What component failed and is it available for inspection? The front driver-side roof seam on my 2022 Toyota Tundra developed corrosion under the paint and eventually opened enough for rainwater to enter the cabin. Water drips directly into the A-pillar area onto the side curtain airbag wiring, squib connector, and padded harness…
Read full complaint
What component failed and is it available for inspection? The front driver-side roof seam on my 2022 Toyota Tundra developed corrosion under the paint and eventually opened enough for rainwater to enter the cabin. Water drips directly into the A-pillar area onto the side curtain airbag wiring, squib connector, and padded harness. It also reaches the dashboard and electrical buttons near the steering wheel during rain. The roof seam, A-pillar wiring, interior rust staining, and all affected components remain available for inspection. How was safety put at risk? The A-pillar contains the SRS curtain airbag system, its wiring, and connectors that should never be exposed to moisture. Continuous water intrusion over many months can cause corrosion, increased resistance, short circuits, or damage to the airbag inflator/squib circuit, which may lead to unintended deployment or failure to deploy in a crash. Water reaching the dashboard controls and electrical switches could cause intermittent electrical faults or malfunction of driver controls. These issues present a significant safety risk because the vehicle’s airbag and electrical systems may not function as designed. Has the problem been reproduced or confirmed? Yes. The Toyota dealer has repeatedly observed the active leak, interior rust streaks, and bubbling/corrosion along the roof seam. The water intrusion occurs every time it rains. Has the vehicle been inspected? Yes. Toyota has inspected the truck multiple times, including by a Field Technical Specialist. However, Toyota has been unable to provide complete documentation or photos from the FTS inspection, and the underlying safety issue remains unresolved. No inspections have been done by police or insurance. Warning lamps or messages? No warning lamps appeared. The first symptom was water leaking into the cabin around March 2024, followed by rust streaking inside the A-pillar and exterior bubbling. The issue continues during rainfall.
NHTSA ODI #11700437
5,000 miles · Apr 28, 2023
Air BagsForward Collision AvoidanceCrash
The contact owns a 2022 Toyota Tundra. The contact stated that while driving approximately 40 mph the vehicle crashed into a tree causing severe damage to the front end. During the crash, the air bags did not deploy and the collision avoidance system did not activate to prevent the crash from occurring. No injuries were reported…
Read full complaint
The contact owns a 2022 Toyota Tundra. The contact stated that while driving approximately 40 mph the vehicle crashed into a tree causing severe damage to the front end. During the crash, the air bags did not deploy and the collision avoidance system did not activate to prevent the crash from occurring. No injuries were reported. A police report was filed at the scene and the vehicle was towed away. The cause of the failure was not determined. The manufacturer was notified of the failure. The local dealer was not contacted. In addition, while driving at highway speeds the Tonneau cover nearly came off the vehicle. The cause of the failure was not determined. The failure mileage was 5000.
NHTSA ODI #11519420
Mileage unknown · Apr 5, 2022
Air BagsFuel/propulsion SystemUnknown Or Other
I have been noticing since the beginning to middle of March 2022 the truck has been stalling while driving. It has happened 4 times since that time. Twice while in traffic and twice while driving on the highway. You have to come to a complete stop, put the vehicle in park and start the vehicle again. One time it happened we were…
Read full complaint
I have been noticing since the beginning to middle of March 2022 the truck has been stalling while driving. It has happened 4 times since that time. Twice while in traffic and twice while driving on the highway. You have to come to a complete stop, put the vehicle in park and start the vehicle again. One time it happened we were almost rear ended by a semi truck driving behind us. Along with that, the Air Bag malfunction light has been coming on and off every few days. The fuel gauge has been showing all different fuel amounts as well every day. The truck has been a Toyota dealer for the past week and been communicating with Toyota engineers and I have been told by the service advisor Toyota is aware of these problems but do not have a fix. My family is terrified to drive the truck any longer and is a very dangerous and serious problem. I am not the only one who is experiencing this based on my own research. I did tell my dealer to document this on my record in detail as if anything happens to my family because of an engineering error I will take this to the highest level ever seen.
NHTSA ODI #11459674
Mileage unknown · Mar 9, 2022
Air Bags
SRS Airbag system malfunction error stated visit your dealer after turning the truck off warning was gone.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2024 Toyota Tundra, Lexus LX, and 2024 Lexus GX vehicles equipped with a V35A engine. Debris from the manufacturing process may contaminate the engine and cause the main bearings to fail, which can result in an engine stall and loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will perform an inspection on the #1 main bearing using vehicle inspection software and drive data, and if necessary, replace the engine. Repairs will be performed free of charge. Owner letters were mailed August 28, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB14 and 25TA14. Lexus' numbers for this recall are 25LB07 and 25LA07. This recall expands previous NHTSA recall number 24V381.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2025 Tundra, Tundra Hybrid, and 2023-2025 Sequoia Hybrid vehicles. A software error may cause the rearview image not to display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the multimedia display software, free of charge. Owner notification letters were mailed November 19, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB10 and 25TA10.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2025 Toyota Tundra and Tundra Hybrid vehicles. Moisture may enter the reverse light assemblies and cause a light failure.
Consequence & remedy
Consequence: Reverse light failure may reduce visibility, and not alert pedestrians and other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy: Dealers will replace both reverse light assemblies and repair the wire harnesses as necessary, free of charge. Owner letters were mailed May 23, 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331.Toyota's numbers for this recall are 24TB06 and 24TA06.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Lexus LX600 vehicles equipped with a V35A engine. Debris from the manufacturing process may contaminate the engine and cause the main bearings to fail, which can result in an engine stall and loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the engine assembly, free of charge. Owner letters were mailed between December 17, 2024 and February 19, 2025. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24TB07/24TA07 and 24LB04/24LA04.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2024 Tundra, Tundra Hybrid, Lexus LX600, and 2023-2024 Sequoia Hybrid vehicles. Unexpected vehicle movement may occur when the vehicle is in neutral and the brakes are not applied.
Consequence & remedy
Consequence: Unexpected vehicle movement can increase the risk of a crash.
Remedy: Dealers will update the transmission control ECU software, free of charge. Owner notification letters were mailed April 8, 2024. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24TA02 and 24LA02.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2022-2024 Toyota Tundra vehicles. The load carrying capacity modification label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: SET will mail a new modified label, free of charge. Owner notification letters were mailed December 18, 2023. Owners may contact SET's customer service at 1-866-405-4226. SET's number for this recall is SET23B.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Tundra Hybrid vehicles. The plastic fuel tube routed near metallic brake lines may chafe against the brake lines and become damaged, possibly resulting in a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Dealers will install protective materials and a clamp on the fuel tube, free of charge. Owner letters were mailed November 6, 2024. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB09/23TA09.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Tundra Hybrid vehicles that may be equipped with a Toyota genuine accessory tonneau cover. The tonneau cover attachment joints may come loose and allow the cover to detach.
Consequence & remedy
Consequence: A tonneau cover that detaches while driving can become a road hazard, increasing the risk of a crash.
Remedy: Owners of the subject vehicles will be notified by first class mail to return their vehicles to a Toyota dealer. Dealer will install new hardware (bolts, spacers, washers, nuts, rubber washers and cotter pins) to the existing bracket and tonneau cover. If the tonneau cover has tears or splits at the mounting holes to the extent that new hardware cannot be installed, it will be replaced with a new tonneau cover and hardware. Owners will receive a notice once the remedy becomes available. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TB03/23TA03.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Tundra Hybrid vehicles. A software error in the combination meter's electronic control unit (ECU) may cause the Instrument Panel LCD display to go blank. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence & remedy
Consequence: A blank display will not show critical information such as the speedometer or warning lights, increasing the risk of a crash.
Remedy: Dealers will update the combination meter ECU software, free of charge. Owner notification letters are expected to be mailed April 17, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA02.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Lexus NX250, NX350, and Toyota Tundra vehicles. The Skid Control ECU within the Brake Actuator Assembly may falsely detect an overcurrent condition of the Electronic Parking Brake (EPB) Actuator and enter a failsafe mode which prevents the EPB from being engaged. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: An electronic parking brake that cannot be engaged while in "park," may result in a vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will reprogram the Skid Control ECU, free of charge. Owner notification letters were mailed November 1, 2022. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 22TA11 and 22LA04.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Tundra and Tundra Hybrid vehicles equipped with a Panoramic View Monitor (PVM) system. Incorrect programming of the parking-assist electronic control unit (ECU) software, may cause the front camera image to appear on the multimedia display instead of the rear camera image when the shifter is placed into reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that fails to display the correct image can reduce the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will reprogram the parking assist ECU, free of charge. Owner notification letters were mailed July 27, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 22TA07.
Additional source detail variants (2)
Back Over Prevention:display Function
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Tundra and Tundra Hybrid vehicles equipped with a Panoramic View Monitor (PVM) system. Incorrect programming of the parking-assist electronic control unit (ECU) software, may cause the front camera image to appear on the multimedia display instead of the rear camera image when the shifter is placed into reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview camera that fails to display the correct image can reduce the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will reprogram the parking assist ECU, free of charge. Owner notification letters were mailed July 27, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 22TA07.
Electrical System:adas:parking Assist:software
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Tundra and Tundra Hybrid vehicles equipped with a Panoramic View Monitor (PVM) system. Incorrect programming of the parking-assist electronic control unit (ECU) software, may cause the front camera image to appear on the multimedia display instead of the rear camera image when the shifter is placed into reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview camera that fails to display the correct image can reduce the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will reprogram the parking assist ECU, free of charge. Owner notification letters were mailed July 27, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 22TA07.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Tundra and Tundra Hybrid vehicles. The flange nuts on the axle shaft sub-assemblies can loosen over time and potentially cause one or both axle shaft sub-assemblies to separate from the axle housing.
Consequence & remedy
Consequence: Axle shaft separation can cause a loss of vehicle stability and brake performance, increasing the risk of a crash.
Remedy: Dealers will inspect the rear axle assembly, tighten the axle flange nuts, and replace any damaged axle-related components if necessary, free of charge. Owner notification letters are expected to be mailed July 15, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 22TA05.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Tundra vehicles equipped with a Panoramic View Monitor (PVM) system. The parking assist electronic control unit (ECU) software may prevent transmission of the rearview camera signal during cold weather, preventing the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will reprogram the parking assist ECU software, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 22TA04.
Additional source detail variants (2)
Back Over Prevention:display Function
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Tundra vehicles equipped with a Panoramic View Monitor (PVM) system. The parking assist electronic control unit (ECU) software may prevent transmission of the rearview camera signal during cold weather, preventing the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview camera that does not display an image reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will reprogram the parking assist ECU software, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 22TA04.
Electrical System:software
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Tundra vehicles equipped with a Panoramic View Monitor (PVM) system. The parking assist electronic control unit (ECU) software may prevent transmission of the rearview camera signal during cold weather, preventing the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview camera that does not display an image reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will reprogram the parking assist ECU software, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 22TA04.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2022 Toyota Tundra Problems, Complaints & Recalls | Skip That Year
Illustration