NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
125 reports4,950 miles · Jul 24, 2015
Vehicle Speed Control
TL* THE CONTACT OWNS A 2013 TOYOTA TACOMA. WHILE THE GEAR WAS SHIFTED INTO DRIVE WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE UNINTENTIONALLY ACCELERATED. THE CONTACT WAS ABLE TO SHIFT THE GEAR INTO PARK; HOWEVER, THE ENGINE CONTINUED TO REVERSE THE CONTACT WAS ABLE TO TURN OFF THE VEHICLE. THE DEALER PERFORMED A DIAGNOSTIC TEST,…
Read full complaint
TL* THE CONTACT OWNS A 2013 TOYOTA TACOMA. WHILE THE GEAR WAS SHIFTED INTO DRIVE WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE UNINTENTIONALLY ACCELERATED. THE CONTACT WAS ABLE TO SHIFT THE GEAR INTO PARK; HOWEVER, THE ENGINE CONTINUED TO REVERSE THE CONTACT WAS ABLE TO TURN OFF THE VEHICLE. THE DEALER PERFORMED A DIAGNOSTIC TEST, WHICH WAS UNABLE TO LOCATE A FAILURE CODE. THE DEALER ADVISED THAT THE SUDDEN ACCELERATION WAS DUE TO DRIVER ERROR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 4,950. UPDATED 09/21/15*LJ
NHTSA ODI #10743360
Mileage unknown · Jul 13, 2015
Equipment Adaptive/mobility
TL* THE CONTACT OWNS A 2013 TOYOTA TACOMA. WHILE DRIVING AT 60 MPH, WITH THE FLAT BED COVER OPEN, THE BOLTS THAT FASTENED THE COVER FRACTURED. AS A RESULT, THE COVER DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10733758
12,000 miles · Jun 11, 2015
Unknown Or Other
MY 2013 TOYOTA TACOMA 4X4 TRD'S FRONT WHEELS ATTEMPT TO LOCK UP ONE AT A TIME AT HIGHWAY SPEEDS. IT'S LIKE I'M TAPPING JUST ONE OF MY FRONT BRAKES. IF I'M NOT HOLDING THE STEERING WHEEL THE TRUCK WILL VEER OFF THE ROAD. BEAVERTON TOYOTA HAS REPLACED THE WHEEL BEARING, HUB AND A WHEEL SENSOR, CALIBRATED THE STEERING SENSOR AND RE…
Read full complaint
MY 2013 TOYOTA TACOMA 4X4 TRD'S FRONT WHEELS ATTEMPT TO LOCK UP ONE AT A TIME AT HIGHWAY SPEEDS. IT'S LIKE I'M TAPPING JUST ONE OF MY FRONT BRAKES. IF I'M NOT HOLDING THE STEERING WHEEL THE TRUCK WILL VEER OFF THE ROAD. BEAVERTON TOYOTA HAS REPLACED THE WHEEL BEARING, HUB AND A WHEEL SENSOR, CALIBRATED THE STEERING SENSOR AND REALIGNED IT. I BELIEVE THE REASON THE ALIGNMENT WAS SO FAR OFF IS DUE TO THE STRESS OF JUST ONE FRONT WHEEL LOCKING UP REPEATEDLY AT HIGHWAY SPEEDS. THIS HAS BEEN GOING ON OVER A YEAR NOW AND BEAVERTON TOYOTA HAS NOT BEEN ABLE TO RESOLVE THIS PROBLEM. THIS ONLY HAS HAPPENED ON STRAIGHT STRETCHES OF HIGHWAY ABOVE 65MPH AND OCCURS MORE OFTEN ON HOT DAYS.
NHTSA ODI #10724676
50,000 miles · May 26, 2015
Electrical SystemFire
TL* THE CONTACT OWNS A 2013 TOYOTA TACOMA. THE CONTACT HEARD A POPPING NOISE COMING FROM THE VEHICLE AND OBSERVED SMOKE INSIDE THE VEHICLE. AFTER OPENING THE DRIVER SIDE DOOR, THE CONTACT NOTICED FLAMES PRIMARILY ON THE DRIVER SIDE OF THE VEHICLE. THE CONTACT EXTINGUISHED THE FIRE WITH A GARDEN HOSE. THE CONTACT TOOK THE VEHICLE…
Read full complaint
TL* THE CONTACT OWNS A 2013 TOYOTA TACOMA. THE CONTACT HEARD A POPPING NOISE COMING FROM THE VEHICLE AND OBSERVED SMOKE INSIDE THE VEHICLE. AFTER OPENING THE DRIVER SIDE DOOR, THE CONTACT NOTICED FLAMES PRIMARILY ON THE DRIVER SIDE OF THE VEHICLE. THE CONTACT EXTINGUISHED THE FIRE WITH A GARDEN HOSE. THE CONTACT TOOK THE VEHICLE TO A DEALER, BUT IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.
NHTSA ODI #10721370
48,000 miles · May 6, 2015
Electronic Stability Control (esc)Service BrakesUnknown Or Other
DRIVING TO WORK TRAVELING AT BETWEEN 55-60 I WAS GOING AROUND A SLIGHT CURVE MY FOOT WAS ON THE ACCELERATOR AND OUT OF NO WHERE THE ABS OR STABILITY CONTROL OR SOMETHING CAUSED MY TRUCK TO SLAM ON THE BRAKES CAUSING THE FRONT TO DIVE DOWN AND A TEMPORARY LOSS OF CONTROL. NO CRASH JUST SPOOKED. I DRIVE THE ROUTE EVERY DAY THE SA…
Read full complaint
DRIVING TO WORK TRAVELING AT BETWEEN 55-60 I WAS GOING AROUND A SLIGHT CURVE MY FOOT WAS ON THE ACCELERATOR AND OUT OF NO WHERE THE ABS OR STABILITY CONTROL OR SOMETHING CAUSED MY TRUCK TO SLAM ON THE BRAKES CAUSING THE FRONT TO DIVE DOWN AND A TEMPORARY LOSS OF CONTROL. NO CRASH JUST SPOOKED. I DRIVE THE ROUTE EVERY DAY THE SAME WAY NEVER HAD THIS HAPPEN BEFORE. THE SKID INDICATOR WAS FLASHING BUT NO NOTICEABLE SKID. I AM SENSITIVE TO THAT FEELING AND THERE WAS NONE DETECTED PRIOR TO THIS HAPPENING. *TR
NHTSA ODI #10714807
5,654 miles · Apr 9, 2015
Steering
I TOOK MY 4 WHEEL DRIVE TRUCK ON A DIRT ROAD, IT HAS SMALL EMBEDDED ROCKS ON IT, PEOPLE ALSO DRIVE CARS ON THIS ROAD IT IS NO BIG NASTY DIRT ROAD, IT FELT LIKE THE FRONT WHEELS WERE GOING TO FALL OFF AND I WAS WONDERING IF I WAS GOING TO ACTUALLY MAKE IT OUT OF THE 9 MILE DIRT ROAD, I GOT BACK TO THE HIGHWAY AND TOOK MY TIRE WRE…
Read full complaint
I TOOK MY 4 WHEEL DRIVE TRUCK ON A DIRT ROAD, IT HAS SMALL EMBEDDED ROCKS ON IT, PEOPLE ALSO DRIVE CARS ON THIS ROAD IT IS NO BIG NASTY DIRT ROAD, IT FELT LIKE THE FRONT WHEELS WERE GOING TO FALL OFF AND I WAS WONDERING IF I WAS GOING TO ACTUALLY MAKE IT OUT OF THE 9 MILE DIRT ROAD, I GOT BACK TO THE HIGHWAY AND TOOK MY TIRE WRENCH AND CHECKED ALL MY LUG NUTS AND TO ME THEY WERE ALL 1/2 TURN LOOSE, I TOOK IT TO VICTORY TOYOTA AND THEY TOOK IT ON A DIRT PARKING LOT AND I TOLD THEM IT NEEDED TO BE MORE ROUGH AND THEY SEEMED LIKE THEY DID NOT CARE, SO THEY PUT ON INVOICE COULD NOT DUPLICATE PROBLEM AND SENT ME ON MY WAY, NOW I TOOK IT INTO TOYOTA BEFORE THE DATE I PUT ON I JUST CANT FIND INVOICES FOR IT, I TOOK IT TO LAVENDER BROTHERS AND PUT ON A 2 1/2 INCH LIFT KIT ON IT AND I WAS HOPING THAT WAS GOING TO FIX THE PROBLEM BUT IT DID NOT, I HAVE TAKEN IT BACK TO VICTORY TOYOTA 6 TIMES FOR SAME PROBLEM AND THEY TAKE IT OUT TO THE SAME DIRT PARKING LOT AND PUT DOWN CANNOT DUPLICATE CUSTOMERS CONCERN, I TOLD THEM I WAS WILLING TO EVEN PAY FOR IT TO GET FIXED BUT THEY JUST DON'T SEEMED TO CARE I EVEN ASKED SOME OF THEM IF YOU DRIVE 30 MILES TO THIS ROAD I WILL GIVE YOU 300 DOLLARS AND NO ONE TOOK IT, I TELL THEM EVERY TIME THE DIRT ROAD IS NOT ROUGH ENOUGH AND IF THEY COULD GO WITH ME TO THIS PARTICULAR DIRT ROAD THEY WOULD KNOW WITHOUT A DOUBT WHAT I AM TALKING ABOUT BUT THEY DON'T WANT TO GO THE EXTRA MILE FOR A CUSTOMER THAT JUST SPENT 35,000 AND DID NOT GO ON A VACATION IN 5 YEARS TO SAVE FOR THIS TRUCK, SO NOW THE STEERING AT TIMES FEELS LOOSE IN THE STEERING WHEEL AND JUST SOMETIMES WHEN I TURN THE WHEELS ALL THE WAY TO ONE SIDE OR THE OTHER AND START TO ROLL IT MAKES A REAL NASTY NOISE, ITS SAD TO HAVE A NEW TRUCK WITH 8700 MILES ON IT AND I DON'T REALLY FEEL SAFE AND I AM GOING ON VACATION AT THE END OF JULY AND I AM TAKING MY TRUCK AND I JUST HOPE EVERYTHING IS OK. *TR
NHTSA ODI #10704852
6,000 miles · Mar 4, 2015
Service Brakes
IN STOP AND GO HEAVY TRAFFIC ON INTERSTATE, BRAKE PEDAL WENT ALMOST TO THE FLOOR. ON TAKING TRUCK TO TOYOTA DEALER, A FAILED BRAKE MASTER CYLINDER WAS REPLACED UNDER WARRANTY. NO EXPLANATION WAS OFFERED AS TO WHY A VEHICLE WITH ONLY 6000 MILES ON IT WOULD SUFFER A FAILED BRAKE MASTER CYLINDER WHICH COULD HAVE RESULTED IN A CRASH…
Read full complaint
IN STOP AND GO HEAVY TRAFFIC ON INTERSTATE, BRAKE PEDAL WENT ALMOST TO THE FLOOR. ON TAKING TRUCK TO TOYOTA DEALER, A FAILED BRAKE MASTER CYLINDER WAS REPLACED UNDER WARRANTY. NO EXPLANATION WAS OFFERED AS TO WHY A VEHICLE WITH ONLY 6000 MILES ON IT WOULD SUFFER A FAILED BRAKE MASTER CYLINDER WHICH COULD HAVE RESULTED IN A CRASH AND INJURY TO OTHER CARS AND PASSENGERS. *TR
NHTSA ODI #10691993
7,779 miles · Dec 29, 2014
Wheels
ON DATE OF SERVICE I WAS INFORMED BY ADVISOR [XXX] THAT ALL 24 WHEEL FASTENERS (LUGS) HOLDING ON THE WHEEL STUDS DID NOT HAVE AMPLE THREADS. I WAS ESCORTED TO SERVICE AREA OF MY VEHICLE AND SAW WHAT HE WAS DESCRIBING TO ME. IT WAS THE WRONG LUGS NUTS INSTALLED. THERE WAS NO ENOUGH AMPLE THREADS TO TIGHTEN THE LUGS TO THE WHEEL …
Read full complaint
ON DATE OF SERVICE I WAS INFORMED BY ADVISOR [XXX] THAT ALL 24 WHEEL FASTENERS (LUGS) HOLDING ON THE WHEEL STUDS DID NOT HAVE AMPLE THREADS. I WAS ESCORTED TO SERVICE AREA OF MY VEHICLE AND SAW WHAT HE WAS DESCRIBING TO ME. IT WAS THE WRONG LUGS NUTS INSTALLED. THERE WAS NO ENOUGH AMPLE THREADS TO TIGHTEN THE LUGS TO THE WHEEL STUDS 1-3 THREADS DEFINITELY NOT TO VEHICLE SPECIFICATION TO MAINTAIN THE TIRES ON FOR SAFE DRIVING, IT COULD HAVE CAUSE THE TIRES RIP OFF AND APART. MY LIFE WAS IN THERE HANDS AND TOYOTA COULD CARE LESS ABOUT MY SAFETY AND SAFETY OF OTHERS HAD THE WHEELS COME OFF. PHOTO'S WAS TAKEN BY ME AND THE WRONG LUG NUTS WAS OFFERED BACK TO ME. THE TRUCK WAS PURCHASE AT LUGOFF TOYOTA IN SOUTH CAROLINA ON 08/23/13 THE FIRST SERVICE WAS DONE AT DICK DYER TOYOTA IN SC ON 05/07/14 MY SERVICE COPY UNDER LABOR AND PARTS SHOWS TIRE ROTATIONS. IF IN FACT THIS SERVICE WAS DONE IT WOULD HAVE BEEN NOTICE BY DICK DYER TOYOTA ON 05/07/14 THIS ISSUE WAS BROUGHT TO THE ATTENTION OF THE SERVICE MANAGER [XXX] . I WAS TOLD TO TAKE THE TRUCK BACK TO WHERE I PURCHASE IT. THEY COULDN'T DO ANYTHING ABOUT THIS PROBLEM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10668861
30,000 miles · Dec 12, 2014
Service BrakesSteering
WHEN BRAKING BETWEEN 45-65 MPH, I CAN FEEL A STRONG SHIMMY AND SHAKING IN THE STEERING WHEEL. I HAVE TO LET OFF THE BRAKES OR IT FEELS LIKE SOMETHING IS GOING TO BREAK IN THE DRIVE TRAIN, STEERING COLUMN, OR WHEELS ARE GOING TO FALL OFF. ITS VERY SCARY AND DANGEROUS, ESPECIALLY WHEN YOU MIGHT NOT BE ABLE TO STOP THE VEHICLE. I'V…
Read full complaint
WHEN BRAKING BETWEEN 45-65 MPH, I CAN FEEL A STRONG SHIMMY AND SHAKING IN THE STEERING WHEEL. I HAVE TO LET OFF THE BRAKES OR IT FEELS LIKE SOMETHING IS GOING TO BREAK IN THE DRIVE TRAIN, STEERING COLUMN, OR WHEELS ARE GOING TO FALL OFF. ITS VERY SCARY AND DANGEROUS, ESPECIALLY WHEN YOU MIGHT NOT BE ABLE TO STOP THE VEHICLE. I'VE ASKED THE TOYOTA DEALER TO CHECK IT ONCE AND THEY DIDN'T DO ANYTHING TO FIX THE PROBLEM. THIS IS PARTICULARLY UNSAFE WHEN DRIVING 95 OR THE TURNPIKE, AND YOU HAVE TO BRAKE HARD AT TIMES. *TR
NHTSA ODI #10664034
500 miles · Nov 18, 2014
Power Train
WHEN ACCELERATING AFTER A STOP THERE IS A HESITATION OR STALL. THIS HAPPENED WITH OUR 2010 TACOMA, ALSO. WE TRADED FOR A 2013 AND THIS TRUCK DOES THE SAME THING. DEALERSHIP SAYS THE TRANSMISSION IS SEARCHING FOR A GEAR. IT IS A SAFETY ISSUE BECAUSE WHEN YOU PULL OUT IN FRONT OF ONCOMING TRAFFIC THE HESITATION COULD CAUSE E…
Read full complaint
WHEN ACCELERATING AFTER A STOP THERE IS A HESITATION OR STALL. THIS HAPPENED WITH OUR 2010 TACOMA, ALSO. WE TRADED FOR A 2013 AND THIS TRUCK DOES THE SAME THING. DEALERSHIP SAYS THE TRANSMISSION IS SEARCHING FOR A GEAR. IT IS A SAFETY ISSUE BECAUSE WHEN YOU PULL OUT IN FRONT OF ONCOMING TRAFFIC THE HESITATION COULD CAUSE ENOUGH OF A DELAY TO CAUSE AN ACCIDENT. THIS HAPPENS AFTER A COMPLETE STOP AND ALSO AFTER A SLOW DOWN. *TR
NHTSA ODI #10658827
Official recalls
6Jul 3, 2017
Southeast Toyota Distributors, LLC (SET) is recalling certain 2011-2016 Toyota Tacoma and 4Runner vehicles equipped with accessory hood scoops installed by SET or SET dealers. The adhesive attaching the hood scoop may weaken, allowing the hood scoop to detach from the vehicle.
Consequence & remedy
Consequence: If the hood scoop detaches, it may become a road hazard, increasing the risk of a crash.
Remedy: SET will notify owners, and dealers will mechanically fasten the scoop to the hood, free of charge. The recall began on September 1, 2017. Owners may contact SET customer service at 1-954-429-2000. SET's number for this recall is SET17B.
Additional source detail variants (2)
Equipment
Southeast Toyota Distributors, LLC (SET) is recalling certain 2011-2016 Toyota Tacoma and 4Runner vehicles equipped with accessory hood scoops installed by SET or SET dealers. The adhesive attaching the hood scoop may weaken, allowing the hood scoop to detach from the vehicle.
Consequence: If the hood scoop detaches, it may become a road hazard, increasing the risk of a crash.
Remedy: SET will notify owners, and dealers will mechanically fasten the scoop to the hood, free of charge. The recall began on September 1, 2017. Owners may contact SET customer service at 1-954-429-2000. SET's number for this recall is SET17B.
Structure:body:hood:hinge And Attachments
Southeast Toyota Distributors, LLC (SET) is recalling certain 2011-2016 Toyota Tacoma and 4Runner vehicles equipped with accessory hood scoops installed by SET or SET dealers. The adhesive attaching the hood scoop may weaken, allowing the hood scoop to detach from the vehicle.
Consequence: If the hood scoop detaches, it may become a road hazard, increasing the risk of a crash.
Remedy: SET will notify owners, and dealers will mechanically fasten the scoop to the hood, free of charge. The recall began on September 1, 2017. Owners may contact SET customer service at 1-954-429-2000. SET's number for this recall is SET17B.
Aug 4, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."
Consequence & remedy
Consequence: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
Remedy: For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.
Feb 12, 2014
Toyota is recalling certain model year 2012 and 2013 Toyota Tacoma and Lexus RX350 vehicles and certain model year 2012 Toyota Rav4 vehicles. In the affected vehicles, the brake system contains a brake actuator that adjusts the fluid pressure of each wheel cylinder. An electrical component within the actuator may experience an increased resistance resulting in the illumination of various warning lights, including those for the Vehicle Stability Control (VSC) system, Antilock Brake System (ABS), and Traction Control system.
Consequence & remedy
Consequence: If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.
Remedy: Toyota will notify owners, and Toyota and Lexus dealers will update the software for the Skid Control electronic control unit, free of charge. The recall began on March 28, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Electronic Stability Control (esc)
Toyota is recalling certain model year 2012 and 2013 Toyota Tacoma and Lexus RX350 vehicles and certain model year 2012 Toyota Rav4 vehicles. In the affected vehicles, the brake system contains a brake actuator that adjusts the fluid pressure of each wheel cylinder. An electrical component within the actuator may experience an increased resistance resulting in the illumination of various warning lights, including those for the Vehicle Stability Control (VSC) system, Antilock Brake System (ABS), and Traction Control system.
Consequence: If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.
Remedy: Toyota will notify owners, and Toyota and Lexus dealers will update the software for the Skid Control electronic control unit, free of charge. The recall began on March 28, 2014. Owners may contact Toyota at 1-800-331-4331.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Toyota is recalling certain model year 2012 and 2013 Toyota Tacoma and Lexus RX350 vehicles and certain model year 2012 Toyota Rav4 vehicles. In the affected vehicles, the brake system contains a brake actuator that adjusts the fluid pressure of each wheel cylinder. An electrical component within the actuator may experience an increased resistance resulting in the illumination of various warning lights, including those for the Vehicle Stability Control (VSC) system, Antilock Brake System (ABS), and Traction Control system.
Consequence: If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.
Remedy: Toyota will notify owners, and Toyota and Lexus dealers will update the software for the Skid Control electronic control unit, free of charge. The recall began on March 28, 2014. Owners may contact Toyota at 1-800-331-4331.
Nov 7, 2013
Toyota Motor Engineering & Manufacturing North America (Toyota) is recalling certain model year 2013-2014 Tacoma vehicles manufactured July 1, 2013, through October 11, 2013. The engines of the affected vehicles contain valve springs that may break over time.
Consequence & remedy
Consequence: If the valve springs break, the engine could fail and stall while the vehicle is being driven, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the valve springs, free of charge. The recall began on November 27, 2013. Owners may contact Toyota at 1-800-331-4331.
Oct 17, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2012-2013 Tacoma vehicles equipped with 18" Maverick Alloy Wheels. In the affected vehicles, the spare tire requires the use of a different style of lug nut to attach it to the vehicle than the other wheels use. These lug nuts were not provided with the vehicle.
Consequence & remedy
Consequence: If the spare tire/wheel is installed on the vehicle using the lug nuts from another wheel, damage to the wheel could result and may eventually lead to a loose wheel, increasing the risk of a crash.
Remedy: SET will notify owners, and dealers will: (a) Install a Warning Label on the spare tire/wheel, (b) supply a bag containing proper spare wheel lug nuts, and (c) place an Owner's Manual Addendum in the vehicle's glove box. The recall began on January 23, 2014. Owners may contact SET at 1-954-429-2000.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.
Illustration