NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
11 reportsClear category filterMileage unknown · Oct 6, 2022
Electrical SystemSteeringVehicle Speed Control
I have multiple problems with the dash lights going on and off , have taken it to car repair when scanned and had replaced relays many times. I have read many stories of people having the same problem with toyota tundras and no one can figure it out. Toyota should have a recall for this because it is not just one or two people w…
Read full complaint
I have multiple problems with the dash lights going on and off , have taken it to car repair when scanned and had replaced relays many times. I have read many stories of people having the same problem with toyota tundras and no one can figure it out. Toyota should have a recall for this because it is not just one or two people with this same exact problem, it is many toyota tundra owners going through the same problems that i' am experiencing.
NHTSA ODI #11488136
Mileage unknown · Jun 9, 2022
SteeringStructure
There is significant rust on the frame of this 2008 Tundra. I am located in North Central WA State and they use compounds on the roads in the winter here similar to what is used in the northeast US. The rust is also on the steering mechanism and spare tire. I just had a flat tire and had to use the spare tire temporarily. Thi…
Read full complaint
There is significant rust on the frame of this 2008 Tundra. I am located in North Central WA State and they use compounds on the roads in the winter here similar to what is used in the northeast US. The rust is also on the steering mechanism and spare tire. I just had a flat tire and had to use the spare tire temporarily. This is a common problem reported on Tundra forums online and this truck should be covered under an ongoing repair mandate since the rust is damaging steering mechanism, brake lines, spare tire support system, etc. These are safety concerns.
NHTSA ODI #11468384
Mileage unknown · May 30, 2022
Steering
Toyota dealer reported that this 2008 Toyota Tundra Double Cab 4WD had a steering fluid leak, and other issues with the steering mechanism that sounds very similar to the current recall from November 2021.
NHTSA ODI #11466636
85,000 miles · Jul 29, 2018
Power TrainSteeringVehicle Speed Control
TRANSMISSION SLIPPED AND VEHICLE LOSE OF POWER. DASHBOARD ALL WARNING LIGHTS BEGAN TO FLASH. PULLED TO SIDE OF ROAD. TURNED OFF VEHICLE ATTEMPTED TO RESET. MANAGED TO GET VEHICLE TO NEARBY PARKING LOT AND OUT OF TRAFFIC. COMPLETE LOSS OF POWER TO DRIVE TRAIN. CAUSE WAS POWER STEERING UNIT SENSOR PER TOYOTA. TOYOTA COVERED…
Read full complaint
TRANSMISSION SLIPPED AND VEHICLE LOSE OF POWER. DASHBOARD ALL WARNING LIGHTS BEGAN TO FLASH. PULLED TO SIDE OF ROAD. TURNED OFF VEHICLE ATTEMPTED TO RESET. MANAGED TO GET VEHICLE TO NEARBY PARKING LOT AND OUT OF TRAFFIC. COMPLETE LOSS OF POWER TO DRIVE TRAIN. CAUSE WAS POWER STEERING UNIT SENSOR PER TOYOTA. TOYOTA COVERED PART IN ATTEMPT TO PREVENT THIS COMPLAINT. FROM INTERNET, "SOME 2007-2008 TOYOTA TUNDRA VEHICLES MAY EXPERIENCE POWER STEERING DTCS P0552 AND/OR P0553. THE POWER STEERING SENSOR HAS SINCE BEEN CHANGED TO CORRECT THIS CONDITION. THE OLD/PREVIOUS POWER STEERING SENSOR IS P/N 89448-34010. THIS HAS BEEN REPLACED WITH SENSOR P/N 89448-34020. USING TIS TECHSTREAM, CONFIRM THE CONDITION BY CHECKING FOR DTCS P0552 AND/OR P-553. DISCONNECT THE PRESSURE SENSOR CONNECTOR AND PROCEED WITH REMOVING THE POWER STEERING PRESSURE SWITCH, WHICH IS LOCATED AT THE POWER STEERING VANE PUMP AND IS MOUNTED TO THE HIGH PRESSURE FEED LINE. INSTALL THE NEW POWER STEERING PRESSURE SENSOR, TIGHTENING TO 15.2 FT.-LBS. (20.6 NM). WITH THE NEW SENSOR FULLY INSTALLED AND CONNECTED, START THE ENGINE AND CHECK FOR LEAKS. ADJUST POWER STEERING FLUID LEVEL AS NEEDED."
NHTSA ODI #11114358
180,000 miles · Jul 31, 2014
Electrical SystemSteering
TL* THE CONTACT OWNS A 2008 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE DRIVERS SIDE AIR BAG AND THE HORN LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING WHEEL WHEN TURING LEFT OR RIGHT. THE STEERING WHEEL WAS DIFFICULT TO MANEUVER. THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE DRIVERS SIDE AIR BAG AND THE HORN LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING WHEEL WHEN TURING LEFT OR RIGHT. THE STEERING WHEEL WAS DIFFICULT TO MANEUVER. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE SPIRAL CABLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000. UPDATED 09/05/14*LJ THE CONSUMER STATED THE TIRE WARNING LIGHT ILLUMINATED, THE HORN, ABS AND CRUISE CONTROL WERE INOPERATIVE. UPDATED 09/09/14
NHTSA ODI #10617901
76,061 miles · Jun 20, 2012
Steering
PRIOR TO THE INCIDENT, THE STEERING COLUMN BECAME VERY LOOSE. I HAD TO KEEP REPOSITIONING IT. I THOUGHT I HAD TIGHTEN THE SAFETY LOCK PIECE THAT HOLDS THE STEERING COLUMN IN PLACE. THE DAY OF THE INCIDENT, AS I WAS GETTING IN MY VEHICLE, THE STEERING COLUMN COMPLETELY CAME DOWN. IT WOULD NOT LOCK IN PLACE. AS I WAS ON MY WAY THE…
Read full complaint
PRIOR TO THE INCIDENT, THE STEERING COLUMN BECAME VERY LOOSE. I HAD TO KEEP REPOSITIONING IT. I THOUGHT I HAD TIGHTEN THE SAFETY LOCK PIECE THAT HOLDS THE STEERING COLUMN IN PLACE. THE DAY OF THE INCIDENT, AS I WAS GETTING IN MY VEHICLE, THE STEERING COLUMN COMPLETELY CAME DOWN. IT WOULD NOT LOCK IN PLACE. AS I WAS ON MY WAY THE STEERING COLUMN MOVED UP AND DOWN, AND IN AND OUT. I COULD NOT CONTROL THE STEERING VEHICLE. THE NEXT DAY I TOOK THE VEHICLE TO A TOYOTA DEALER. I WAS TOLD TWO PIECES OF THE STEERING COLUMN BROKE OFF. I WAS GIVEN A QUOTE FROM TOYOTA IN THE AMOUNT OF $600 FOR THE PART AND $645 FOR LABOR. *JS
NHTSA ODI #10462484
48,035 miles · Apr 4, 2012
SteeringSuspension
RIGHT FRONT TIE ROD STRIPPED OUT AND BECAME SEPARATED FROM RIGHT FRONT WHEEL. *TR
NHTSA ODI #10454148
13,000 miles · Feb 2, 2012
Power TrainSteering
TL* THE CONTACT OWNS A 2008 TOYOTA TUNDRA. THE CONTACT WAS DRIVING 60 MPH WHEN THE VEHICLE STARTED TO SHAKE VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 13,000 AND THE CURRENT MILEAGE WAS 13,500. UPDATED 03/23/12 *BF THE CONSUMER STATED T…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA TUNDRA. THE CONTACT WAS DRIVING 60 MPH WHEN THE VEHICLE STARTED TO SHAKE VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 13,000 AND THE CURRENT MILEAGE WAS 13,500. UPDATED 03/23/12 *BF THE CONSUMER STATED THE VEHICLE ALSO HAS TRANSMISSION PROBLEMS. UPDATED 05/10/12
NHTSA ODI #10446289
32,100 miles · Sep 12, 2011
Steering
TL* THE CONTACT OWNS A 2008 TOYOTA TUNDRA. THE CONTACT STATED THAT WHEN ATTEMPTING A TURN, THE STEERING WHEEL WOULD NOT RE-ALIGN ONCE THE TURN WAS COMPLETED. THE DEALER DIAGNOSED THE VEHICLE WITH A WORN INTERMEDIATE SHAFT AND PERFORMED THE REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 32,35…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA TUNDRA. THE CONTACT STATED THAT WHEN ATTEMPTING A TURN, THE STEERING WHEEL WOULD NOT RE-ALIGN ONCE THE TURN WAS COMPLETED. THE DEALER DIAGNOSED THE VEHICLE WITH A WORN INTERMEDIATE SHAFT AND PERFORMED THE REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 32,358 AND THE APPROXIMATE FAILURE MILEAGE WAS 32,100.
NHTSA ODI #10424767
10 miles · May 3, 2011
Steering
TL* THE CONTACT OWNS A 2008 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE ABNORMALLY PULLED TO THE RIGHT WHEN HE LEFT GO OF THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER SEVERAL TIMES BUT THE FAILURE PERSISTED. A WHEEL ALIGNMENT WAS PERFORMED ON THE VEHICLE WHICH DID NOT REMEDY THE ISSUE AND THE FAILURE …
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE ABNORMALLY PULLED TO THE RIGHT WHEN HE LEFT GO OF THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER SEVERAL TIMES BUT THE FAILURE PERSISTED. A WHEEL ALIGNMENT WAS PERFORMED ON THE VEHICLE WHICH DID NOT REMEDY THE ISSUE AND THE FAILURE CAUSED PREMATURE WEAR OF THE TIRES. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE WAS APPROXIMATELY 45,000 AND THE FAILURE MILEAGE WAS 10. UPDATED 09/08/2011 *LN *TR
NHTSA ODI #10398742
Official recalls
12Nov 23, 2021
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence & remedy
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Additional source detail variants (2)
Steering:hydraulic Power Assist System
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Steering:rack And Pinion
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
May 12, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2007-2011 TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE TPMS ON SOME VEHICLES MAY NOT HAVE BEEN PROPERLY CALIBRATED AND AS A RESULT THE LOW TIRE PRESSURE WARNING LAMP MAY NOT ILLUMINATE SHOULD THE INFLATION PRESSURE IN ONE OR MORE OF THE VEHICLE'S TIRES FALL BELOW THE THRESHOLD FOR WHEN THE LOW TIRE PRESSURE WARNING LAMP SHOULD ILLUMINATE.
Consequence & remedy
Consequence: DRIVERS WILL NOT RECEIVE A WARNING FROM THE TIRE PRESSURE MONITOR THAT ONE OR MORE TIRES ARE UNDERINFLATED, INCREASING THE RISK THAT THE VEHICLE WILL BE DRIVEN WITH ONE OR MORE UNDERINFLATED TIRES, INCREASING THE RISK OF A TIRE FAILURE THAT MAY LEAD TO A CRASH.
Remedy: DEALERS WILL RECALIBRATE THE TIRE PRESSURE MONITORING SYSTEM IN ACCORDANCE WITH THE REGULATION FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JULY 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER ASSISTANCE CENTER TOLL FREE AT 1-800-301-6859, MONDAY THROUGH FRIDAY, 8:30 AM TO 5:00 PM, EASTERN STANDARD TIME.
Mar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
Consequence & remedy
Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration