NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
17 reportsClear category filter32,000 miles · Jun 8, 2011
Service Brakes, Hydraulic
BRAKING INCONSISTENCY, USUALLY IN STOP AND GO OR UNEXPECTED TRAFFIC STOPS, SAY AT TRAFFIC LIGHTS AND INTERSECTIONS. OCCASIONALLY THE EFFICIENCY OF THE BRAKES VARIES, USUALLY CAUSING CONCERN THAT ONE MIGHT / WILL NOT BE ABLE TO STOP SHORT OF A COLLISION. IE NEAR MISSES. THIS CONDITION IS EXPERIENCED EVEN ON DRY EXCELLENT ROAD SUR…
Read full complaint
BRAKING INCONSISTENCY, USUALLY IN STOP AND GO OR UNEXPECTED TRAFFIC STOPS, SAY AT TRAFFIC LIGHTS AND INTERSECTIONS. OCCASIONALLY THE EFFICIENCY OF THE BRAKES VARIES, USUALLY CAUSING CONCERN THAT ONE MIGHT / WILL NOT BE ABLE TO STOP SHORT OF A COLLISION. IE NEAR MISSES. THIS CONDITION IS EXPERIENCED EVEN ON DRY EXCELLENT ROAD SURFACES IN NORMAL WEATHER CONDITIONS. SURPRISE, LONGER THAN EXPECTED STOPPING DISTANCES, QUESTIONING IF ALL THE BRAKES ARE FUNCTIONING OR IF ABS IS CUTTING IN PREMATURELY. OCCASIONAL LONG ROLLOUTS STOPS AND A COUPLE OF EXPERIENCES WHERE I HAD TO ALTER HEADING TO ALMOST PASS UP ALONG SIDE THE VEHICLE AHEAD, DURING A FREEWAY STOP AND GO, PANIC STOP HAS MADE ME SUSPECT THAT THERE MIGHT BE A RELATIONSHIP WITH THE AXLE-WRAP (TACOMA) PHENOMENON. COULD THE EXCESSIVE BRAKE BIAS CAUSED ROTATION OF THE REAR AXLE HOUSING AND ABS SENSORS BE IMPARTING A PREMATURE FALSE, IMPENDING WHEEL LOCKUP SIGNAL, TO THE ABS COMPUTER TO UNNECESSARILY BYPASS FLUID UNDER PRESSURE BACK TO THE RESERVOIR AND THUS NOT MAINTAIN FULL BRAKE PRESSURE TO ALL FOUR BRAKES/WHEELS DURING MEDIUM TO HEAVY BRAKING ON GOOD ROAD CONDITIONS? NOT ALL STOPS PRODUCE BUMPING (AXLEWRAP) AND ONLY ON OCCASION IS REDUCED BRAKING A MAJOR FACTOR, HOWEVER THEY DO OCCUR AND USUALLY WHEN YOU ARE NOT EXPECTING IT. TOYOTA DOESN'T SEEM TO HAVE A SOLUTION TO THE AXLE-WRAP RECURRING DISCREPANCY. DEALERSHIPS SEEM TO BELIEVE THAT IF THERE WAS A SERIOUS PROBLEM THEN TOYOTA WOULD TELL THEM ABOUT IT? UNUSUAL BRAKE SHOE WEAR PATTERNS EXIST. ON SUBJECT VEHICLE THE REAR SHOES AT LAST INSPECTION APPEARED TO BE ABOUT HALF WORN AWAY AND THE FRONT DISC PADS WERE RELATIVELY LITTLE WORN AND ONE COULD EXPECT THAT THE BACKS WOULD NEED CHANGING TWO TO THREE TIMES RELATIVE TO THE FRONT DISCS ONCE. THIS MAY SUPPORT THE THEORY THAT A SEVERE BRAKE BIAS EXISTS AND COULD BE DUE TO A MALFUNCTIONING ABS SYSTEM? TECHNICIANS FROM TOYOTA HAVE DRIVEN THE VEHICLE AND HAVE NOT RECOMMENDED ANY SOLUTIONS OR CORRECTIVE MAINTENANCE. 5/10 - 5/11. *TR
NHTSA ODI #10405617
24,000 miles · Feb 23, 2011
Service Brakes, Hydraulic
THIS VEHICLE HAS WHAT I CONSIDER TO BE A BREAK PROBLEM. THE PRESSURE AND LENGTH OF PEDAL DEPRESSION REQUIRED TO STOP THE VEHICLE IS DANGEROUS. I HAVE TO DEPRESS THE PEDAL TO THE FLOOR IN ORDER TO STOP UNDER AVERAGE DRIVING CONDITIONS. IT ACTUALLY FEELS AS THOUGH THE PEDAL HAS NOT FULLY ENGAGED THE BRAKING SYSTEM WHEN COMPLETELY …
Read full complaint
THIS VEHICLE HAS WHAT I CONSIDER TO BE A BREAK PROBLEM. THE PRESSURE AND LENGTH OF PEDAL DEPRESSION REQUIRED TO STOP THE VEHICLE IS DANGEROUS. I HAVE TO DEPRESS THE PEDAL TO THE FLOOR IN ORDER TO STOP UNDER AVERAGE DRIVING CONDITIONS. IT ACTUALLY FEELS AS THOUGH THE PEDAL HAS NOT FULLY ENGAGED THE BRAKING SYSTEM WHEN COMPLETELY DEPRESSED. THE LENGTH OF TRAVEL IN THE PEDAL FROM THE POINT WHERE BREAKS INITIALLY ENGAGE AND COMPLETELY STOPS IS EXCESSIVE AND COULD CAUSE AN ACCIDENT. I HAVE TAKEN THE VEHICLE IN TO TOYOTA FOR SERVICE AND THEY HAVE INDICATED THAT THE BREAKS ARE WITHIN TOYOTA SPECIFICATIONS AND DO NOT REQUIRE SERVICE.
NHTSA ODI #10384968
10 miles · Oct 23, 2010
Service Brakes, Hydraulic
I HAVE A 2009 TOYOTA TACOMA DOUBLE CAB PRE RUNNER. THE BRAKES ARE SPONGY AND BECOME EVEN SOFTER WHEN DRIVEN. THE BRAKE PEDAL SLOWLY LOSES HEIGHT, SINKING TOWARDS THE FLOOR. STOPPING DISTANCE BECOMES UNPREDICTABLE AND THE VEHICLE BECOMES MORE DIFFICULT TO STOP. I'VE COMPLAINED TO THE DEALER SEVERAL TIMES, AND FILED NUMEROUS COMPL…
Read full complaint
I HAVE A 2009 TOYOTA TACOMA DOUBLE CAB PRE RUNNER. THE BRAKES ARE SPONGY AND BECOME EVEN SOFTER WHEN DRIVEN. THE BRAKE PEDAL SLOWLY LOSES HEIGHT, SINKING TOWARDS THE FLOOR. STOPPING DISTANCE BECOMES UNPREDICTABLE AND THE VEHICLE BECOMES MORE DIFFICULT TO STOP. I'VE COMPLAINED TO THE DEALER SEVERAL TIMES, AND FILED NUMEROUS COMPLAINTS WITH YOU GUYS. WILL YOU PLEASE HELP ME RESOLVE MY BRAKING ISSUE. *TR
NHTSA ODI #10361842
5,000 miles · Oct 21, 2010
Service Brakes, Hydraulic
BRAKE PEDAL GOES ALL THE WAY TO THE FLOOR SOMETIMES. IF YOU PUMP IT THEN IT IS OK. *TR
NHTSA ODI #10361588
2,200 miles · Aug 19, 2010
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT DEPRESSED THE BRAKES AND THE ENTIRE BRAKE PEDAL FRACTURED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE BRAKE PEDAL WAS REPLACED DUE TO A BAD WELD. THERE WERE NO PRIOR WARNINGS OF THE FAILURE. THE FAILURE MILEAGE WAS 2,200 AND THE CURRENT MILEAGE WAS 2,800.
NHTSA ODI #10350667
Mileage unknown · Apr 13, 2010
Service Brakes, Hydraulic
S10 APPROPRIATE-LETTER FROM RE CONCERNS ABOUT THE BRAKE PEDAL IN HIS 2009 TOYOTA TACOMA PICKUP TRUCK. *TGW THE CONSUMER STATED HE NOTICED THE BRAKE PEDAL ALMOST WENT TO THE FLOOR BOARD. THE VEHICLE WAS TAKEN TO THE DEALER FOR AN INSPECTION, BUT THEY WERE UNABLE TO FIND ANYTHING WRONG IT. *JB
NHTSA ODI #10325310
6,000 miles · Mar 28, 2010
Service Brakes, HydraulicCrash
A SOME TIMES LOW BRAKE PEDAL, NEVER TAKES HOLD AT THE SAME HIGHT. SOME TIMES AS HIGH AS JUST A 1/2 INCH. THE NEXT TIME BELOW THE THROTLE BY AN INCH. I HAVE HIT A PICK UP IN THE REAR AND A BOULDER. THE DEALER TOLD ME THIS IS NORMAL. WHO DO I BELIVE. *CN
NHTSA ODI #10322526
8,000 miles · Mar 17, 2010
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKE PEDAL, IT WOULD FEEL SPONGY AND WOULD NOT ENGAGE FULLY. THE APPROXIMATE FAILURE MILEAGE WAS 15 MPH. THE BRAKES WOULD FALL ON THE FLOOR BOARD. IN ORDER TO GET THE BRAKES TO ENGAGE, HE HAD TO PUMP THE BRAKE PEDAL SEVERAL TIMES. THE DEALER …
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKE PEDAL, IT WOULD FEEL SPONGY AND WOULD NOT ENGAGE FULLY. THE APPROXIMATE FAILURE MILEAGE WAS 15 MPH. THE BRAKES WOULD FALL ON THE FLOOR BOARD. IN ORDER TO GET THE BRAKES TO ENGAGE, HE HAD TO PUMP THE BRAKE PEDAL SEVERAL TIMES. THE DEALER COULD NOT LOCATE ANY FAILURES IN THE BRAKING SYSTEM. THE DEALER STATED THAT THE BRAKES WERE OPERATING AS DESIGNED AND THE CONTACT WOULD HAVE TO GET COMFORTABLE WITH THE BRAKING SYSTEM. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 8,000 AND THE CURRENT MILEAGE WAS UNKNOWN.
NHTSA ODI #10320492
4,000 miles · Mar 10, 2010
Power TrainService Brakes, HydraulicVehicle Speed Control
PURCHASED NEW TOYOTA TACOMA TRD SPORT IN AUG 2009 WITH ZERO MILES. ALL SEEMED OK, OTHER THAN A FEW FRUSTRATING CAB RATTLES HERE AND THERE. HOWEVER, I ALSO NOTICED THAT AS MY TRUCK NEARED MORE MILES (7,000 CURRENT), I NOW HAVE TO PRESS ON THE BRAKE PEDAL A BIT HARDER, YET WHEN I BROUGHT THIS UP TO THE DEALER, THEY STATED ALL WAS …
Read full complaint
PURCHASED NEW TOYOTA TACOMA TRD SPORT IN AUG 2009 WITH ZERO MILES. ALL SEEMED OK, OTHER THAN A FEW FRUSTRATING CAB RATTLES HERE AND THERE. HOWEVER, I ALSO NOTICED THAT AS MY TRUCK NEARED MORE MILES (7,000 CURRENT), I NOW HAVE TO PRESS ON THE BRAKE PEDAL A BIT HARDER, YET WHEN I BROUGHT THIS UP TO THE DEALER, THEY STATED ALL WAS NORMAL AND COULD NOT REPLICATE. I'VE HAD A COUPLE OF INSTANCES WHERE I'VE HAD TO PRESS THE BRAKE PRETTY HARD TO COME TO A STOP OR SLOW DOWN. IT SEEMS I NEED TO RIDE IT A LITTLE HARDER THAN WHEN I FIRST BOUGHT MY TRUCK. I ALSO WANT TO ADD, THAT BESIDES THE IRRITATING RATTLES (DOOR PANELS/TRAY HOLDER IN CENTER CONSOLE BELOW THE STEERING WHEEL - WHICH WAS REPLACED, BUT STILL MAKE POP SOUNDS HERE AND THERE, THE OTHER SMALLER RATTLES - SOME OF WHICH WERE COMING FROM ILL-FIT WINDOW SEALS WERE NOT REALLY FIXED. THE DEALER REPLACED THE SEALS AND THE POPPING SOUNDS STOPPED FOR A DAY OR SO THEN RETURNED. I FOUND THE PROBLEM IS THE SEALS TEND TO BE SOMEWHAT IMPROPER FIT. IN OTHER WORDS, THEY ARE TOO LARGE AND CAUSE THE RUBBING. I PERSONALLY CORRECTED THIS BY REMOVING ALL DOOR PANELS ONLY TO FIND OUT THAT SOME OF THE RATTLE SOUNDS I HAD COMPLAINED ABOUT MERELY HAD A SMALL PIECE OF FELT ON THE BACKSIDE, WHICH DID NOT COMPLETELY CURE THE PROBLEM. I PURCHASED AN ENTIRE ROLL OF THIS MATERIAL MYSELF AND COATED THE INSIDE OF EACH DOOR PANEL THEN ADDED A SMALL PIECE OF WEATHER STRIPPING TO THE INSIDE OF DOOR PANEL EDGE WHERE IT TOUCHES THE GLASS WINDOW. THIS HELPED CONSIDERABLY IN REDUCING AIR NOISE AND NO MORE RATTLING. MY COMPLAINT IS STILL WITH THE BRAKE PEDAL SOMETIMES, NOT ALWAYS, NEEDING TO BE PUSHED HARDER THAN NORMAL TO COME TO STOP OR SLOW DOWN. ON OTHER THING I ADDRESSED WITH THE DEALER WAS THE FACT THAT WHEN I SLOW DOWN AND MAKE TURN, NOT COMPLETE STOP AND GO, MY ENGINE RPM'S DON'T DECELERATE QUICKLY ENOUGH FOR THE TRANSMISSION TO CATCH UP. DEALER STATES THIS IS NORMAL OPERATING RPMS CATCHING DOWN TO SHIFT DOWN OF TRANNY. *TR
NHTSA ODI #10318522
4,000 miles · Mar 5, 2010
Service Brakes, Hydraulic
HI AND LOW BRAKE PEDAL, HARD TO TELL HOW TO STOP AND HAVE RAN IT A BOLDER AND A PICKUP WITH SMALL DAMAGE. *TR
NHTSA ODI #10316973
Official recalls
13Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 4, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."
Consequence & remedy
Consequence: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
Remedy: For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Mar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
Consequence & remedy
Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration