUCK TO MY PASSENGER SIDE SEAT!!!, AND ACTING LIKE THEY COULD CARE LESS ABOUT THE POOR QUALITY OF THEIR PRODUCTS & LABOR. *TR
NHTSA ODI #10200746
89,957 miles · Jul 3, 2007
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 1998 VOLKSWAGEN BEETLE. THE PLASTIC TUBE THAT EXTENDS FROM THE VACUUM PUMP TO THE VACUUM BRAKE BOOSTER IS CRACKED AND DEFECTIVE. THE CONTACT STATED THAT WITHOUT THIS PIECE, BRAKE FAILURE IS LIKELY TO OCCUR. AS A RESULT, HE WOULD HAVE TO DEPRESS THE BRAKE PEDAL VERY HARD IN ORDER FOR THEM TO WORK. THE VE…
Read full complaint
TL*THE CONTACT OWNS A 1998 VOLKSWAGEN BEETLE. THE PLASTIC TUBE THAT EXTENDS FROM THE VACUUM PUMP TO THE VACUUM BRAKE BOOSTER IS CRACKED AND DEFECTIVE. THE CONTACT STATED THAT WITHOUT THIS PIECE, BRAKE FAILURE IS LIKELY TO OCCUR. AS A RESULT, HE WOULD HAVE TO DEPRESS THE BRAKE PEDAL VERY HARD IN ORDER FOR THEM TO WORK. THE VEHICLE HAS NOT BEEN DRIVEN SINCE THE FAILURE OCCURRED. THE CURRENT AND FAILURE MILEAGES WERE 89,957. THE CONSUMER STATED PLASTIC LINE REPLACED WITH 3/8" VACUUM LINE. UPDATED 07/26/07 *TR
NHTSA ODI #10195258
Mileage unknown · Aug 12, 2004
Power TrainService Brakes, Hydraulic
1998 BEETLE.*MR AFTER THE VEHICLE WAS PURCHASED IT WAS DRIVER 120 MILES TO THE CONSUMER'S HOME. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BECAUSE THE CONSUMER HEARD A NOISE COMING FROM THE REAR OF THE VEHICLE. THE TECHNICIAN DETERMINED THAT EH VEHICLE'S BRAKES AND CLUTCH WERE BAD. THE CONSUMER CONTACTED THE DEALER BUT THE…
Read full complaint
1998 BEETLE.*MR AFTER THE VEHICLE WAS PURCHASED IT WAS DRIVER 120 MILES TO THE CONSUMER'S HOME. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BECAUSE THE CONSUMER HEARD A NOISE COMING FROM THE REAR OF THE VEHICLE. THE TECHNICIAN DETERMINED THAT EH VEHICLE'S BRAKES AND CLUTCH WERE BAD. THE CONSUMER CONTACTED THE DEALER BUT THE REFUSED TO PROVIDE ANY ASSISTANCE. *NM
NHTSA ODI #10089281
Mileage unknown · Mar 12, 2003
Engine And Engine CoolingExterior LightingService Brakes, Hydraulic
CONSUMER REPLACED BRAKE LIGHTS/HEADLIGHTS/REAR BRAKE PADS AND ROTORS/ ENGINE SHIELD AND COOLING SYSTEM. *AK *JB
NHTSA ODI #567790
Mileage unknown · Sep 25, 2002
Engine And Engine CoolingExterior LightingService Brakes, HydraulicFire
VEHICLE CAUGHT ON FIRE, POSSIBLE ENGINE FAILURE, WHILE DRIVING THE VEHICLES BRAKE SYSTEM FAILED AND THE DRIVER HAD TO USE THE EMERGENCY BRAKE TO STOP VEHICLE. *MR THE HEAD LIGHT MALFUNCTIONED AND THE VEHICLES IS FLLING APART AFTER ONE MONTH OF OWNERSHIP. THE DEALER REFUSED TO FIX IT. *YH
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ELECTRICAL WIRING LOCATED IN THE ENGINE COMPARTMENT WAS ROUTED TOO CLOSE TO THE ENDGE OF THE VEHICLE'S BATTERY TRAY. THE WIRING CAN BECOME DAMAGED OVER TIME BY CHAFING AND THE AIR-CONDITIONER COMPRESSOR AND/OR THE FUEL PUMP CAN MALFUNCTION.
Consequence & remedy
Consequence: A MALFUNCTION OF THE FUEL PUMP CAN CAUSE THE VEHICLE TO STALL, AND IN SOME INSTANCES, COULD ALSO RESULT IN A WIRING FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL A MODIFIED BATTERY TRAY AND INSPECT, PROPERLY ROUTE, AND SECURING THE WIRING IN ACCORDANCE WITH THE RECALL REPAIR INSTRUCTIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Exterior Lighting:brake Lights
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Exterior Lighting
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
1998 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration