IllustrationCheck engine light came on suddenly and acceleration slowed… truck will no longer go over 30 mph. Replaced radiator, driver air injection module, and regularly changed oil. no check engine light now the injection module was replaced but truck still will not go over 30 mph or 1800-2000 rpm’s.
2007 Toyota Tundra
Owner reports · Recalls · Investigations
More warning signs than most Tundra years
Owner complaints for the 2007 Toyota Tundra are substantially higher than the model-year median of 144.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tundra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1080–25K
5025–50K
6150–75K
3375–100K
44100–150K
18150K+
314 reports with mileage · 75 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports5 fire reports14 injury reports
Engine complaints
27 reportsTL* THE CONTACT OWNS A 2007 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE MERGING INTO TRAFFIC, THE VEHICLE EXPERIENCED REDUCED POWER AND WAS ONLY ABLE TO DRIVE APPROXIMATELY 30 MPH. THE VEHICLE STABILITY WARNING LIGHT WAS ILLUMINATED AND FLASHING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE VEHICLE STABI…
Read full complaint
TL* THE CONTACT OWNS A 2007 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE MERGING INTO TRAFFIC, THE VEHICLE EXPERIENCED REDUCED POWER AND WAS ONLY ABLE TO DRIVE APPROXIMATELY 30 MPH. THE VEHICLE STABILITY WARNING LIGHT WAS ILLUMINATED AND FLASHING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE VEHICLE STABILITY CONTROL OR SECONDARY INJECTOR VALVE FAILED. THE CONTACT CALLED SUN TOYOTA (3001 US-19, HOLIDAY, FL 34691, (727) 310-3070) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 136,000.
TL* THE CONTACT OWNS A 2007 TOYOTA TUNDRA. THE CONTACT WAS UNABLE TO START THE VEHICLE AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE AIR INJECTOR VALVE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE INJECTOR VALVE WAS REPLACED AND THE FAILURE WAS REMEDIED. THE CONTACT INDICA…
Read full complaint
TL* THE CONTACT OWNS A 2007 TOYOTA TUNDRA. THE CONTACT WAS UNABLE TO START THE VEHICLE AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE AIR INJECTOR VALVE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE INJECTOR VALVE WAS REPLACED AND THE FAILURE WAS REMEDIED. THE CONTACT INDICATED THAT THE SAME FAILURE HAD OCCURRED ON 3 SEPARATE OCCASIONS. THE LOCAL DEALER GRAY DANIAL TOYOTA LOCATED AT 104 GRAY DANIELS BLVD, BRANDON, MS 39042, AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000. *BF *AS
MECHANICS REPAIRING MY ELECTRICAL SYSTEM SAID THAT RATS OR MICE ARE ATTRCTED TO THE SOY WIRING IN THE ENGINE COMPARTMENT AND SAID TOYOTA KNOWS THIS BUT PROVIDES NO HELP WARNING OR ASSISTANCE MY ENGINE COULD HAVE FAILED AND DID... MY TRUCK IS A 2007 TOYOTA TUNDRA CREW CABIN, VIN IS : 5TFRT541X7X''' THE ISSUE CAME FROM N…
Read full complaint
MECHANICS REPAIRING MY ELECTRICAL SYSTEM SAID THAT RATS OR MICE ARE ATTRCTED TO THE SOY WIRING IN THE ENGINE COMPARTMENT AND SAID TOYOTA KNOWS THIS BUT PROVIDES NO HELP WARNING OR ASSISTANCE MY ENGINE COULD HAVE FAILED AND DID... MY TRUCK IS A 2007 TOYOTA TUNDRA CREW CABIN, VIN IS : 5TFRT541X7X''' THE ISSUE CAME FROM NOWHERE ALMOST VAUSING US TO GET HIT BY NORMAL SPEED TRAFFIC AND UNABLE TO DEAL WITH IT AT ALL SIMPLY DRIVING DOWN THE ROAD WHEN THE ENGINE FIRST STOPPED ACCELERATING, THEN CAUSING US TO MOVE ONLY AT LOW SPEED PUTTING US IN SERIOUS JEOPARDY
WE RECEIVED A RECALL FOR THIS VEHICLE FROM TOYOTA TO SAY THE SECONDARY AIR INJECTION SYSTEM VALVE STUCK OPEN, WE CONTACTED THEM, THE VEHICLE WAS UNDER THE MILEAGE, BUT, UNDER THE YEAR OF MANUFACTURE, THIS WAS RELAYED TO US ON TWO DIFFERENT OCCASIONS, VERBALLY, TOYOTA SEEMS RELUCTANT TO PUT IT IN WRITING. THE PROBLEM THEY SAID IS…
Read full complaint
WE RECEIVED A RECALL FOR THIS VEHICLE FROM TOYOTA TO SAY THE SECONDARY AIR INJECTION SYSTEM VALVE STUCK OPEN, WE CONTACTED THEM, THE VEHICLE WAS UNDER THE MILEAGE, BUT, UNDER THE YEAR OF MANUFACTURE, THIS WAS RELAYED TO US ON TWO DIFFERENT OCCASIONS, VERBALLY, TOYOTA SEEMS RELUCTANT TO PUT IT IN WRITING. THE PROBLEM THEY SAID IS CAUSED BY A FAULTY SENSOR INSTALLED WHEN THE VEHICLE WAS ASSEMBLED. WHEN THE SENSOR TRIGGERS, THE VEHICLE LOOSES POWER IMMEDIATELY, THIS CAN BE VERY DANGEROUS WHEN OVERTAKING FOR EXAMPLE. ON BOTH OCCASIONS THE VERBAL MESSAGE WE RECEIVE SAYS TOYOTA WILL NOT REPAIR THE PROBLEM, EVEN THOUGH THEY SENT A RECALL LETTER, AND THE PROBLEM IS CAUSED BY A FAULTY SENSOR INSTALLED WHEN THE VEHICLE WAS MANUFACTURED. IF YOU REQUIRE MORE INFORMATION PLEASE LET US KNOW THANK YOU
TL* THE CONTACT OWNS A 2007 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 40 MPH, THE CHECK ENGINE, ESC, AND VSC WARNING INDICATORS ILLUMINATED, THE VEHICLE STARTED TO LOSE POWER AND WOULD NOT ACCELERATE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE AP…
Read full complaint
TL* THE CONTACT OWNS A 2007 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 40 MPH, THE CHECK ENGINE, ESC, AND VSC WARNING INDICATORS ILLUMINATED, THE VEHICLE STARTED TO LOSE POWER AND WOULD NOT ACCELERATE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.
SINCE THE DAY THAT I BOUGHT THIS VEHICLE I HAVE COMPLAINED ABOUT THE RUST. IT WAS 2 YES OLD WITH 17,000 MILES ON IT. THE BED AND FRAME ARE BADLY RUSTED. I RECEIVED A LETTER FROM TOYOTA ABOUT FRAME AND THEY APPLIED SOME WEIRD BLACK STUFF. TOTAL NIGHTMARE. THE BED ,EVEN THOUGH I FOUND A SERVICE BULLETIN THEY SAY TOO LATE TO DO A…
Read full complaint
SINCE THE DAY THAT I BOUGHT THIS VEHICLE I HAVE COMPLAINED ABOUT THE RUST. IT WAS 2 YES OLD WITH 17,000 MILES ON IT. THE BED AND FRAME ARE BADLY RUSTED. I RECEIVED A LETTER FROM TOYOTA ABOUT FRAME AND THEY APPLIED SOME WEIRD BLACK STUFF. TOTAL NIGHTMARE. THE BED ,EVEN THOUGH I FOUND A SERVICE BULLETIN THEY SAY TOO LATE TO DO ANYTHING. EVEN THOUGH I HAVE BEEN COMPLAINING AT MORE THEN 5 DEALERSHIP'S SINCE 2009 AND CALLED CORPORATE NUMEROUS TIMES. THE BED IS DANGEROUS AND HAS BEEN. THE SUPPORT STRUCTURE,.AROUND MOUNTING BOLTS, EVENTUALLY BED WILL SEPARATE FROM FRAME. VERY CRITICAL SAFETY ISSUE. KNOWN PROBLEM BUT WON'T HONOR . NEXT PROBLEM THAT THEY ALSO HAVE AN UPDATED WARRANTY WHICH I WAS NEVER NOTIFIED ABOUT. SECONDARY AIR INJECTION SYSTEM FAILS ,WHICH IS AN EMISSIONS COMPONENT. CRITICAL TO KEEP EMISSIONS LOW.
SERVICE ENGINE LIGHT CAME ON WHILE DRIVING UNDER 30MPH. ENGINE NO LONGER STARTS CORRECTLY. ONLY 51,000 MILES. AIR PUMP ASSEMBLY AND AIR SWITCHING VALVES ERROR CODE. (P0418) KNOWN DEFUNCT PARTS FOR 2007 TUNDRAS WHICH TOYOTA EXTENDED WARRANTY TO 10 YEARS OR 150,000 MILES. WARRANTY NOT SUFFICIENT LENGTH FOR THIS MODEL YEAR FOR…
Read full complaint
SERVICE ENGINE LIGHT CAME ON WHILE DRIVING UNDER 30MPH. ENGINE NO LONGER STARTS CORRECTLY. ONLY 51,000 MILES. AIR PUMP ASSEMBLY AND AIR SWITCHING VALVES ERROR CODE. (P0418) KNOWN DEFUNCT PARTS FOR 2007 TUNDRAS WHICH TOYOTA EXTENDED WARRANTY TO 10 YEARS OR 150,000 MILES. WARRANTY NOT SUFFICIENT LENGTH FOR THIS MODEL YEAR FOR LOW MILEAGE VEHICLES. COULD NOT HAVE HAD PROPERLY FIXED UNTIL CHECK ENGINE LIGHT COMES ON. HOWEVER, PARTS FAIL AT 50K+ MILES. PLEASE EXTEND WARRANTY TO APPROPRIATE LENGTH FOR THIS ISSUE. NUMEROUS SIMILAR INSTANCES NOTED UPON INTERNET RESEARCH.
I TOOK MY TRUCK FOR SERVICE AT A TOYOTA TUNDRA AND THE SHOP INFORMED ME THAT MY AIR PUMP WAS DEFECTIVE. I CAN'T GO ABOVE 30 MPH UP HILL AND IT DOESN'T SHIFT CORRECTLY WHEN MY TRUCK IS IN LIMP MODE. THE TRACTION CONTROL LIGHT, VEHICLE SWERVE CONTROL LIGHT, AND CHECK ENGINE LIGHT STAYS ON.
WHILE DRIVING THE TRUCK TO LAS VEGAS AUG, 2018 WAS PASSING A LINE OF SEMI'S GOING TO SLOW AFTER PASSING ABOUT 3 OF THEM THE ENGINE JUST STOPPED RUNNING, HAD TO GET TO SIDE OF ROAD FAST, AFTER MAKING IT THERE THE TRUCK WOULD NOT START AGAIN. AFTER AN HOUR OR SO IT STARTED. MADE IT TO VEGAS. THE SAME THING HAPPENED SEVERAL TIMES S…
Read full complaint
WHILE DRIVING THE TRUCK TO LAS VEGAS AUG, 2018 WAS PASSING A LINE OF SEMI'S GOING TO SLOW AFTER PASSING ABOUT 3 OF THEM THE ENGINE JUST STOPPED RUNNING, HAD TO GET TO SIDE OF ROAD FAST, AFTER MAKING IT THERE THE TRUCK WOULD NOT START AGAIN. AFTER AN HOUR OR SO IT STARTED. MADE IT TO VEGAS. THE SAME THING HAPPENED SEVERAL TIMES SINCE THAT DAY ALSO THERE IS NO WARNING LIGHTS SUCH AS "CHECK ENGINE" LIGHT THAT CAME ON.THIS TRUCK WAS BOUGHT NEW IN 2008, WHEN THE FIRST TIME THAT HAPPENED IT HAD 29080 MILES ON IT, I DON'T DRIVE IT THAT MUCH AS I AM RETIRED SO DON'T DRIVE AS MUCH AS I DID BEFORE.THAT TRIP TO VEGAS COULD HAVE BEEN ALL TO DIFFERENT HAD I NOT BEEN ABLE TO GET OFF FREEWAY, BECAUSE THE STEARING AT 70 MPH IS NOT TOO GOOD, COULD HAVE BEEN BAD ACCIDENT FOR MY WIFE AND MYSELF, AND OTHERS THAT MAY HAVE BEEN INVOLVED. TOYOTA DEALER SAID HE NEVER HEARD OF A PROBLEM LIKE THAT WHEN I CALLED THEM. HAVE SEARCHED SEVERAL WEB SITES AND FOUND COMPLAINTS WITH SAME PROBLEM THEREFORE I BELIEVE TOYOTA KNOWS ABOUT IT BUT REFUSES TO REPAIR THEIR PROBLEM. MAYBE THEY NEED A HIGH TOTAL OF DEATHS BEFORE FIXING THEIR PROBLEM. I THINK ITS A FUEL PUMP PROBLEM OR RELATED TO THE ENGINE.
Official recalls
1221V920000 · Steering:hydraulic Power Assist System; Steering:rack And Pinion
Nov 23, 2021
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence & remedy
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Additional source detail variants (2)
Steering:hydraulic Power Assist System
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Steering:rack And Pinion
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
16V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
12V491000 · Visibility:power Window Devices And Controls
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
11V278000 · Tires:pressure Monitoring And Regulating Systems
May 12, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2007-2011 TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE TPMS ON SOME VEHICLES MAY NOT HAVE BEEN PROPERLY CALIBRATED AND AS A RESULT THE LOW TIRE PRESSURE WARNING LAMP MAY NOT ILLUMINATE SHOULD THE INFLATION PRESSURE IN ONE OR MORE OF THE VEHICLE'S TIRES FALL BELOW THE THRESHOLD FOR WHEN THE LOW TIRE PRESSURE WARNING LAMP SHOULD ILLUMINATE.
Consequence & remedy
Consequence: DRIVERS WILL NOT RECEIVE A WARNING FROM THE TIRE PRESSURE MONITOR THAT ONE OR MORE TIRES ARE UNDERINFLATED, INCREASING THE RISK THAT THE VEHICLE WILL BE DRIVEN WITH ONE OR MORE UNDERINFLATED TIRES, INCREASING THE RISK OF A TIRE FAILURE THAT MAY LEAD TO A CRASH.
Remedy: DEALERS WILL RECALIBRATE THE TIRE PRESSURE MONITORING SYSTEM IN ACCORDANCE WITH THE REGULATION FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JULY 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER ASSISTANCE CENTER TOLL FREE AT 1-800-301-6859, MONDAY THROUGH FRIDAY, 8:30 AM TO 5:00 PM, EASTERN STANDARD TIME.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
10V017000 · Vehicle Speed Control:accelerator Pedal
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
08V080000 · Wheels:lugs/nuts/bolts/studs
Feb 25, 2008
SOUTHEAST TOYOTA IS RECALLING 1,555 MY 2007 TUNDRA VEHICLES DUE TO A WHEEL NUT ISSUE. THE RECALLED VEHICLES ARE MY 2007 TUNDRAS EQUIPPED WITH 18" INSTALLED DIAMOND FINISH 5-SPOKE ALLOY WHEELS (OPTION CODE WN1 OR WN4) OR 20" INSTALLED PAINTED ALLOY WHEELS WITH 6 DUAL SPOKES (OPTION CODE WV1 OR WV4). AFFECTED VEHICLES WERE ORIGINALLY SOLD IN FLORIDA, GEORGIA, ALABAMA, NORTH CAROLINA OR SOUTH CAROLINA. WHEN THE VEHICLE WAS PROCESSED AT THE PORT, THE UPGRADED ALLOY WHEELS WERE FASTENED WITH NEW WHEEL NUTS. THE WHEEL NUTS CAN CRACK AND BREAK IF THEY ARE NOT INSTALLED CAREFULLY OR NOT CAREFULLY TIGHTENED. THIS WHEEL NUT CONDITION COULD OCCUR AT THE TIME OF WHEEL INSTALLATION, TIRE ROTATION, OR SERVICE.
Consequence & remedy
Consequence: IF A VEHICLE'S WHEEL HAS A CRACKED OR BROKEN WHEEL NUT CONDITION AND THE WHEEL BECOMES LOOSE AND FALLS OFF THE VEHICLE WITHOUT WARNING, A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE ATTACHING WHEEL NUTS. THE RECALL BEGAN ON APRIL 18, 2008. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
07V579000 · Power Train:driveline:driveshaft
Dec 18, 2007
ON CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS, DUE TO THE IMPROPER HEAT TREATMENT OF THE SLIP YOKES THAT HAD BEEN REWORKED DURING THE MANUFACTURING PROCESS, THE HARDNESS OF THE SLIP YOKE MAY BE INSUFFICIENT.
Consequence & remedy
Consequence: IN THIS CONDITION, THERE IS A POSSIBILITY THAT THE YOKE MAY BREAK CAUSING THE PROPELLER SHAFT TO SEPARATE AT THE JOINT AND COME INTO CONTACT WITH THE ROAD SURFACE OR THE FUEL TANK WHICH COULD RESULT IN A LOSS OF VEHICLE CONTROL OR A FUEL LEAK.
Remedy: DEALERS WILL INSPECT THE SLIP YOKE AND REPLACE THE PROPELLER SHAFT IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 7, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.