NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
14 reportsClear category filterMileage unknown · Dec 3, 2025
Fuel/propulsion SystemStructure
The 2016 Toyota Frame Rust Settlement (Burns v. Toyota Motor Sales, U.S.A., Inc.): This $3.4 billion class action directly addresses premature corrosion in 2007–2008 Tundras (and similar models). It claims Toyota “knowingly failed to apply adequate rust protection,” leading to frame perforation despite later treatments like HOF.…
Read full complaint
The 2016 Toyota Frame Rust Settlement (Burns v. Toyota Motor Sales, U.S.A., Inc.): This $3.4 billion class action directly addresses premature corrosion in 2007–2008 Tundras (and similar models). It claims Toyota “knowingly failed to apply adequate rust protection,” leading to frame perforation despite later treatments like HOF. The settlement’s “recurrent perforation” clause applies even after HOF. My rusted-through fuel tank strap and holes in the rear cross member qualify. HOF RO# XXX. Claim #XXX My 2008 Tundra SR5 TRD was treated with HOF in Nov 2017. In November 2025 my mechanic told me the gas tank was falling out as the straps that hold the tank in place were completely rotted out. And rust perforation was on the rear cross member. He instructed me to get a safety inspection at a Toyota dealership to document the rust. Toyota of Waldorf didn’t even schedule a appt, they told me to call the Brand Engagement Center and that there was no possibility of repair because Toyota had no frames. Brand engagement refused to provide any guidance. I scheduled an inspection at Koons Toyota of Annapolis, which it failed inspection with multiple >10mm frame holes and a rusted-through tank strap (held by bungee). They deemed it unsafe to operate and unrepairable. They kept leaving out the information about the rust or the holes until they realized I was not leaving until they documented it properly. I have 3 versions. Despite ZH7 expiration, this is a post-HOF recurrence and safety hazard. I requested goodwill repurchase at 1.5x KBB (~$12k) under the settlement’s intent. The Brand Engagement Center had me call them and [XXX] ” announced she was my case manager, then almost as quickly announced it was going to “Internal Dept” for repurchase review, that she would no longer be my case manager, and that they would get back to me in 60 days. I said the average is 2-4 weeks, not months and that I expected a response in 3-7 days. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.
NHTSA ODI #11702797
Mileage unknown · Nov 19, 2025
Fuel/propulsion SystemStructure
Standard Vehicle Components failed. My 2008 Tundra [VIN [XXX] ] was inspected in Nov 2017 under HOF/WEP, passed with CRC applied, but now has a 2-finger-wide perforation in the frame and rusted through the gas tank support—a clear safety defect in a salt state like Maryland. The undercoating failed prematurely; I need goodwill f…
Read full complaint
Standard Vehicle Components failed. My 2008 Tundra [VIN [XXX] ] was inspected in Nov 2017 under HOF/WEP, passed with CRC applied, but now has a 2-finger-wide perforation in the frame and rusted through the gas tank support—a clear safety defect in a salt state like Maryland. The undercoating failed prematurely; I need goodwill frame replacement or buyback per the $3.4B settlement’s spirit.” (reference the 2017 class action, case no. 3:14-cv-03538). Toyota Brand Engagement Center has refused my request for repair or replacement or buy back. They also refused to provide written refusal. They admitted to recording the conversation, but refused my request for a copy or to record the call myself. There is literally no rust on any other portion of my truck as it is garage kept. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11700423
Mileage unknown · Oct 1, 2023
Fuel/propulsion SystemSuspension
I was washing my truck October,1,2023 and while spraying the underside with water I noticed the fuel tank hanging extremely low from the back while further inspection I observed the rear fuel tank strap had rusted off and the tank was hanging by the front strap which is very corroded along with all inner structure and frame rail…
Read full complaint
I was washing my truck October,1,2023 and while spraying the underside with water I noticed the fuel tank hanging extremely low from the back while further inspection I observed the rear fuel tank strap had rusted off and the tank was hanging by the front strap which is very corroded along with all inner structure and frame rails which is rusted corroded and completely rotted out. This truck has been very well maintained and has only 104354 miles on it.
NHTSA ODI #11547622
Mileage unknown · Aug 1, 2022
Fuel/propulsion System
Took my truck in for maintenance and a bracket was hanging down. Dealer brought me back and showed me corrosion of mid framing and that gas bracket had rotted off. gave me a proposal of over $7000 to repair. I had said to them that I had the frame frame coated during the recall, and why weren't the cross members sprayed at that …
Read full complaint
Took my truck in for maintenance and a bracket was hanging down. Dealer brought me back and showed me corrosion of mid framing and that gas bracket had rotted off. gave me a proposal of over $7000 to repair. I had said to them that I had the frame frame coated during the recall, and why weren't the cross members sprayed at that time. They replied Toyota said it was not needed. Did some research yesterday and found that rusting cross members was a problem, and that tire holders, and gas brackets were a problem. Called Toyota and they explained to me that certain vin #'s were covered but that mine was not. I asked them why my truck with the same issues was not covered? Was told corporate policy. Do I have any rights in this issue. My cell # is [XXX]1, my e-mail is [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11476852
Mileage unknown · Jul 29, 2022
EngineFuel/propulsion SystemSuspension
The air injection pumps went out. Vehicle could not get out of limp mode, was very dangerous as I couldnt get up to speed while merging onto traffic. Had to put hazards on and drive vehicle home under 25mph. Vehicles were going around me. Vehicle is scheduled to be looked at by a dealer, but still recommend this be a safety is…
Read full complaint
The air injection pumps went out. Vehicle could not get out of limp mode, was very dangerous as I couldnt get up to speed while merging onto traffic. Had to put hazards on and drive vehicle home under 25mph. Vehicles were going around me. Vehicle is scheduled to be looked at by a dealer, but still recommend this be a safety issue!!
NHTSA ODI #11476560
Mileage unknown · Sep 16, 2021
Fuel/propulsion System
SECONDARY AIR INJECTION SWITCHING VALVE FAILED WHILE CHANGING LANES CAUSING MY VEHICLE TO GO INTO CREEP MODE AND ALMOST CAUSE A COLISION WITH VEHICLE BEHIND ME DUE TO NO POWER. MY UNDERSTANDING IS THAT THIS IS A SERIOUS AND RE OCCURING ISSUE THAT HAS BEEN AROUND FOR SOME TIME AND I AM JUST NOW BEING MADE AWARE OF IT BY TOYOTA WH…
Read full complaint
SECONDARY AIR INJECTION SWITCHING VALVE FAILED WHILE CHANGING LANES CAUSING MY VEHICLE TO GO INTO CREEP MODE AND ALMOST CAUSE A COLISION WITH VEHICLE BEHIND ME DUE TO NO POWER. MY UNDERSTANDING IS THAT THIS IS A SERIOUS AND RE OCCURING ISSUE THAT HAS BEEN AROUND FOR SOME TIME AND I AM JUST NOW BEING MADE AWARE OF IT BY TOYOTA WHO CLAIMS THIS IS NOT A SAFETY ISSUE. COULD HAVE DIED IN THIS CAR INCIDENT.
NHTSA ODI #11433232
149,000 miles · Apr 24, 2021
Electrical SystemFuel/propulsion SystemVehicle Speed Control
I WAS DRIVING AND ALL OF A SUDDEN MY TRUCK TURNED OFF A LOT WREAKED MY TRUCK DUE TO LOSING POWER. FUEL PUMP CONTROL MODULE IS BAD. THIS WAS A RECALL IN THE DATA BASE
NHTSA ODI #11413696
159,000 miles · Nov 9, 2020
EngineFuel/propulsion SystemVehicle Speed Control
I AM HAVING PROBLEMS WITH MY TRUCK. WHEN DRIVING IT. IT LOOSES POWER. ENGINE SHAKES.. GOES FROM OKAY TO LOSS OF POWER TO BACK TO HAVING POWER. IN CODES ARE SHOWING UP WHEN PLACED ON THE COMPUTER. I HAVE REPLACED SPARK PLUGS AND WIRES. I TOOK THE TRUCK TO TOYOTA AND THEY ADVISED ME THAT THEIR HAS BEEN RECALLS WITH FUEL PUMP AND C…
Read full complaint
I AM HAVING PROBLEMS WITH MY TRUCK. WHEN DRIVING IT. IT LOOSES POWER. ENGINE SHAKES.. GOES FROM OKAY TO LOSS OF POWER TO BACK TO HAVING POWER. IN CODES ARE SHOWING UP WHEN PLACED ON THE COMPUTER. I HAVE REPLACED SPARK PLUGS AND WIRES. I TOOK THE TRUCK TO TOYOTA AND THEY ADVISED ME THAT THEIR HAS BEEN RECALLS WITH FUEL PUMP AND COULD BE THE PROBLEM I AM HAVING.
NHTSA ODI #11373740
195,000 miles · Jun 25, 2020
Fuel/propulsion SystemStructure
REAR LEFT FUEL TANK BRACKET BROKE OFF FROM TRUCK FRAME. IT APPEARS TO HAVE BROKEN AT WELD. SEE PHOTO. NOTICED PROBLEM WHILE DRIVING DUE TO BRACKET RUBBING AGAINST DRIVESHAFT AND SCRAPING ON ROAD. PREVIOUSLY, FUEL TANK BRACKET ON SAME VEHICLE SNAPPED AND HAD TO BE REPLACED. TRUCK TOWED TO SHOP FOR REPAIR. I WILL KEEP BROKEN PAR…
Read full complaint
REAR LEFT FUEL TANK BRACKET BROKE OFF FROM TRUCK FRAME. IT APPEARS TO HAVE BROKEN AT WELD. SEE PHOTO. NOTICED PROBLEM WHILE DRIVING DUE TO BRACKET RUBBING AGAINST DRIVESHAFT AND SCRAPING ON ROAD. PREVIOUSLY, FUEL TANK BRACKET ON SAME VEHICLE SNAPPED AND HAD TO BE REPLACED. TRUCK TOWED TO SHOP FOR REPAIR. I WILL KEEP BROKEN PART ONCE REMOVED FROM TRUCK. *TR
NHTSA ODI #11330731
73,400 miles · May 26, 2019
Fuel/propulsion SystemStructureSuspension
FRAME MOUNT FOR GAS TANK HAS RUSTED AND FUEL TANK IS DROPPING DOWN. LAST YEAR AN UNDERCOATING WAS APPLIED BY A TOYOTA DEALER AND IS PEELING OFF IN CERTAIN AREAS. I BELIEVE PURSUANT TO THE CLASS ACTION LAWSUIT REFERRED TO AS BRIAN WARNER ET AL TOYOTA MOTOR CORPORATION MY VEHICLE MAY BE COVERED UNDER WARRANTY BECAUSE THE GAS TANK …
Read full complaint
FRAME MOUNT FOR GAS TANK HAS RUSTED AND FUEL TANK IS DROPPING DOWN. LAST YEAR AN UNDERCOATING WAS APPLIED BY A TOYOTA DEALER AND IS PEELING OFF IN CERTAIN AREAS. I BELIEVE PURSUANT TO THE CLASS ACTION LAWSUIT REFERRED TO AS BRIAN WARNER ET AL TOYOTA MOTOR CORPORATION MY VEHICLE MAY BE COVERED UNDER WARRANTY BECAUSE THE GAS TANK STRAP MOUNTING IS PART OF THE FRAME. AS OF NOW, MY MECHANIC ADVISED ME NOT TO DRIVE IT AS IT IS A SAFETY HAZARD. I NOTICED THE TANK STRAP WAS HANGING DOWN FROM THE FRAME AND THE GAS TANK WAS ALSO HANGING DOWN WHILE THE VEHICLE WAS PARKED IN MY DRIVEWAY.
NHTSA ODI #11210067
Official recalls
12Nov 23, 2021
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence & remedy
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Additional source detail variants (2)
Steering:hydraulic Power Assist System
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Steering:rack And Pinion
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
May 12, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2007-2011 TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE TPMS ON SOME VEHICLES MAY NOT HAVE BEEN PROPERLY CALIBRATED AND AS A RESULT THE LOW TIRE PRESSURE WARNING LAMP MAY NOT ILLUMINATE SHOULD THE INFLATION PRESSURE IN ONE OR MORE OF THE VEHICLE'S TIRES FALL BELOW THE THRESHOLD FOR WHEN THE LOW TIRE PRESSURE WARNING LAMP SHOULD ILLUMINATE.
Consequence & remedy
Consequence: DRIVERS WILL NOT RECEIVE A WARNING FROM THE TIRE PRESSURE MONITOR THAT ONE OR MORE TIRES ARE UNDERINFLATED, INCREASING THE RISK THAT THE VEHICLE WILL BE DRIVEN WITH ONE OR MORE UNDERINFLATED TIRES, INCREASING THE RISK OF A TIRE FAILURE THAT MAY LEAD TO A CRASH.
Remedy: DEALERS WILL RECALIBRATE THE TIRE PRESSURE MONITORING SYSTEM IN ACCORDANCE WITH THE REGULATION FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JULY 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER ASSISTANCE CENTER TOLL FREE AT 1-800-301-6859, MONDAY THROUGH FRIDAY, 8:30 AM TO 5:00 PM, EASTERN STANDARD TIME.
Mar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
Consequence & remedy
Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration