DEALER REFUSES TO SCHEDULE PROMPT REPAIR FOR CURRENT HEADLIGHT FAILURE (REQUEST 5-10 DAYS); CURRENT HEADLIGHT FAILURE INCLUDES PERMANENT FAILURE OF LEFT HEADLIGHT AND INTERMITTENT FAILURE OF BOTH HEADLIGHTS; CONSUMER REPORTS REPORTS 1998 NEW BEETLE AS "USED CAR TO AVOID" (APRIL 2000ISSUE, P. 75); NEW BEETLE WEBSITE CONDUCTED SUR…
Read full complaint
DEALER REFUSES TO SCHEDULE PROMPT REPAIR FOR CURRENT HEADLIGHT FAILURE (REQUEST 5-10 DAYS); CURRENT HEADLIGHT FAILURE INCLUDES PERMANENT FAILURE OF LEFT HEADLIGHT AND INTERMITTENT FAILURE OF BOTH HEADLIGHTS; CONSUMER REPORTS REPORTS 1998 NEW BEETLE AS "USED CAR TO AVOID" (APRIL 2000ISSUE, P. 75); NEW BEETLE WEBSITE CONDUCTED SURVEY OF OWNERS OF 1998 MODEL - 55 PERCENT REPORT TROUBLE WITH THE CAR, 90 PERCENT OF WHICH IS ELECTRICAL; A RECALL WAS ISSUED FOR 1998 BEETLES MANUFACTURED IN FIRST HALF OF 1998 BECAUSE OF FAULTY WIRING THAT COULD CAUSE FIRE IN ENGINE COMPARTMENT (WE WERE NOT NOTIFIED OF A RECALL); THERE ARE MANY COMPLAINTS OF BEETLE OWNERS REGARDING VW CONSUMER SERVICE; WE HAVE RECEIVED SUBSTANDARD SERVICE FROM OUR DEALER, INCLUDING ONE REPAIR ON A FAILED HEADLIGHT THAT WAS NOT PERFORMED AS STATED, FORCING US TO RETURN THE CAR. *AK
NHTSA ODI #723056
Mileage unknown · Mar 23, 2000
Engine And Engine CoolingExterior LightingPower Train
VEHICLE HAS HAD CONTINUED PROBLEMS WITH TRANSMISSION OPERATION AND SHIFTING, REPLACEMENT OF THE SPEED SENSOR,THROTTLE CABLE AND TCM WIRING RECTIFIED PROBLEMS. *MJS
NHTSA ODI #551528
Mileage unknown · Jan 25, 1999
Exterior Lighting
HEADLAMP: I STATED TO MY DEALER THAT MY HEADLAMPS WERE NOT PROPERLY ADJUSTED, DEALER FOUND LEFT HEADLAMP HAD NO POSSIBLE ADJUSTMENT, AND REPLACED THE ENTIRE ASSEMBLY. FOG LIGHTS: FOG LAMPS WHEN SWITCHED ON, DON'T LIGHT. AFTER A FEW MINUTES OF DRIVING, THEY COME ON SOMETIMES. *AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ELECTRICAL WIRING LOCATED IN THE ENGINE COMPARTMENT WAS ROUTED TOO CLOSE TO THE ENDGE OF THE VEHICLE'S BATTERY TRAY. THE WIRING CAN BECOME DAMAGED OVER TIME BY CHAFING AND THE AIR-CONDITIONER COMPRESSOR AND/OR THE FUEL PUMP CAN MALFUNCTION.
Consequence & remedy
Consequence: A MALFUNCTION OF THE FUEL PUMP CAN CAUSE THE VEHICLE TO STALL, AND IN SOME INSTANCES, COULD ALSO RESULT IN A WIRING FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL A MODIFIED BATTERY TRAY AND INSPECT, PROPERLY ROUTE, AND SECURING THE WIRING IN ACCORDANCE WITH THE RECALL REPAIR INSTRUCTIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Exterior Lighting:brake Lights
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Exterior Lighting
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
1998 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration