NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
11 reportsClear category filter160,000 miles · Dec 7, 2018
Electronic Stability Control (esc)Service BrakesSteering
ANY DAY, ANY WEATHER, ANY ROAD CONDITIONS. THE ROAD COULD BE AS DRY AS A BONE. WHEN I DRIVE AROUND A CURVE (IT DOESN'T MATTER IF I'M DRIVING 45 MPH, OR 15 MPH), THE BREAK PEDAL WILL ENGAGE ON IT'S OWN, THE STEERING WHEEL WILL LOCK, AND A BEEPING ALARM WILL GO OFF. I HAVE NO CONTROL OF THE VAN. IT WILL PUT ME INTO ONCOMING TRAFFI…
Read full complaint
ANY DAY, ANY WEATHER, ANY ROAD CONDITIONS. THE ROAD COULD BE AS DRY AS A BONE. WHEN I DRIVE AROUND A CURVE (IT DOESN'T MATTER IF I'M DRIVING 45 MPH, OR 15 MPH), THE BREAK PEDAL WILL ENGAGE ON IT'S OWN, THE STEERING WHEEL WILL LOCK, AND A BEEPING ALARM WILL GO OFF. I HAVE NO CONTROL OF THE VAN. IT WILL PUT ME INTO ONCOMING TRAFFIC. EVERYDAY. EVERYDAY. ANY TIME I DRIVE THIS VAN. MULTIPLE TIMES A DAY FOR THE LAST 15 MONTHS. LOTS OF $, AND LOTS OF TRIPS TO DEALER AND CAR REPAIR SHOPS. CAN'T FIGURE OUT WHAT IS CAUSING THE PROBLEM, BUT IT'S A MAJOR PROBLEM. WE TRIED NEW TIRES, CHANGING WHEEL SENSORS, NEW BRAKES, ADDING FLUID TO STEERING WHEEL COLUMN, NEW AXELS... AND THE LIST GOES ON. NOTHING FIXES THE PROBLEM. I'VE READ A LOT OF SIMILAR STORIES ON THE INTERNET. LOTS PF PEOPLE, SAME PROBLEM, AND NOTHING IS FIXING THE PROBLEM ON ANYONE'S VAN. THERE ISN'T A SOLUTION TO A MAJOR PROBLEM.
NHTSA ODI #11156877
Mileage unknown · Aug 26, 2017
Air BagsSeatsSteering
TAKATA RECALL RECEIVED INTERIM NOTICE, BUT DID NOT RECEIVE ANY REMEDY NOTIFICATION LATER. JUST RECEIVED AUTO AIRBAG SETTLEMENT NOTICE TODAY. CALLED LOCAL DEALER TO FOLLOW THE NOTICE OF GETTING THE AIRBAG REPLACED ASAP, AND THEY SAID THEY HAD NOBODY THERE TO OPERATE THE COMPUTER TO VERIFY MY CAR WAS UNDER THE RECALL & CALL BAC…
Read full complaint
TAKATA RECALL RECEIVED INTERIM NOTICE, BUT DID NOT RECEIVE ANY REMEDY NOTIFICATION LATER. JUST RECEIVED AUTO AIRBAG SETTLEMENT NOTICE TODAY. CALLED LOCAL DEALER TO FOLLOW THE NOTICE OF GETTING THE AIRBAG REPLACED ASAP, AND THEY SAID THEY HAD NOBODY THERE TO OPERATE THE COMPUTER TO VERIFY MY CAR WAS UNDER THE RECALL & CALL BACK ANOTHER DAY. HOW COME I COULD VERIFY THE SAME DAY ON MY PHONE & THE DEALER COULD NOT? NOW, I NEED TO TAKE MY WIFE TO THE HOSPITAL & WILL NOT BE ABLE TO CONTACT THE DEALER UNTIL LATER. SO TWO COMPLAINTS; NO REMEDY NOTIFICATION & DELAY BY THE LOCAL DEALER.
NHTSA ODI #11019871
109,797 miles · Aug 19, 2015
Exterior LightingSteeringStructureCrash
THE AIRBAG DID NOT DEPLOY EVEN THOUGH I HIT THE FENCE BESIDE THE WINDOW.
NHTSA ODI #10749645
100,000 miles · Aug 11, 2014
Air BagsService BrakesSteeringCrashInjury
TL* THE CONTACT OWNED A 2007 TOYOTA YARIS. WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKES FAILED AND THE STEERING LOCKED. AS A RESULT, THE CONTACT CRASHED THE VEHICLE INTO THE REAR OF THE PRECEDING VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED BURNS ON THE CHEST, A CUT ON THE LIP, AND A BRUISED RIGHT ARM AND LEG.…
Read full complaint
TL* THE CONTACT OWNED A 2007 TOYOTA YARIS. WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKES FAILED AND THE STEERING LOCKED. AS A RESULT, THE CONTACT CRASHED THE VEHICLE INTO THE REAR OF THE PRECEDING VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED BURNS ON THE CHEST, A CUT ON THE LIP, AND A BRUISED RIGHT ARM AND LEG. MEDICAL ATTENTION WAS RECEIVED. A POLICE REPORT WAS FILED AND THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V169000 (SEATS). THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10621452
111,111 miles · Sep 21, 2013
Steering
ON THURSDAY, SEPTEMBER 19, 2013, WHILE TURNING MY STEERING WHEEL AND ATTEMPTING TO PARK MY 2007 TOYOTA YARIS I HEARD A LOUD CRACK. I KNEW SOMETHING WAS DEFINITELY WRONG AND QUICKLY REALIZED THAT A CONNECTION BETWEEN THE STEERING COLUMN AND THE WHEEL HAD BROKEN AS THE STEERING PIECE WAS NO LONGER TURNING THE WHEELS. IN FACT, THE …
Read full complaint
ON THURSDAY, SEPTEMBER 19, 2013, WHILE TURNING MY STEERING WHEEL AND ATTEMPTING TO PARK MY 2007 TOYOTA YARIS I HEARD A LOUD CRACK. I KNEW SOMETHING WAS DEFINITELY WRONG AND QUICKLY REALIZED THAT A CONNECTION BETWEEN THE STEERING COLUMN AND THE WHEEL HAD BROKEN AS THE STEERING PIECE WAS NO LONGER TURNING THE WHEELS. IN FACT, THE STEERING PIECE JUST SPUN AROUND 360 DEGREES. I LEFT MY CAR IN PARK AND CALLED A FRIEND WHO REALLY KNOWS CARS. UPON EXAMINING THE CAR, HE IMMEDIATELY SAID THAT SOMETHING WAS SERIOUSLY WRONG WITH THAT TOYOTA PART AND IT NEVER SHOULD HAVE BROKEN ESPECIALLY BECAUSE THE PART IS COVERED BY A PROTECTIVE BOOT AND IS NOT LOCATED IN THE FRONT OF THE CAR. IF I HAD BEEN ON THE HIGHWAY, I COULD HAVE DIED. I BROUGHT IT TO THE DEALERSHIP, BUT BECAUSE THE PART IS NOT YET ON THE RECALL LIST AND MY CAR HAD OVER 60,000 THEY TOLD ME THAT I WOULD HAVE TO PAY NEARLY $2,000 FOR THE REPAIR. I BELIEVE THAT THIS IS A PROBLEM WITH A TOYOTA PART THAT SHOULD BE ADDED TO THE RECALL LIST AND I SHOULD NOT HAVE TO PAY FOR THE REPLACEMENT OF THE PART.
NHTSA ODI #10544708
82,651 miles · Sep 19, 2013
SteeringVehicle Speed Control
WHILE DRIVING AT HIGHWAY SPEEDS, STEERING STICK WHEN TRYING TO MAKE SLIGHT STEERING CORRECTIONS. THIS HAS GOTTEN BAD ENOUGH TO WHERE VEHICLE MAKES LANE CHANGES WHEN JUST TRYING TO MAKE SLIGHT CORRECTION. HAVE HAD THE VEHICLE CHECKED SEVERAL TIMES, THE ACCELERATION SENSOR HAS BEEN RELEARNED THREE SEPARATE TIMES WITH LITTLE OR NO …
Read full complaint
WHILE DRIVING AT HIGHWAY SPEEDS, STEERING STICK WHEN TRYING TO MAKE SLIGHT STEERING CORRECTIONS. THIS HAS GOTTEN BAD ENOUGH TO WHERE VEHICLE MAKES LANE CHANGES WHEN JUST TRYING TO MAKE SLIGHT CORRECTION. HAVE HAD THE VEHICLE CHECKED SEVERAL TIMES, THE ACCELERATION SENSOR HAS BEEN RELEARNED THREE SEPARATE TIMES WITH LITTLE OR NO CHANGE. THIS IS VERY ANNOYING AND DANGEROUS. *TR
NHTSA ODI #10544488
79,500 miles · Aug 17, 2010
Air BagsSteeringCrash
PURCHASED A 07 TOYOTA YARIS ON 6/7/2010 CERTIFIED WITH 77302 MILES ON IT FOR MY SON. CAR HAS HAD NO INCIDENTS UNTIL 7/25/10 AT APPROX 7:30 - 7:45PM EST. DRIVING CONDITIONS WERE SUNNY AND CLEAR. MY SON AND I HAVE DRIVEN ON THE ROAD MANY TIMES BEFORE AS IT IS VERY CLOSE TO THE HOUSE. WHEN MY SON WAS TRYING TO BEAR RIGHT AROUND A T…
Read full complaint
PURCHASED A 07 TOYOTA YARIS ON 6/7/2010 CERTIFIED WITH 77302 MILES ON IT FOR MY SON. CAR HAS HAD NO INCIDENTS UNTIL 7/25/10 AT APPROX 7:30 - 7:45PM EST. DRIVING CONDITIONS WERE SUNNY AND CLEAR. MY SON AND I HAVE DRIVEN ON THE ROAD MANY TIMES BEFORE AS IT IS VERY CLOSE TO THE HOUSE. WHEN MY SON WAS TRYING TO BEAR RIGHT AROUND A TURN AT THE TOP OF THE HILL WHILE GOING APPROX 25-30 MPH HE COULD NOT TURN RIGHT TO STAY IN HIS LANE. APPLIED THE BRAKES WHILE THE CAR DROVE DIRECTLY INTO A LARGE TREE. THERE WAS NO WAY TO AVOID THE TREE AS THE CAR WOULD NOT ALLOW HIM TO STEER IT. THE POSTED SPEED LIMIT IS 40 MPH FOR THE GENERAL AREA AND 25 MPH SUGGESTED SPEED FOR THE CURVE. ALTHOUGH NO AIRBAGS DEPLOYED, NEITHER DRIVER OR PASSENGER WERE INJURED. DAMAGE TO FRONT END AND THE LEFT QUARTER PANEL PUSHED BACK INTO THE LEFT DOOR SO THE HINGE IS IMPEDED WHEN OPENING THE DOOR. ENGINE WAS PUSHED BACK ON A TILT. THE OFFICER SAID HE COULD NOT SEE ANY OTHER WAY THE ACCIDENT COULD HAVE HAPPENED AS NO ONE WOULD WILLINGLY DRIVE DIRECTLY INTO A TREE ON PURPOSE. THE CAR WAS TOWED TO A LOCAL TOYOTA DEALERSHIP THAT EVENING. ON 7/26 I SPOKE TO THE SERVICE MANAGER (SM) AS DIRECTED BY THE GM. THE SM SUGGESTED I SPEAK TO TOYOTA VIA AN 800 #. I CALLED, GAVE DETAILS AS DESCRIBED ABOVE AND HAVE A CASE NUMBER. I WAS ASSIGNED A CASE MANAGER ON 7/27 AND WAS PROMISED A REGIONAL TOYOTA INVESTIGATOR WOULD LOOK AT THE CAR WITHIN 10-14 BUSINESS DAYS. SHORTLY THEREAFTER I SPOKE TO THE COLLISION MANAGER TO ADVISE HER OF THE ISSUE AND WAITED FOR SOMEONE TO CONTACT ME FROM TOYOTA ADVISING ME WHEN THE INSPECTION WILL TAKE PLACE. ON 8/13 A REP FROM TOYOTA'S EXEC. OFFICE CONTACTED ME AND INDICATED I WOULD NEED TO SIGN AN EDR DATA READOUT AUTHORIZATION AND CONSENT FORM. THEY THINK THE INSPECTION WILL OCCUR ON 8/19 OR 8/20. I HAVE REQUESTED TO VIDEOTAPE THE COMPUTER SCREEN DURING THE DOWNLOAD OF EDR & ECM DATA ALONG WITH IT BACKED UP ON A USB DRIVE AND GET A PRINTOUT AND EXPLANATION FROM THE INSPECTOR. *TR
NHTSA ODI #10350073
50,000 miles · Jul 28, 2009
Steering
TL*THE CONTACT OWNS A 2007 TOYOTA YARIS. WHENEVER THE CONTACT TURNS THE STEERING WHEEL TO THE LEFT OR RIGHT, SHE HEARS A LOUD GRINDING SOUND COMING FROM THE STEERING COLUMN. THE FAILURE WAS NOTICED WHILE DRIVING 15 MPH. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE INTERMEDIATE SHAFT FAILED AND WAS A VERY COMMON…
Read full complaint
TL*THE CONTACT OWNS A 2007 TOYOTA YARIS. WHENEVER THE CONTACT TURNS THE STEERING WHEEL TO THE LEFT OR RIGHT, SHE HEARS A LOUD GRINDING SOUND COMING FROM THE STEERING COLUMN. THE FAILURE WAS NOTICED WHILE DRIVING 15 MPH. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE INTERMEDIATE SHAFT FAILED AND WAS A VERY COMMON ISSUE WITH THE VEHICLE. THE CONTACT WAS INFORMED THAT SINCE THE VEHICLE WAS OUT OF WARRANTY, SHE WOULD BE RESPONSIBLE FOR THE REPAIRS. THE MANUFACTURER WAS AWARE OF THE FAILURE, BUT STATED THAT THERE WAS NO RECALL. THE CONTACT BELIEVES THAT THE MANUFACTURER SHOULD BE RESPONSIBLE AND THAT A RECALL SHOULD BE ISSUED. THE FAILURE MILEAGE WAS 50,000 AND CURRENT MILEAGE WAS 55,000.
NHTSA ODI #10278551
21,755 miles · Apr 22, 2009
Steering
WHILE DRIVING AT AROUND 60 TO 70 MPH THE VEHICLE CONSTANTLY PULLS TO THE RIGHT AND TO THE LEFT. I TOOK THE CAR TO THE TOYOTA DEALER AND THE TOYOTA DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. CURRENT MILEAGE OF THIS TOYOTA YARIS IS 21,755. *TR
NHTSA ODI #10266422
975 miles · Jan 7, 2008
Steering
TL*THE CONTACT OWNS A 2007 TOYOTA YARIS. WHILE DRIVING 65MPH, THE VEHICLE JERKED AND CONSTANTLY PULLED TO THE LEFT AND THE RIGHT. THE MANUFACTURER AND THE DEALER WERE UNABLE TO DIAGNOSE THE FAILURE. THE CURRENT MILEAGE WAS 29,687 AND FAILURE MILEAGE WAS 975.
NHTSA ODI #10214094
Official recalls
10Oct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Air Bags:frontal:driver Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Jan 9, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2012 Toyota 4Runner, Corolla, Corolla Matrix, Sienna, Yaris, Scion xB, Lexus ES350, GX460, IS-F, IS250, IS350, IS250C, IS350C, and Lexus LFA vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain 2009 Toyota Corolla, Corolla Matrix, Yaris, Yaris HB, Scion xB, Pontiac Vibe, Lexus, ES350, IS250, IS350, and IS-F vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Toyota is recalling certain 2006-2008 Lexus IS250 and IS350, 2007-2008 Lexus ES350, Toyota Yaris, Yaris HB, and 2008 Lexus IS-F and Scion xB vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on February 1, 2017. Owners may contact Toyota customer service at 1-800-331-4331, or Pontiac customer service at 1-800-762-2737. Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), H0A (Toyota Zone C), GLG (Lexus Zone A), GLH (Lexus Zone B) and HLA (Lexus Zone C).
May 23, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Apr 9, 2014
Toyota is recalling certain model year 2006-2010 Yaris vehicles manufactured August 22, 2005, through May 12, 2010, and 2008-2010 Scion xD vehicles manufactured April 4, 2007, through May 12, 2010. In the affected vehicles, the springs used for the seat rails on the driver's seat and the seat rails of the front passenger seat of three-door models may break.
Consequence & remedy
Consequence: If the spring breaks, the seat may not lock in position. In the event of a vehicle crash, the seat could move increasing the risk of injury to the seat occupant.
Remedy: Toyota will notify owners, and dealers will inspect the seat rail, and replace it with a new one, if necessary, free of charge. The recall began on July 3, 2014. Owners may contact Toyota at 1-800-331-4331.
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jan 29, 2009
TOYOTA IS RECALLING 134,895 MY 2006-2007 YARIS VEHICLES EQUIPPED WITH DRIVER AND FRONT PASSENGER SEAT BELT PRETENSIONERS, WHICH ARE DESIGNED TO BE ACTIVATED IN RESPONSE TO A SEVERE FRONTAL IMPACT. WHEN THE SENSOR DETECTS A SEVERE FRONTAL IMPACT, THE FRONT SEAT BELTS ARE QUICKLY DRAWN BACK BY THE RETRACTORS SO THAT THE BELTS SNUGLY RESTRAIN THE OCCUPANTS. THE INVOLVED VEHICLES CONTAIN A CENTER PILLAR SOUND INSULATOR LOCATED UNDERNEATH EACH FRONT SEAT BELT PRETENSIONER.
Consequence & remedy
Consequence: IN THE EVENT OF SEAT BELT PRETENSIONER DEPLOYMENT, THE GAS GENERATED MAY AFFECT THE SOUND INSULATORS. IN THE WORST CASE, IF THE SOUND INSULATORS IGNITE, THIS CONDITION WILL RESULT IN A POST-COLLISION FIRE.
Remedy: DEALERS WILL MODIFY THE VEHICLE FREE OF CHARGE. THE MODIFICATION WILL ENTAIL REMOVAL OF THE SMALL URETHANE CENTER PILLAR SOUND INSULATORS (SPONGE) UNDERNEATH THE DRIVER AND FRONT PASSENGER SEAT BELT PRETENSIONERS. THE RECALL BEGAN ON JANUARY 28, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
EA12006 · Power Window Master Switch Fire
Opened Jun 14, 2012 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Additional source detail variants (3)
Electrical System
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Structure:body
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
PE12002 · Power Window Master Switch Fire
Opened Feb 6, 2012 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Additional source detail variants (3)
Electrical System
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Structure:body
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Illustration