IllustrationINVOLVED IN ACCIDENT GOING 45 MPH. AIRBAG DID NOT DEPLOY. *TR
2006 Toyota Tacoma
Owner reports · Recalls · Investigations
More warning signs than most Tacoma years
Owner complaints for the 2006 Toyota Tacoma are substantially higher than the model-year median of 228.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tacoma years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1150–25K
9025–50K
10450–75K
10375–100K
122100–150K
60150K+
594 reports with mileage · 188 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 242 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 154 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 147 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
66 crash reports7 fire reports23 injury reports
What owners actually said
782 reportsTHE VEHICLE FRAME AND INCLUDED TOW HITCH AND MISC AREAS OF THE UNDERCARRIAGE ARE EXTREMELY RUSTED TO THE POINT OF CRACKING AND FLAKING METAL. ALSO OF A LESS SERIOUS CONCERN, THE ALLOY RIMS ARE HEAVILY CORRODED, BOTH CONDITIONS WERE NOTICED WITHIN TWO YEARS OF OWNERSHIP. I AM THE ORIGINAL AND SOLE VEHICLE OWNER. I WILL BE MAILING…
Read full complaint
THE VEHICLE FRAME AND INCLUDED TOW HITCH AND MISC AREAS OF THE UNDERCARRIAGE ARE EXTREMELY RUSTED TO THE POINT OF CRACKING AND FLAKING METAL. ALSO OF A LESS SERIOUS CONCERN, THE ALLOY RIMS ARE HEAVILY CORRODED, BOTH CONDITIONS WERE NOTICED WITHIN TWO YEARS OF OWNERSHIP. I AM THE ORIGINAL AND SOLE VEHICLE OWNER. I WILL BE MAILING PICTURES ALONG WITH A HARD COPY OF THIS FORM TO THE ADDRESS BELOW. UPDATED 02/01/12*LJ UPDATED 04/18/12
THIS HAS BEEN GOING ON FOR FEW YEARS. THIS MONTH MY A/C STARTED WORKING INTERMITTENTLY AGAIN. I HAVE REPLACED THE RESISTOR BEFORE THINKING IT WAS BAD..THAT'S WHEN I FIRST NOTICED THE HOT SPOTS. THIS TIME I INVESTIGATED MORE. NOW ALL 4 CONDUCTORS ARE SHOWING SIGNS OF A HOTSPOTS AND THE PLUG ALSO IS SHOWING SIGNS OF OVERHEATIN…
Read full complaint
THIS HAS BEEN GOING ON FOR FEW YEARS. THIS MONTH MY A/C STARTED WORKING INTERMITTENTLY AGAIN. I HAVE REPLACED THE RESISTOR BEFORE THINKING IT WAS BAD..THAT'S WHEN I FIRST NOTICED THE HOT SPOTS. THIS TIME I INVESTIGATED MORE. NOW ALL 4 CONDUCTORS ARE SHOWING SIGNS OF A HOTSPOTS AND THE PLUG ALSO IS SHOWING SIGNS OF OVERHEATING ON THE TWO MIDDLE CONNECTIONS. TOYOTA'S SERVICE MANAGE DIDN'T KNOW OF ANY SERVICE BULLETINS OR RECALLS ON THIS ISSUE. ALSO TOYOTA DOESN'T SELL A REPLACEMENT PLUG. THIS CAN, AND PROBABLY WILL START A FIRE. THE PARTS DEPARTMENT SAID I WILL FINE THAT MOST OF THE PLUGS WILL SHOW HEAT INDICATIONS AT A USED PARTS HOUSES. HAVING A FIRE INSIDE MY VEHICLE IS DEFINITELY A SAFETY ISSUE. FIRST RESISTOR CHANGED 11/10 @ 81500 MILES AND THERE WAS NOTHING WRONG WITH IT, JUST LOOSE CONNECTIONS. *TR
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THE AIR BAGS ILLUMINATE CONSTANTLY. IN CASE OF A CRASH THE AIR BAY WOULD NOT DEPLOY. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED IT NEEDED A SPIRAL CABLE AND CLOCK SPRING. THERE ARE NO RECALLS OR WARRANTY FOR THIS FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THE AIR BAGS ILLUMINATE CONSTANTLY. IN CASE OF A CRASH THE AIR BAY WOULD NOT DEPLOY. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED IT NEEDED A SPIRAL CABLE AND CLOCK SPRING. THERE ARE NO RECALLS OR WARRANTY FOR THIS FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 52,375
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE UNEXPECTEDLY INCREASED ACCELERATION UPON ENGAGING THE BRAKE PEDAL. THE VEHICLE FAILED TO REDUCE SPEED AND CRASHED INTO THE REAR END OF A VEHICLE. A POLICE REPORT WAS NOT FILED OF THE INCIDENT. THERE WAS NO PERSONAL INJURY. THE CONTACT'S FR…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE UNEXPECTEDLY INCREASED ACCELERATION UPON ENGAGING THE BRAKE PEDAL. THE VEHICLE FAILED TO REDUCE SPEED AND CRASHED INTO THE REAR END OF A VEHICLE. A POLICE REPORT WAS NOT FILED OF THE INCIDENT. THERE WAS NO PERSONAL INJURY. THE CONTACT'S FRONT BUMPER WAS DAMAGED AND WOULD NEED TO BE REPLACED. AN APPOINTMENT WAS SCHEDULED FOR THE NECESSARY REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 35,600. CONSMER STATED AS APPROACHING STOPLIGHT TAPED ON THE BRAKE TRUCK ACCELERATED AN HIT THE CAR STOPPED IN FRONT OF THEM. UPDATED 1/20/2012 *BF UPDATED 01/27/12
I WAS DRIVING MY 2006 TOYOTA TACOMA ON THE INTERSTATE AT APPROXIMATELY 65 MPH. I WAS USING CRUISE CONTROL AND I MERGED INTO THE PASSING LANE TO GET OVER FOR A HIGHWAY PATROL THAT HAD A TRUCK PULLED OVER. I ACCELERATED TO PASS ANOTHER TRUCK AND WHEN I WENT TO SLOW DOWN AFTER PASSING THE TRUCK SUDDENLY STARTED ACCELERATING BY IT…
Read full complaint
I WAS DRIVING MY 2006 TOYOTA TACOMA ON THE INTERSTATE AT APPROXIMATELY 65 MPH. I WAS USING CRUISE CONTROL AND I MERGED INTO THE PASSING LANE TO GET OVER FOR A HIGHWAY PATROL THAT HAD A TRUCK PULLED OVER. I ACCELERATED TO PASS ANOTHER TRUCK AND WHEN I WENT TO SLOW DOWN AFTER PASSING THE TRUCK SUDDENLY STARTED ACCELERATING BY ITSELF AND I COULD NOT GET THE BRAKES TO WORK. I THOUGHT SOMETHING WAS WRONG WITH THE CRUISE CONTROL SO I PUSHED THE BUTTON TO TURN IT OFF BUT IT CONTINUED TO ACCELERATE. I WAS SUDDENLY GOING OVER 90 MPH AND I COULD NOT STOP. I WAS PUSHING THE BRAKES AND NOTHING WAS HAPPENING, JUST FIGHTING AGAINST THE ACCELERATION. FINALLY I PUNCHED THE ACCELERATOR WITH MY FOOT AND IT FELT LIKE IT CAME UN-STUCK OR SOMETHING. I PREVIOUSLY TOOK THE TRUCK IN FOR A RECALL TO CUT OFF THE GAS PEDAL SO IT WOULD NOT GET STUCK ON THE FLOOR MAT, SO MY PEDAL HAS ALREADY BEEN SHORTENED. I HAVE OWNED THIS VEHICLE SINCE IT WAS NEW IN 2006 AND HAVE NEVER HAD ANYTHING LIKE THIS HAPPEN. IT WAS AS IF THERE WAS A COMPUTER GLITCH OR SOMETHING AND IT WAS JUST DRIVING ITSELF. *TR
AT AROUND 48,000 MILES, AIRBAG LIGHT CAME ON. TOOK IT TO TOYOTA DEALER AND WAS DIAGNOSED AT BROKEN SPIRAL CABLE. TOTAL COST TO FIX WAS 460 DOLLARS WITH LABOR. SEEMS TO BE A COMMON PROBLEM WITH 06 TACOMA. *KB
IN 09 NOTICED MY 3YEAR OLD TRUCKS FRAME WAS RUSTING ON THE FRAME. RUST WAS TO THE POINT THAT FRAME WAS SWELLING AND FLAKES OF METAL WERE FALLING OFF TO THE TOUCH. TOOK TRUCK TO DEALER WHERE IT WAS INSPECTED. THEY SAID THERE WAS NOTHING THEY COULD DO AND RECOMMENDED SANDING RUSTPROOFING AND PAINT. DESPITE TAKING ACTION AGAIN…
Read full complaint
IN 09 NOTICED MY 3YEAR OLD TRUCKS FRAME WAS RUSTING ON THE FRAME. RUST WAS TO THE POINT THAT FRAME WAS SWELLING AND FLAKES OF METAL WERE FALLING OFF TO THE TOUCH. TOOK TRUCK TO DEALER WHERE IT WAS INSPECTED. THEY SAID THERE WAS NOTHING THEY COULD DO AND RECOMMENDED SANDING RUSTPROOFING AND PAINT. DESPITE TAKING ACTION AGAINST RUST FRAME HAS CONTINUED TO CORRODE IN OTHER LOCATIONS SUCH AS WELDS WHERE SHOCKS ARE CONNECTED TO FRAME. CONCERNED FRAME WILL EVENTUALLY FAIL. *TR
I RECENTLY HAD AN ISSUE WITH THE ENGINE FAN HITTING THE SHROUD ON MY 2006 TACOMA. I TOOK MY TACOMA INTO THE LOCAL TOYOTA DEALERSHIP FOR DIAGNOSTICS. THEY INFORMED ME THAT THE FRAME WAS CRACKED AROUND THE WELD WHERE THE DRIVERS' SIDE MOTOR MOUNT BRACKET WAS WELDED TO THE FRAME. THE BRACKET HAS STARTED SINKING INTO THE FRAME WHICH…
Read full complaint
I RECENTLY HAD AN ISSUE WITH THE ENGINE FAN HITTING THE SHROUD ON MY 2006 TACOMA. I TOOK MY TACOMA INTO THE LOCAL TOYOTA DEALERSHIP FOR DIAGNOSTICS. THEY INFORMED ME THAT THE FRAME WAS CRACKED AROUND THE WELD WHERE THE DRIVERS' SIDE MOTOR MOUNT BRACKET WAS WELDED TO THE FRAME. THE BRACKET HAS STARTED SINKING INTO THE FRAME WHICH COULD ULTIMATELY CAUSE SERIOUS PROBLEMS TO CONSUMERS LEADING TO VEHICLE ACCIDENTS ETC. I HAVE BEEN DOING RESEARCH AND HAVE HEARD OF THIS SAME ISSUE HAPPENING WITH 2005 & 2006 TACOMAS FROM NUMEROUS OTHER TACOMA OWNERS. THE WELDS AROUND THE MOTOR MOUNT BRACKETS ARE WEAK. THESE SHOULD BE ONE OF THE STRONGEST WELDS ON THE TRUCK. TOYOTA ADVERTISES THEIR TRUCKS FOR OFF ROAD USE YET THEY BARELY HOLD UP TO NORMAL HIGHWAY DRIVING. I HOPE TOYOTA RESOLVES THIS MATTER ACCORDINGLY. *TR
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED THAT THE TIRE PRESSURE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE A FAILURE. THE CONTACT INSPECTED THE VEHICLE AND NOTIC…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED THAT THE TIRE PRESSURE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE A FAILURE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT DRIVER SIDE AND THE FRONT AND REAR PASSENGER SIDE RIMS WERE CORRODED. THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 06V061000 (TIRES:BEAD) AND TAKEN TO THE DEALER FOR INSPECTION BUT THE TIRES WERE NOT REPLACED UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 58,000. UPDATED 01/03/12*LJ UPADTED 01/05/12
Official recalls
1116V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V604000 · Suspension:rear:springs:leaf Spring Assembly:leaf
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
13V337000 · Seat Belts
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
12V092000 · Air Bags:frontal
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
06V096000 · Air Bags
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
06V061000 · Tires:bead
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.