2022 Toyota Tundra

This 2022 Toyota Tundra TRD Pro is subject to Limited Service Campaign 24TD01 for premature tire wear, caused by a factory front toe/camber angle defect acknowledged by Toyota. The vehicle received the campaign remedy (front alignment adjustment and tire replacement) in May 2024, but the same wear pattern on the front tires reappeared and has continued for over a year, documented across multiple dealership visits. A dealership technician found abnormal front tire wear on three separate occasions (August 2025, September 2025, and March 2026) but never recommended a front-end alignment despite Toyota's own campaign identifying alignment/camber as the root cause. As of August 2026, the right front tire tread had worn down to approximately 1/32 inch, an unsafe condition, and only then was an alignment finally recommended in writing for the first time. The vehicle also had a documented brake rotor warping issue (front rotors) as early as November 2024, causing a braking vibration above 40 mph that has persisted. The recurring tire wear presents an ongoing safety risk due to reduced traction and control, particularly relevant given the near-bald tire condition reached before any alignment correction was recommended by the servicing dealer.

The vehicle was purchased brand new from an authorized franchised dealership, sold and contracted as being equipped with a dealer-installed 2.5-inch suspension lift. At approximately 20,000 miles, a severe front-end squeaking symptom developed. The vehicle was brought to a separate authorized Toyota dealership service center for inspection. An authorized Toyota Master Technician formally inspected the vehicle and documented that the selling dealership did not install an engineered suspension lift. Instead, they installed unauthorized, budget aftermarket spacer pucks and non-certified upper control arms. The Master Technician documented in writing that the vehicle "isn't even lifted properly" and a factory front strut has failed prematurely. SAFETY RISK: The unauthorized spacer modification has severely altered and compromised the factory steering and suspension geometry. Because the front suspension, upper control arms, ball joints, struts, and steering rack are forced to operate continuously at unsafe, extreme, out-of-spec angles, the components are subjected to premature, destructive stress. The Master Technician confirmed that this improper configuration creates an imminent highway life-safety hazard, presenting an extreme risk of the front CV axles binding or snapping at highway speeds, which would result in an immediate, catastrophic loss of steering control. The vehicle is available for inspection upon request. The safety defect has been explicitly reproduced and confirmed in writing by an authorized Toyota Master Technician. The selling dealership management has been formally notified of this safety diagnosis but has actively refused to remediate the unsafe components, leaving a structurally compromised and highly dangerous vehicle operating on public highways.

Front end alignment is incorrect from Toyota factory. This is reflected in the service campaign 24TD01 for this vehicle. Toyota refuses to fix the problem, stating the campaign has expired. The alignment causes premature uneven wear of the tires, which is a safety problem. The 24TD01 campaign document states the dealer should complete the service prior to sale. Marietta Toyota DID NOT complete this service on my vehicle before sale.

My 2022 had a new crate engine put in at 26,000 miles in approx June 2025 (told me it would be 2 days but in less than 24hrs the service advisor called and told me it was completed) and from the second I picked up my truck and started it at the dealership, I heard a loud, fast ticking noisy sound coming from under the hood so I popped my hood and it sounded like a diesel engine and as I started driving I felt a weird popping/vibrating noise when turning either right or left at slow speeds and it felt like there were no shocks or motor mounts or something was bent and the rear end was skipping and making a loud thud when slightly stepping on gas pedal and Toyota said it's all normal. It also lost all power while I was driving 2 days after I picked it up from engine replacement along with the continuous surging forward when taking off from stop sign or red light. My front seat is cracked and they refused to fix it under warranty, my brakes squeal so bad and they said they ordered parts under TSB but it will be months before they come in, it's now been 7 months and still nothing. I will not drive further than 10 miles from my home Every time I get in this truck and put it in D, I fear for my life and when I put it in P, I breathe a sigh of relief. AutoNation Toyota in Weston, Fl replaced my engine and I truly believe that whoever put my new engine in, didn't put it back together correctly and damaged the suspension/steering system as well as the new ticking engine that is so rough. My new 2nd engine needs another engine. I feel like this truck is going to get me killed.

First I had my engine replaced in May 2025 under the recall and service advisor informed me it would be about 3 days before they completed the engine swap and it had to sit to make sure there were no leaks anywhere and in less than 24 hrs the called me and told me my truck was all done. I went to pick my truck up they had it waiting in the service line with the engine running, I heard a strange ticking noise coming from under my hood that sounded like a lawnmower engine, the service tech tells me that is normal with the replacement engines which is absolutely false. Being a woman they tell me I don't know what I'm talking about. I got frustrated and got in my truck and when I came to the first stoplight when the light turned green and I stepped on the gas pedal, my truck would not move, after about 5 seconds it surged forward and then again wouldn't move, then again my truck surged forward with a loud thud in the rear like somebody hit me from behind. It feels like it isn't kicking into gear and also my steering wheel was not centered when they swapped the engine so I have to hold my steering off to one side for my truck to drive straight. This has been a nightmare for me and Toyota refuses to acknowledge there is anything wrong. I've also been waiting for 7 months to get my front brakes fixed under the TSB and all they say is we don't have parts available, meanwhile they're building new trucks with new brake pads, rotors and calipers before taking care of the people waiting months and months? They try and wait until your warranty runs out so I have to pay for the fix. Please help. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On [XXX] I was driving in Connecticut when I realized we had taken the wrong directions. We were following my son’s girlfriend’s iphone which kept changing the directions. When we ended up with an over pass in a parking area I applied my brakes but the brakes didn’t work. I was trying to go left to take an alternate road but couldn’t stop. This kind of thing where the brakes or steering have been happening on and off since we got the truck I believe someone has hacked into it using a car kit is what I found under devices but then it disappeared. It also changes my truck into towing mode which is another thing it does. This is done everyday. I noticed I have no history on my truck. This is because it can be put on and taken off randomly. I believe it is a family members doing this to me. We had a Nissan and they did it to that too. It totaled our new camper. I will have to get USAA TO SEND ME SOME COPIES OF PAPERWORK SINCE SOMEONE KEEPS BREAKING INTO OUR APARTMENT AND STEALING THINGS INCLUDING PAPERWORK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1.Jan 3 Power steering wheel low power error message 2.Jan 18 Truck stalled on freeway when hit hard brake Dealer can't duplicate issue just return the truck 3. Jan 31 Check Engine light was on Dealer said Fuel gate issue but didn't doesn't need to fix 4. Feb 2 all brakes LED went out dealer replace Instrument cluster Truck still at Dealer as of today 2/10/22