NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
782 reports72,000 miles · Jan 21, 2021
Structure
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY AT 10 MPH, THE FUEL TANK STRAPS FAILED CAUSING THE FUEL TANK TO DETACH FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE LOCAL DEALER ARLINGTON TOYOTA LOCATED AT 10939 ATLANTIC BLVD, JACKSONVILLE, FL 32225 JACKSONVILLLE FL. WHO DIAGNOSED …
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY AT 10 MPH, THE FUEL TANK STRAPS FAILED CAUSING THE FUEL TANK TO DETACH FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE LOCAL DEALER ARLINGTON TOYOTA LOCATED AT 10939 ATLANTIC BLVD, JACKSONVILLE, FL 32225 JACKSONVILLLE FL. WHO DIAGNOSED THAT THE SUBFRAME HAD SUSTAINED SEVERE RUSTING AND CORROSION AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #11389279
Mileage unknown · Jan 3, 2021
Structure
WHITE PAINT CHIPPING AND PEELING ALL OVER TRUCK WHITE PAINT
NHTSA ODI #11386259
202,000 miles · Dec 11, 2020
Structure
06 TACOMA FRAME THAT HAS RUSTED THROUGH THE FRAME WHERE THE FRONT AND BACK SECTION ARE WELDED TOGETHER. ALSO ON THE ARM TO THE SHOCK HAS RUSTED THROUGH. THE VEHICLE WAS INSPECTED IN 2018 AND THE LEAF SPRINGS WERE REPLACED AND WAS TOLD THE REST OF THE FRAME WAS OK. I ONLY FOUND THE PROBLEM WHEN THE EXHAUST BRACKET WAS HANGING DOW…
Read full complaint
06 TACOMA FRAME THAT HAS RUSTED THROUGH THE FRAME WHERE THE FRONT AND BACK SECTION ARE WELDED TOGETHER. ALSO ON THE ARM TO THE SHOCK HAS RUSTED THROUGH. THE VEHICLE WAS INSPECTED IN 2018 AND THE LEAF SPRINGS WERE REPLACED AND WAS TOLD THE REST OF THE FRAME WAS OK. I ONLY FOUND THE PROBLEM WHEN THE EXHAUST BRACKET WAS HANGING DOWN, WHICH THE WELD BROKE FROM THE RUST.
NHTSA ODI #11383003
56,163 miles · Dec 3, 2020
Seat Belts
IT IS HARD TO PULL OUT AND THE BELT IS NOT TIED ENOUGH. I DID BRING TO THE DEALER FOR RECALL, BUT THEY DONT CONFIRM THAT THEY FIX/REPLACE OR NOT. THE CONSUMER STATED THE SEAT BELT WAS REPAIRED UNDER RECALL BUT, STILL FAILED. *JS
NHTSA ODI #11377753
147,250 miles · Nov 24, 2020
Suspension
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS TAKEN TO SERVCO AUTO (2477 ULU MAIKA ST, LIHUE, HI 96766, (877) 292-9755) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE LEAF SPRINGS WERE RUSTED AND THE RECALL REPAIR COULD NOT BE CO…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS TAKEN TO SERVCO AUTO (2477 ULU MAIKA ST, LIHUE, HI 96766, (877) 292-9755) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE LEAF SPRINGS WERE RUSTED AND THE RECALL REPAIR COULD NOT BE COMPLETED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT ADDITIONAL REPAIRS MAY BE COMPLETED BY THE VEHICLE OWNER. THE FAILURE MILEAGE WAS 147,250.
NHTSA ODI #11376208
280,000 miles · Oct 10, 2020
Service Brakes
WHEN PRESSING THE BREAK PEDAL TO STOP THE TRUCK, THE BREAK PEDAL WILL GO STRAIGHT TO THE FLOOR. THE BREAKS WILL NOT ENGAGE THE TRUCK WILL NOT STOP. PUMPING THE BREAKS DOES NOT BRING THE BREAKS BACK. NO DASHBOARD LIGHT COME ON. THE BREAKS WILL BE GONE FOR ANY LENGTH OF TIME AND THEN WILL START WORKING AGAIN. STOPPING THE TRUCK AN…
Read full complaint
WHEN PRESSING THE BREAK PEDAL TO STOP THE TRUCK, THE BREAK PEDAL WILL GO STRAIGHT TO THE FLOOR. THE BREAKS WILL NOT ENGAGE THE TRUCK WILL NOT STOP. PUMPING THE BREAKS DOES NOT BRING THE BREAKS BACK. NO DASHBOARD LIGHT COME ON. THE BREAKS WILL BE GONE FOR ANY LENGTH OF TIME AND THEN WILL START WORKING AGAIN. STOPPING THE TRUCK AND TURNING IT ON AND OFF WILL NOT BRING THE BREAKS BACK. ONLY WAY TO STOP THE TRUCK WHEN THE BREAKS GO OUT IS WITH THE PARKING BREAK. THIS IS AN INTERMITTENT PROBLEM SOMETIMES THEY WORK SOMETIMES THEY DON'T. WHEN THE BREAKS WOULD GO OUT IT WAS ALWAYS AT SPEEDS OVER 40MPH AND ON HIGHWAYS COUNTRY ROADS AND ALWAYS ON A RETURN TRIP AFTER THE CAR HAD BEEN TURNED OFF ONCE. AFTER THE FIRST INCIDENT TOOK IT TO TOYOTA DEALERSHIP THEY SAID IT WAS BAD FRONT BREAKS AND FRONT LEFT BEARING, REPLACED BOTH TOOK IT HOME TWO WEEKS LATER BREAKS WENT OUT AGAIN ON HIGHWAY WHILE TRYING TO STOP AT A LIGHT, BROUGHT IT BACK TO TOYOTA DEALERSHIP, BREAKS WERE STILL OUT. THEY SAID NOTHING WAS WRONG EXCEPT I HEATED UP MY FRONT BREAKS WHILE TRYING TO STOP, AND THAT THEY WERE NOW COOL AND I SHOULD NOT HAVE THE PROBLEM AGAIN. I ASKED THEM TO CHECK ALL THE OTHER COMPONENTS OF THE BREAKING SYSTEM THEY SAID THEY WERE FINE. AT NO TIME DID ANY LIGHT COME ON ON THE DASHBOARD. I PICKED IT UP FROM DEALERSHIP THERE WAS NO BREAKS ON THE TRUCK. SO I TOWED HOME. HAD BREAK BOOSTER AND CHECK VALVE REPLACED RE-FLUSHED BREAKS. PROBLEM ACCURED AGAIN, TOOK IT TO LOCAL MECHANIC WHO BELIEVES IT'S THE ABS MODULAR. HAVE BEEN TRYING TO REPLACE ABS MODULAR SINCE MAY OF 2020, TOYOTA SAYS THERE IS A BACKORDER OF ABS SYSTEMS CAN NOT GIVE AN ETA OF WHEN THEY WILL BE BACK IN STOCK.THE PROBLEM MIGHT BE UNKNOWN BUT THE MECHANIC IS PRETTY SURE IT IS THE ABS MODULAR.
NHTSA ODI #11363703
136,100 miles · Oct 1, 2020
StructureSuspensionVehicle Speed Control
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 09V388000 (VEHICLE SPEED CONTROL) AND 14V604000 (SUSPENSION). THE CONTACT CALLED AND TOOK THE VEHICLE TO THE ARLINGTON TOYOTA LOCATED AT 10939 ATLANTIC BLVD, JACKSONVILLE, FL 32225, AND AFTER TWO WEEKS, THE TECHNICIAN STATED TH…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 09V388000 (VEHICLE SPEED CONTROL) AND 14V604000 (SUSPENSION). THE CONTACT CALLED AND TOOK THE VEHICLE TO THE ARLINGTON TOYOTA LOCATED AT 10939 ATLANTIC BLVD, JACKSONVILLE, FL 32225, AND AFTER TWO WEEKS, THE TECHNICIAN STATED THAT THE FRAME WAS RUSTED AND NEEDED TO BE REPLACED PRIOR TO THE RECALL REPAIRS BEING PERFORMED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 136,100.
NHTSA ODI #11362256
Mileage unknown · Sep 21, 2020
EngineStructureVehicle Speed Control
BODY ROT DUE TO CORROSION OF MANUFACTURE DEFECT. TOYOTA SPRAYED THE BODY UNDER COST BUT AGAIN COMING OFF AND BODY ROT THROUGH OUT VEHICLE.
NHTSA ODI #11360140
122,000 miles · Sep 11, 2020
StructureSuspension
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT THE SUBFRAME WAS RUSTED AND THE VEHICLE WOULD NOT PASS STATE INSPECTION. THE VEHICLE WAS TAKEN TO GLOUCESTER TOYOTA LOCATED AT 6357 GEORGE WASHINGTON MEMORIAL HWY, GLOUCESTER, VA 23061, AND THE CONTACT WAS INFORMED BY THE TECHNICIAN THAT THE VEHICLE WAS SUBJECTED…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT THE SUBFRAME WAS RUSTED AND THE VEHICLE WOULD NOT PASS STATE INSPECTION. THE VEHICLE WAS TAKEN TO GLOUCESTER TOYOTA LOCATED AT 6357 GEORGE WASHINGTON MEMORIAL HWY, GLOUCESTER, VA 23061, AND THE CONTACT WAS INFORMED BY THE TECHNICIAN THAT THE VEHICLE WAS SUBJECTED TO NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS REPAIRED. THE TECHNICIAN ALSO INFORMED THE CONTACT ABOUT AN UNKNOWN FRAME RECALL THAT HAD EXPIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRAME WAS RUSTED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT, OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 126,000.*JB
NHTSA ODI #11354472
180,000 miles · Aug 28, 2020
Structure
I HAVE A BLACK-COLORED 2006 TOYOTA TACOMA PICKUP TRUCK. FOR MANY YEARS, I'VE WONDERED WHY THE PAINT ON THE HOOD CHIPPED OFF IN TINY CIRCLES, UNLIKE ANY OTHER MODEL VEHICLE THAT I HAVE EVER OWNED. RECENTLY, I WAS SHOCKED TO SEE HOW BADLY RUSTED A SECTION OF THE ROOF OF MY CAB WAS. I CHECKED ONLINE TO SEE IF OTHERS WERE HAVING …
Read full complaint
I HAVE A BLACK-COLORED 2006 TOYOTA TACOMA PICKUP TRUCK. FOR MANY YEARS, I'VE WONDERED WHY THE PAINT ON THE HOOD CHIPPED OFF IN TINY CIRCLES, UNLIKE ANY OTHER MODEL VEHICLE THAT I HAVE EVER OWNED. RECENTLY, I WAS SHOCKED TO SEE HOW BADLY RUSTED A SECTION OF THE ROOF OF MY CAB WAS. I CHECKED ONLINE TO SEE IF OTHERS WERE HAVING A SIMILAR ISSUE AND FOUND PEOPLE COMPLAINING OF THIS SEEMED TO OWN PICK-UPS THAT WERE ALSO PAINTED BLACK, AND WERE ALSO 2006 MODELS. THE RUST PATTERNS SEEMED SIMILAR IN EVERY PICTURE I VIEWED, A PORTION OF THE ROOF ABOVE THE DRIVERS SIDE, RUSTED THE LENGTH FROM NEAR THE FRONT WINDSHIELD AREA TO NEAR THE BACK OF THE CAB. IN MY OPINION, AND BASED ON THE PICTURES OF SIMILAR INSTANCES I'VE VIEWED ONLINE, THERE SEEMS TO POSSIBLY BE SOME COMPELLING EVIDENCE OF A DEFICIENCY IN THE PAINTING METHOD OR MATERIAL USED ON THIS COLOR/YEAR TRUCK. IS THERE A RECALL OR SERVICE BULLETIN IN THE WORKS? I BELIEVE TOYOTA NEEDS TO ACKNOWLEDGE THIS ISSUE AS SOMETHING DOES NOT SEEM QUITE RIGHT AND THAT THEY SHOULD ADDRESS THESE ANOMALIES IN AN EFFORT TO REACH A FAIR RESOLUTION? BTW, THE REAR BUMPER'S EXCEPTIONALLY RUSTED OUT TOO, AND THE PLASTIC HEADLIGHT COVERINGS ON THIS MODEL HAVE CLOUDED UP WORSE THAN I HAVE EVER SEEN ON ANY OTHER VEHICLE MAKE, AS MOST OTHER HEADLIGHTS THAT I AM FAMILIAR WITH ARE MADE OF GLASS. (SEE ATTACHED PICTURES)
NHTSA ODI #11351791
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Illustration