IllustrationWHILE DRIVING PLASTIC COVER THAT PROTECTS ENGINE/ EXHAUST SYSTEM AND PLUGS DISENGAGED FROM UNDER VEHICLE. PLEASE GIVE ANY FURTHER DETAILS.*AK
1998 Volkswagen Beetle
Owner reports · Recalls · Investigations
More warning signs than most Beetle years
Owner complaints for the 1998 Volkswagen Beetle are substantially higher than the model-year median of 49.
About this comparison →How this year compares
Owner complaints by model year
Compare all Beetle years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
825–50K
1450–75K
1475–100K
7100–150K
0150K+
46 reports with mileage · 125 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports16 fire reports6 injury reports
Engine And Engine Cooling complaints
32 reportsMULTIPLE PROBLEMS WITH CAR SINCE PURCHASE.
POSSIBLE ENGINE FAILURE AND MISSING OIL CAP CAUSED FIRE. YH
VEHICLE HAS HAD CONTINUED PROBLEMS WITH TRANSMISSION OPERATION AND SHIFTING, REPLACEMENT OF THE SPEED SENSOR,THROTTLE CABLE AND TCM WIRING RECTIFIED PROBLEMS. *MJS
POSSIBLE ENGINE FAILURE CAUSED VEHICLE FIRE. YH
ELECTICAL WIRING LOCATED IN THE ENGINE COMPARTMENT WAS TOO CLOSE TO THE BATTERY TRAY CAUSING THE WIRE TO DAMAGE (RECALL-98V-100), OWNER IS NOT SATISFIED WITH VEHICLE WITH THIS DEFECT. YH
PLASTIC CLIP IN COOLING SYSTEM BROKE, CAUSING ALL COOLANT TO BE DISCHARGED ALL OVER THE ENGINE AND ENGINE TO OVERHEAT. DEALER REPLACED PLASTIC CLIP WITH METAL CLIP. VW SENT DEALER 8 METAL CLIPS THE WEEK PREVIOUS. THEY SAID OTHER BEETLES PROBABLY HAD THIS PROBLEM, THAT'S WHY VW SENT THEM 8 METAL CLIPS AHEAD OF TIME. *AK
OIL CONSUMED AT RATE OF 1QT/1500 MILES. NO LEAK OR SMOKING EXHAUST. VW RECOMMENDS OIL CHANGE EVERY 10,000 MILES. ENGINE WOULD HAVE NO OIL BY 6,000 MILES. COULD CAUSE ENGINE TO SEIZE AND POSSIBLE ACCIDENT. OTHER NEW BEETLE OWNERS I KNOW HAVE TOLD ME THEY HAVE THE SAME PROBLEM WITH THEIR GAS 2.0L ENGINE, 5SPD NEW BEETLE. THIS S…
Read full complaint
OIL CONSUMED AT RATE OF 1QT/1500 MILES. NO LEAK OR SMOKING EXHAUST. VW RECOMMENDS OIL CHANGE EVERY 10,000 MILES. ENGINE WOULD HAVE NO OIL BY 6,000 MILES. COULD CAUSE ENGINE TO SEIZE AND POSSIBLE ACCIDENT. OTHER NEW BEETLE OWNERS I KNOW HAVE TOLD ME THEY HAVE THE SAME PROBLEM WITH THEIR GAS 2.0L ENGINE, 5SPD NEW BEETLE. THIS SITUATION IS VERY UNSAFE. *AK
WHILE DRIVING AT 45 MPH, ENGINE TURBO WENT OUT, CAUSING VEHICLE TO ACCELERATE TO 120 MPH. CONSUMER APPLIED BRAKES/EMERGENCY BRAKE, AND DOWNSHIFTED VEHICLE, IT DIDN'T WORK. CONSUMER KEPT PUSHING ON THE EMERGENCY BRAKE, VEHICLE STARTED SLOWING DOWN, AND THEN IT ACCELERATED BACK TO HIGH SPEED. FINALLY, SLOWED BACK DOWN AND CA…
Read full complaint
WHILE DRIVING AT 45 MPH, ENGINE TURBO WENT OUT, CAUSING VEHICLE TO ACCELERATE TO 120 MPH. CONSUMER APPLIED BRAKES/EMERGENCY BRAKE, AND DOWNSHIFTED VEHICLE, IT DIDN'T WORK. CONSUMER KEPT PUSHING ON THE EMERGENCY BRAKE, VEHICLE STARTED SLOWING DOWN, AND THEN IT ACCELERATED BACK TO HIGH SPEED. FINALLY, SLOWED BACK DOWN AND CAME TO A STOP. *AK
VEHICLE HAS HIGH OIL CONSUMPTION, RADIO/CASSETTE FAILURE WHICH RESULTED IN FIRE, PREVIOUS INCIDENT RADIATOR FAILURE, COMPUTER FAILURE, DEFECTIVE CONTROL SWITCHES AND DEFECTICE ENGINE.
Official recalls
206V183000 · Exterior Lighting:brake Lights:switch
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
98V100000 · Electrical System:wiring:front Underhood
May 13, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ELECTRICAL WIRING LOCATED IN THE ENGINE COMPARTMENT WAS ROUTED TOO CLOSE TO THE ENDGE OF THE VEHICLE'S BATTERY TRAY. THE WIRING CAN BECOME DAMAGED OVER TIME BY CHAFING AND THE AIR-CONDITIONER COMPRESSOR AND/OR THE FUEL PUMP CAN MALFUNCTION.
Consequence & remedy
Consequence: A MALFUNCTION OF THE FUEL PUMP CAN CAUSE THE VEHICLE TO STALL, AND IN SOME INSTANCES, COULD ALSO RESULT IN A WIRING FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL A MODIFIED BATTERY TRAY AND INSPECT, PROPERLY ROUTE, AND SECURING THE WIRING IN ACCORDANCE WITH THE RECALL REPAIR INSTRUCTIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA03002 · Brake Light Switch
Opened Apr 8, 2003 · Closed Aug 20, 2003
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Exterior Lighting:brake Lights
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
PE02084 · Brake Light Switch Operation
Opened Nov 18, 2002 · Closed Apr 8, 2003
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Exterior Lighting
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.