NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
782 reports128,000 miles · Mar 21, 2016
Structure
TOYOTA TACOMA LIMITED SERVICE CAMPAIGN. I DROPPED MY TRUCK OFF IN NOVEMBER 2015 FOR A FRAME INSPECTION, I WAS THEN TOLD I COULD NOT DRIVE MY TRUCK OFF OF THE LOT AND HAD TO HAVE A LOANER VEHICLE. I WAS IN A LOANER VEHICLE WITHOUT MY TRUCK FOR 4 MONTHS UNTIL THE BEGINNING OF MARCH 2016. THE DAY I GOT MY TRUCK BACK, THE CHECK E…
Read full complaint
TOYOTA TACOMA LIMITED SERVICE CAMPAIGN. I DROPPED MY TRUCK OFF IN NOVEMBER 2015 FOR A FRAME INSPECTION, I WAS THEN TOLD I COULD NOT DRIVE MY TRUCK OFF OF THE LOT AND HAD TO HAVE A LOANER VEHICLE. I WAS IN A LOANER VEHICLE WITHOUT MY TRUCK FOR 4 MONTHS UNTIL THE BEGINNING OF MARCH 2016. THE DAY I GOT MY TRUCK BACK, THE CHECK ENGINE LIGHT CAME ON, THE CODES WERE P0420 AND P0430 WHICH INDICATE A CATALYTIC CONVERTER ISSUE. THE CHECK ENGINE LIGHT WAS NOT ON WHEN I TOOK THE TRUCK IN, OR EVER IN THE 2 YEARS I OWNED IT, BUT THE DEALERSHIP IS REFUSING TO DO ANYTHING BUT SAY IT NEEDS NEW CONVERTS THAT COST OVER $3000. MY TRUCK NOW HAS A VIBRATION FROM 50-55MPH WHICH WAS NOT PRESENT BEFORE AS WELL. I BELIEVE THESE ISSUES ARE A DIRECT RESULT OF THE FRAME BEING REPLACE, OR THE FACT THE MY TRUCK SAT STATIONARY FOR 4 MONTHS WHILE WAITING FOR A FRAME, NEITHER OF WHICH WERE MY FAULT.
NHTSA ODI #10850705
130,000 miles · Mar 17, 2016
Structure
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT WAS NOTIFIED OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE DEALER DIAGNOSED THAT THE UNDERCARRIAGE WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #10850266
Mileage unknown · Mar 17, 2016
Unknown Or Other
MY TACOMA WAS RECALLED FOR RUST ON THE FRAME. A NEW FRAME WAS ORDERED BUT I WAS INFORMED THAT I WOULD HAVE TO PAY FOR ANY RUSTED PARTS THAT NEEDED TO BE REPLACED WHEN THE FRAME WAS INSTALLED. I DIDN'T THINK YOU PAID FOR SAFETY RECALL WORK. I CALLED TOYOTA AND ASKED FOR A GUIDELINE AS TO WHAT COSTS WOULD BE MINE AND I HOPED A LIT…
Read full complaint
MY TACOMA WAS RECALLED FOR RUST ON THE FRAME. A NEW FRAME WAS ORDERED BUT I WAS INFORMED THAT I WOULD HAVE TO PAY FOR ANY RUSTED PARTS THAT NEEDED TO BE REPLACED WHEN THE FRAME WAS INSTALLED. I DIDN'T THINK YOU PAID FOR SAFETY RECALL WORK. I CALLED TOYOTA AND ASKED FOR A GUIDELINE AS TO WHAT COSTS WOULD BE MINE AND I HOPED A LITTLE SUPPORT IN DEALING WITH THE DEALER. I DON'T THINK TOYOTA TRUSTS THE DEALER. THEY WERE NO HELP. THIS SAFETY REPAIR WOULD COST ME THOUSANDS WITH THERE BEING NO LIMITS AS TO WHAT THE TOTAL WOULD BE. IF YOU REPLACE A FRAME ON A 10 YEAR OLD TRUCK YOU CAN EXPECT SOME RUSTED BOLTS AND FITTINGS. I DON'T THINK YOU SHOULD BE CHARGED FOR A SAFETY RECALL, BUT THE COST WOULD BE OPEN ENDED. THERE ARE NO LIMITS OR CRITERIA AS TO WHAT WOULD COVERED AND WHAT IS NOT. TOYOTA DOES NOT SEEM TO REALLY WANT TO CORRECT THIS DEFECT. THE LETTER FROM TOYOTA STATED THAT THE DEALER WILL PROVIDE AN APPROPRIATE REMEDY AT NO CHARGE TO ME. WHAT DO I DO? THERE DOESN'T SEEM TO BE ANY HELP COMING.
NHTSA ODI #10850251
Mileage unknown · Mar 17, 2016
Unknown Or Other
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED A RECALL NOTICE, BUT THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO DO THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE NHTSA CAMPAIGN NUMBER AND COMPONENT WERE UN…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED A RECALL NOTICE, BUT THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO DO THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE NHTSA CAMPAIGN NUMBER AND COMPONENT WERE UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 05/06/16*LJ
NHTSA ODI #10850238
145,000 miles · Mar 9, 2016
Power TrainStructureSuspension
I TOOK MY TRUCK TO MALLOY TOYOTA FOR FRAME INSPECTION REGARDING THE LIMITED SERVICE CAMPAIGN EOD- FRAME RUST RECALL. DEALER INFORMED ME THERE WAS RUST, BUT NO PERFORATIONS. THEY RECOMMENDED COATING THE FRAME WITH COMPOUNDS. I FEEL THAT MY TRUCK MAY NOT HAVE PERFORATIONS, BUT IT IS JUST A MATTER OF TIME BEFORE THE FRAME BECO…
Read full complaint
I TOOK MY TRUCK TO MALLOY TOYOTA FOR FRAME INSPECTION REGARDING THE LIMITED SERVICE CAMPAIGN EOD- FRAME RUST RECALL. DEALER INFORMED ME THERE WAS RUST, BUT NO PERFORATIONS. THEY RECOMMENDED COATING THE FRAME WITH COMPOUNDS. I FEEL THAT MY TRUCK MAY NOT HAVE PERFORATIONS, BUT IT IS JUST A MATTER OF TIME BEFORE THE FRAME BECOMES PERFORATED, RESULTING IN A DANGEROUS / UNSAFE VEHICLE. PUTTING THE COMPUNDS ON THE FRAME IS A QUICK BAND-AID AND DOES NOT FIX THE PROBLEM. THIS FRAME WILL BECOME UNSAFE, IT IS JUST A MATTER OF TIME. THIS WILL NOT ONLY POTENTIALLY JEOPARDIZE THE SAFETY OF MY FAMILY / OCCUPANTS IN THE VEHICLE, BUT ALSO THE OTHERS THAT SHARE THE ROAD WITH MY TRUCK.
NHTSA ODI #10845735
13,000 miles · Mar 8, 2016
Unknown Or Other
EARLY IN 2014 I RECEIVED A NOTICE FROM TOYOTA ABOUT A CONCERN WITH THE FRAME RUSTING OUT TO THE POINT THAT THE VEHICLE WOULD BECOME UNSAFE TO DRIVE. IN SEPTEMBER OF 2014 I HAD THE FRAME INSPECTED BY PRIME TOYOTA IN SACO, MAINE, WHERE I HAD PURCHASED THE VEHICLE NEW IN OCTOBER OF 2006. THE FRAME WAS INSPECTED AND FOUND TO BE FREE…
Read full complaint
EARLY IN 2014 I RECEIVED A NOTICE FROM TOYOTA ABOUT A CONCERN WITH THE FRAME RUSTING OUT TO THE POINT THAT THE VEHICLE WOULD BECOME UNSAFE TO DRIVE. IN SEPTEMBER OF 2014 I HAD THE FRAME INSPECTED BY PRIME TOYOTA IN SACO, MAINE, WHERE I HAD PURCHASED THE VEHICLE NEW IN OCTOBER OF 2006. THE FRAME WAS INSPECTED AND FOUND TO BE FREE OF CONCERNS REGARDING THE FRAME RUST ISSUE. I WAS TOLD THAT IF THE FRAME DID NOT SHOW SIGNS OF RUST IT WOULD BE RESPRAYED WITH RUST PROOFING MATERIAL. THE RESPRAYING WAS COMPLETED IN SEPTEMBER OF 2014. IN OCTOBER OF 2015 I WAS NOTICING A RATTLE UNDER BY TRUCK AND CRAWLED UNDER TO SEE WHAT WAS MAKING THE RATTLE. I FOUND A LOOSE HEAT SHIELD AROUND THE MUFFLER AND AT THAT TIME NOTICED THAT THE RUST PROOFING MATERIAL THAT HAD BEEN APPLIED WAS ALMOST ALL GONE. I BROUGHT IT BACK TO THE DEALER FOR AN OIL CHANGE AND ASKED THEM TO TAKE A LOOK AT THE FRAME. I WAS THEN INFORMED THAT THE FRAME HAD A PERFORATION. I CALLED TOYOTA CUSTOMER SERVICE TOYOTA 1-800-331-4331 WITH CASE #1601273298 AND SPOKE TO CASE MGR NICOLE. I WAS INFORMED THAT BECAUSE THEY HAD RESPRAYED THE FRAME THEY WOULD NOT DO ANYTHING ABOUT THE FRAME RUST. MY POSITION IS THAT EITHER THE INSPECTION WAS NOT DONE CORRECTLY AND OR THE RUST PROOFING WAS IMPROPERLY APPLIED. HENCE THE RUST PROOFING FALLING OFF AND A RUSTY FRAME. I HAD CALLED A SECOND TIME WITH THE SAME RESULT. I WAS NOT INFORMED AT THE TIME THAT IF THEY RESPRAYED THE FRAME I WOULD FORFEIT ALL FURTHER CLAIMS FOR THE RUSTY FRAME. THE ISSUE OF 2005 - 2009 TOYOTA TACOMA FRAME RUST IS WIDELY KNOWN AND DOCUMENTED. ATTACHED ARE THE SERVICE RECORDS FROM 2014 THAT THE INSPECTION WAS DONE AND THE RUST PROOFING APPLIED. NOWHERE IN THERE DOES IT SAY THAT THERE IS NO GUARANTEE FOR THE RUST PROOFING.
NHTSA ODI #10845627
Mileage unknown · Mar 8, 2016
Unknown Or Other
DEALER FOUND HEAVY RUST. ORDERED NEW FRAME TO BE COVERED UNDER WARRANTY. CORPORATE DENIED RESPONSIBILITY
NHTSA ODI #10845534
Mileage unknown · Mar 1, 2016
Suspension
REAR LEAF SPRING FRACTURED OR BROKEN. THIS WAS CONFIRMED BY RIVERTOWN TOYOTA. RE: LEAF SPRING RECALL DATED JULY 2015 | BROKEN SPRING MAKES AUDIBLE CLUNK OR BANG. FRACTURED SPRINGS MAY HIT FUEL TANK REPEATEDLY AND CAUSE EXPLOSION OR FIRE. TOYOTA REFUSES TO FIX .....UNTIL...THEY CAN FIND A REMEDY TO STOP IT FROM REOCCURING.
NHTSA ODI #10839128
Mileage unknown · Feb 26, 2016
Suspension
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10838556
21,000 miles · Feb 15, 2016
Structure
FRAME RUST - 2006 TOYOTA TACOMA - 21K MILES - SIGNIFICANT RUST OF FRAME. SPRAY-ON RUST INHIBITOR FIX COMPLETED APPROX. TWO YEARS AGO BUT RUST REMAINS AND IS INCREASING.
NHTSA ODI #10836237
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Illustration