NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
13 reportsClear category filter100,500 miles · Apr 14, 2026
Electrical SystemExterior LightingFireInjury
The contact owns a 2019 Toyota Tundra. The contact stated that while parked for 5-10 minutes, the contact noticed a burning plastic odor, and upon looking up moments later, the contact noticed flames coming from the driver's side headlight, and the flames were 6 inches above the headlight. The contact started extinguishing the f…
Read full complaint
The contact owns a 2019 Toyota Tundra. The contact stated that while parked for 5-10 minutes, the contact noticed a burning plastic odor, and upon looking up moments later, the contact noticed flames coming from the driver's side headlight, and the flames were 6 inches above the headlight. The contact started extinguishing the fire with water bottles. The contact drove to a water hose, which the contact also used to extinguish the fire. The contact sustained minor smoke inhalation. No police report was filed. The contact was able to drive to the nearby residence. The contact related the failure to NHTSA Campaign Number: 21V688000(Exterior Lighting, Electrical System), which included the VIN. The manufacturer was notified of the failure and sent a field inspector, who inspected the vehicle and informed the contact that the inspection report would be completed on the same day; however, the manufacturer would follow up with the contact within 45-60 days. The contact followed up with the manufacturer three days later and was provided with the same information. The dealer was not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 100,500.
NHTSA ODI #11731104
Mileage unknown · Aug 18, 2025
Electrical SystemService Brakes
Intermittent message displaying "Trailer Brakes Disconnected" while towing. Trailer lights continued to operate even while message was displayed. On average trailer connected and disconnected every 2-3 minutes
NHTSA ODI #11681433
Mileage unknown · Jul 24, 2025
Electrical SystemForward Collision Avoidance
Keep getting the messages "Trailer brake error, if towing come to a stop with manual controls" And "Pre-collision system malfunction" The messages go away usually after restarting the vehicle but eventually comes back on
NHTSA ODI #11676036
102,000 miles · Apr 2, 2025
Electrical SystemFuel System, Gasoline
The contact owns a 2019 Toyota Tundra. The contact stated while driving at an undisclosed speed on several occasions, the vehicle stalled. There was no warning light illuminated. The vehicle failed to restart and was towed to the dealer on two occasions. The dealer diagnosed that the fuel pump had failed and needed to be replace…
Read full complaint
The contact owns a 2019 Toyota Tundra. The contact stated while driving at an undisclosed speed on several occasions, the vehicle stalled. There was no warning light illuminated. The vehicle failed to restart and was towed to the dealer on two occasions. The dealer diagnosed that the fuel pump had failed and needed to be replaced; however, the fuel pump part #770200C170 was on backorder. The dealer reprogrammed the fuel pump system twice as temporary repairs; however, the failure persisted. The contact stated while driving 35 MPH, the vehicle stalled. There was no warning light illuminated. The contact was unable to pull over to the side of the road. The vehicle failed to restart and was towed to the residence, where it was diagnosed by a mobile mechanic. The mechanic diagnosed that that the fuel pump was burned, causing the electrical connector part #9098010844 to burn and melt. The dealer was contacted and informed the contact that the electrical connector part had been discontinued. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under the factory warranty. The failure mileage was approximately 102,000.
NHTSA ODI #11652378
Mileage unknown · Mar 29, 2023
Electrical SystemForward Collision Avoidance
The electrical system malfunctioned, causing all warning lamps on the dashboard to light up. Because this happened while I was driving, I do believe that this electrical issue caused safety concerns for others on the road. The taillights went out first, seconds later, all remaining electrical failed at once, including airbags, w…
Read full complaint
The electrical system malfunctioned, causing all warning lamps on the dashboard to light up. Because this happened while I was driving, I do believe that this electrical issue caused safety concerns for others on the road. The taillights went out first, seconds later, all remaining electrical failed at once, including airbags, windows, headlights at one point, pre collision warning lights, lane departure, and the breaking system failed as well. This caused safety concerns for myself, my passenger, as well as the public because all safety warning sensors failed at once while on the road. The problem has been confirmed by Roseville Toyota, who is a manufacturer, and who currently has the vehicle now, they said that there is definitely an electrical issue and most likely a short of some sort. The warning lamps and messages on the dash lit up one at a time, seconds apart from each other, until the entire dash was lit up completely while I was driving on March 24, 2023.
NHTSA ODI #11514520
Mileage unknown · Feb 26, 2023
Electrical SystemSeats
The seat heater control module has failed causing the plastic to burn and melt, nearly starting a fire. Toyota knows about this but refuses to issue a safety recall.
NHTSA ODI #11509199
Mileage unknown · Jan 22, 2023
Electrical System
2019 Tundra: for no reason or indication the vehicle displayed a “Trailer Break Error” and “Pre-collision System malfunction” warning asking me to pull over if towing anything (nothing was being towed) and to contact the dealership. Vehicle still operational however the menus can’t be seen as the warning is consistent.
NHTSA ODI #11503022
Mileage unknown · Aug 25, 2022
Electrical SystemForward Collision AvoidanceService Brakes
PCS ABS 4LO 4HI Brake ABS BSM Traction Control RCTA Warning Triangle christmas tree started. Along with the Precollision System Malfunction, Drive Start Control Malfunction, Blind Spot Monitor Malfuntion, Rear Cross Traffic Alert, and Trailer Brake Error massages
NHTSA ODI #11481180
Mileage unknown · Jun 4, 2022
Electrical SystemForward Collision AvoidanceCrash
Intermit message "Trailer disconnect " message causing the trailer braking system to fail when attached to truck. Truck brakes are used to stop trailer at unsafe distances. Several trailers were used to verify. I have attached the fix but Toyota says its warranty issue. This is a "safety" issue. I had my 3 year old son in t…
Read full complaint
Intermit message "Trailer disconnect " message causing the trailer braking system to fail when attached to truck. Truck brakes are used to stop trailer at unsafe distances. Several trailers were used to verify. I have attached the fix but Toyota says its warranty issue. This is a "safety" issue. I had my 3 year old son in the truck when i had to apply the brakes and couldn't stop in enough time. The truck brakes could not handle the weight of the trailer hence why the trailer brakes were needed. Please prevent a death.
NHTSA ODI #11467483
12,000 miles · Jan 29, 2020
Electrical SystemExterior Lighting
FLASHING FRONT AMBER TURN SIGNAL LIGHTS ARE NOT ADEQUATELY VISIBLE TO OTHER DRIVERS WHEN DRL OR HEADLIGHTS ARE ON. DUE TO THIS OTHER DRIVERS OFTEN DON'T SEE TURN SIGNAL FROM THE FRONT OF THE VEHICLE.
NHTSA ODI #11302902
Official recalls
9Nov 23, 2021
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence & remedy
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Additional source detail variants (2)
Steering:hydraulic Power Assist System
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Steering:rack And Pinion
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Sep 2, 2021
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2021 Tundra vehicles. The headlight electrical circuits may power the high and low beams simultaneously, which could overheat the electrical connector.
Consequence & remedy
Consequence: An overheated electrical connector can increase the risk of a fire.
Remedy: Dealers will modify the engine wire harness assembly and replace any damaged bulb, bulb connector, and/or headlight assembly as necessary, free of charge. Owner notification letters were mailed April 25, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB06 and 21TA06.
Additional source detail variants (2)
Exterior Lighting:headlights
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2021 Tundra vehicles. The headlight electrical circuits may power the high and low beams simultaneously, which could overheat the electrical connector.
Consequence: An overheated electrical connector can increase the risk of a fire.
Remedy: Dealers will modify the engine wire harness assembly and replace any damaged bulb, bulb connector, and/or headlight assembly as necessary, free of charge. Owner notification letters were mailed April 25, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB06 and 21TA06.
Electrical System:wiring
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2021 Tundra vehicles. The headlight electrical circuits may power the high and low beams simultaneously, which could overheat the electrical connector.
Consequence: An overheated electrical connector can increase the risk of a fire.
Remedy: Dealers will modify the engine wire harness assembly and replace any damaged bulb, bulb connector, and/or headlight assembly as necessary, free of charge. Owner notification letters were mailed April 25, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB06 and 21TA06.
Nov 4, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
Jul 15, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2020 Toyota Tundra vehicles equipped with LED headlight assemblies. Due to a wiring error, the front turn signals may not flash brightly enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the turn signals or hazard lamps do not flash brightly enough, other drivers may fail to see that the turn signal or hazard lamp functions have been activated, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will modify the wire harness connected to the front turn signal bulbs free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-800-270-9371. Toyota's number for this recall is 20TB12/20TA12.
Additional source detail variants (2)
Exterior Lighting:turn Signal
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2020 Toyota Tundra vehicles equipped with LED headlight assemblies. Due to a wiring error, the front turn signals may not flash brightly enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the turn signals or hazard lamps do not flash brightly enough, other drivers may fail to see that the turn signal or hazard lamp functions have been activated, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will modify the wire harness connected to the front turn signal bulbs free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-800-270-9371. Toyota's number for this recall is 20TB12/20TA12.
Electrical System:wiring
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2020 Toyota Tundra vehicles equipped with LED headlight assemblies. Due to a wiring error, the front turn signals may not flash brightly enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the turn signals or hazard lamps do not flash brightly enough, other drivers may fail to see that the turn signal or hazard lamp functions have been activated, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will modify the wire harness connected to the front turn signal bulbs free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-800-270-9371. Toyota's number for this recall is 20TB12/20TA12.
Jan 13, 2020
Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, and ES 350 vehicles on January 13, 2020. On March 4, 2020, Toyota expanded the recall to include certain 2014-2015 Toyota 4Runner and Land Cruiser, 2018 Avalon, Corolla, 2014 FJ Cruiser, 2017 Sienna and Lexus 2018 ES 350, 2018-2019 GS 300, 2013-2014 GS350, 2014-2015 GX 460, IS 350 and LX 570, 2014 IS F, 2018-2019 IS 350, LC 500H and LS 500H, 2013-2015 LS 460, 2015 NX 200T and RC350, 2017 RC 200T and RX 350. Toyota also removed the 2018-2019 Toyota 4Runner and Land Cruiser and 2018-2019 Lexus GX 460 and LX 570 and 2019 NX300 from inclusion in this recall. On March 19, 2020, Toyota expanded the recall to include 2015 Lexus GS350 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump, free of charge. The recall began May 4, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are 20TB02 and 20TA02 for Toyota vehicles and 20LB01 and 20LA01 for Lexus vehicles.
Mar 27, 2019
Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.
Remedy: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.
Dec 19, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Toyota Tundra standard and long bed trucks equipped with a spray-in bed liner. The load carrying capacity modification label may have been incorrectly calculated. If the label is followed, the vehicle may be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle can increase the risk of a crash.
Remedy: Toyota has notified owners, and provided corrected load carrying capacity labels, free of charge. The recall began on January 24, 2019. The recall number is J08. Owners may contact Toyota customer service at 1-888-270-9371.
Oct 11, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 Toyota Tundra vehicles. The accessory all-weather floormats may have been counted twice when creating the load carrying capacity modification label, resulting in the capacity modification label incorrectly overstating the additional weight by 10 pounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Since the incorrect label is not within 1% of the additional weight, the vehicles are not compliant with the FMVSS.
Remedy: All vehicle owners will be sent a corrected label. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0Z.
Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 Toyota Tundra and Sequoia vehicles and 2019 Toyota Avalon and Avalon Hybrid vehicles. The air bag electronic control unit (ECU) may erroneously detect a fault during the vehicle start-up self check. If this occurs, the ECU may not deploy the airbags as intended, in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection," and 214, "Side Impact Protection."
Consequence & remedy
Consequence: If the air bags do not deploy as intended, it can increase the risk of injury in a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the air bag ECU, free of charge. The recall began October 26, 2018. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0X. Note: 18V-122 was superseded by this recall. The software remedy also includes the updates to the software for 18V-122.
Additional source detail variants (2)
Electrical System:software
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 Toyota Tundra and Sequoia vehicles and 2019 Toyota Avalon and Avalon Hybrid vehicles. The air bag electronic control unit (ECU) may erroneously detect a fault during the vehicle start-up self check. If this occurs, the ECU may not deploy the airbags as intended, in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection," and 214, "Side Impact Protection."
Consequence: If the air bags do not deploy as intended, it can increase the risk of injury in a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the air bag ECU, free of charge. The recall began October 26, 2018. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0X. Note: 18V-122 was superseded by this recall. The software remedy also includes the updates to the software for 18V-122.
Air Bags
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 Toyota Tundra and Sequoia vehicles and 2019 Toyota Avalon and Avalon Hybrid vehicles. The air bag electronic control unit (ECU) may erroneously detect a fault during the vehicle start-up self check. If this occurs, the ECU may not deploy the airbags as intended, in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection," and 214, "Side Impact Protection."
Consequence: If the air bags do not deploy as intended, it can increase the risk of injury in a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the air bag ECU, free of charge. The recall began October 26, 2018. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0X. Note: 18V-122 was superseded by this recall. The software remedy also includes the updates to the software for 18V-122.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration