IllustrationVoss Toyota would not perform the recall of new leaf springs that has not been completed on my truck. The frame is rusty and they will not touch my truck. There should be an existing recall or customer satisfaction program on the frame of this truck that needs done as well.
2006 Toyota Tacoma
Owner reports · Recalls · Investigations
More warning signs than most Tacoma years
Owner complaints for the 2006 Toyota Tacoma are substantially higher than the model-year median of 228.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tacoma years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1150–25K
9025–50K
10450–75K
10375–100K
122100–150K
60150K+
594 reports with mileage · 188 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 242 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 154 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 147 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
66 crash reports7 fire reports23 injury reports
Suspension complaints
154 reportsI took my 2006 Toyota Tacoma ext cab 4x4 v6 to have diagnostic run on it . "EXACT PERFORMANCE " Johnson drive . KCK The differential was shot . However , that was not the final . They did not do full diagnostic . They informed me that my frame was rotted and rusted through and would not last till spring and was a safety hazard. …
Read full complaint
I took my 2006 Toyota Tacoma ext cab 4x4 v6 to have diagnostic run on it . "EXACT PERFORMANCE " Johnson drive . KCK The differential was shot . However , that was not the final . They did not do full diagnostic . They informed me that my frame was rotted and rusted through and would not last till spring and was a safety hazard. That was Dec. 2024 . The truck has been parked since . Ive had no transportation and can not run right out and buy another truck . I am also not willing to give up the truck either . I have put a lot of hard earned money into this truck believing it to last forever . The motor and train are sound . I do not want to junk the truck . Please , tell me what I can do . Yes . My vehicle is available for inspection upon request.
The frame of my 2006 Toyota Tacoma (VIN: [XXX] ) is severely corroded and compromised. I recently acquired the vehicle and discovered that it was part of a past Toyota recall/program for frame corrosion inspection and replacement. However, it appears the previous owner did not take the vehicle in for the service. The frame now s…
Read full complaint
The frame of my 2006 Toyota Tacoma (VIN: [XXX] ) is severely corroded and compromised. I recently acquired the vehicle and discovered that it was part of a past Toyota recall/program for frame corrosion inspection and replacement. However, it appears the previous owner did not take the vehicle in for the service. The frame now shows advanced rust and structural weakness, which puts my safety and the safety of others at risk. I am concerned that the recall program was not adequately communicated or tracked, and I am requesting that the NHTSA review this issue for potential reopening or expansion of coverage for affected vehicles like mine. The vehicle is available for inspection if needed. Thanks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The truck's frame has severely rusted. The frame has deteriorated. It is unsafe to drive as the frame is breaking in half. According to Toyota, this was a huge problem with the 2006 Tacoma. They will not fix the frame or offer any solution. My son can not safely drive this vehicle.
There are holes in the frame and the frame mounts. Sold with a clean title
This truck is for sale in Oregon with HOLES/RUST on the frame and the frame mount. It is being sold with a clean title which clearly with the frame damage it is considered a branded title. The car lot that is selling the truck will no disclose the frame issue when asked about the structure damage on the truck. BUYERS BEWARE!!!
The contact owns a 2006 Toyota Tacoma. The contact stated that after the vehicle was taken to a local dealer for unrelated repairs, the mechanic determined that the rear subframe needed to be replaced. The contact was made aware of NHTSA Campaign Number: 14V604000 (Suspension); however, the VIN was not included in the recall. Th…
Read full complaint
The contact owns a 2006 Toyota Tacoma. The contact stated that after the vehicle was taken to a local dealer for unrelated repairs, the mechanic determined that the rear subframe needed to be replaced. The contact was made aware of NHTSA Campaign Number: 14V604000 (Suspension); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The approximate failure mileage was 178,000. The VIN was not available.
I will try to give you as concise statement of my complaint as possible, however, I have copies I sent to the manufacturer and others that I'm willing to furnish you if requested. On 3/18/21, I wrote to Toyota's Executive VP , Chief Quality Officer, [XXX], stating my compliance with their notice of 7/9/15, requiring frame inspe…
Read full complaint
I will try to give you as concise statement of my complaint as possible, however, I have copies I sent to the manufacturer and others that I'm willing to furnish you if requested. On 3/18/21, I wrote to Toyota's Executive VP , Chief Quality Officer, [XXX], stating my compliance with their notice of 7/9/15, requiring frame inspection, significant perforation not found, therefore they applied CRC corrosion resistant compound to my frame. As NO critical problem was noted, I felt I was good until during a later inspection was performed and rated more attention. On 3/29/21 during my next oil change I noted on a notation on an unusual service bill, typewritten not the usual custom printed type, a notation that I have 2 holes, approx. 3.5" on my frame, use caution if driving". At this time I found there was an open class action suit against Toyota. Toyota advised me that since I had not responded to more than one notification I was not included in the suit. I replied that "I DID NOT RECEIVE ANY SUCH NOTATION". As they did not send receipt requested or certified, I neither could prove sent or not received. I asked for consideration based on that to which, was denied. I have written also to CT Attorney General, CT US Senator, [XXX], with only the Attorney General's office stating Toyota's response was negative. I realize this is a late request, I was not aware of his avenue. I have Certified copies of each request for help, which I am more than happy to copy and send to you if you will try to help me right Toyota's wrong. I'm an 89 year old male just trying to right a wrong I believe done to me. I DID NOT RECEIVE NOTIFICATION FROM TOYOTA! , If I had, I would not be so persistent. I send my letters CERTIFIED, they should have had to also, could have solved this problem earlier. Please help me, thank you. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). The contact has noted that they still have yet to receive any compensation or resolution to this issue.
The frame is rusted so bad. The dealer wouldn’t replace due to the vehicle being registered in Florida as it’s not one of the states affected. But my Toyota came from a Pennsylvania dealer first then shipped to Florida after years of being in Pennsylvania and not having an issue up there. Now I’m stuck with a truck I can’t sell …
Read full complaint
The frame is rusted so bad. The dealer wouldn’t replace due to the vehicle being registered in Florida as it’s not one of the states affected. But my Toyota came from a Pennsylvania dealer first then shipped to Florida after years of being in Pennsylvania and not having an issue up there. Now I’m stuck with a truck I can’t sell or fix. It’s not right. Where is the quality control on this.
The contact owns a 2006 Toyota Tacoma. The contact stated upon taking the vehicle to an independent mechanic for front brake repair, she was informed that the front side of the subframe and the passenger's side and the driver's side subframe were severely corroded. The dealer was notified of the failure and informed the contact …
Read full complaint
The contact owns a 2006 Toyota Tacoma. The contact stated upon taking the vehicle to an independent mechanic for front brake repair, she was informed that the front side of the subframe and the passenger's side and the driver's side subframe were severely corroded. The dealer was notified of the failure and informed the contact that she would need to pay for the repair because an unknown Extended Warranty related to the failure had expired. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but did not provide any assistance. The failure mileage was approximately 70,000.
Official recalls
1116V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V604000 · Suspension:rear:springs:leaf Spring Assembly:leaf
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
13V337000 · Seat Belts
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
12V092000 · Air Bags:frontal
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
06V096000 · Air Bags
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
06V061000 · Tires:bead
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.