Illustration2006 TOYOTA FRAME RUST ON TACOMA
2006 Toyota Tacoma
Owner reports · Recalls · Investigations
More warning signs than most Tacoma years
Owner complaints for the 2006 Toyota Tacoma are substantially higher than the model-year median of 228.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tacoma years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1150–25K
9025–50K
10450–75K
10375–100K
122100–150K
60150K+
594 reports with mileage · 188 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 242 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 154 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 147 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
66 crash reports7 fire reports23 injury reports
What owners actually said
782 reportsWENT TO GET MY CAR INSPECTED AND IT FAILED FOR A RUSTED FRAME. DID SOME RESEARCH AND FOUND OUT IT'S UNDER RECALL.
I WENT TO MY MECHANIC FOR A SMALL REPAIR RECENTLY AND HE INFORMED ME (AND SHOWED ME) EXTENSIVE RUST ON THE FRAME AND A MAJOR SPLIT IN THE FRAME FROM THE EXTENSIVE RUST. HE HAS TOLD ME THAT PERFORATIONS ARE IMMINENT IN THE FRAME AND THAT THE FRAME WILL NEED TO BE REPLACED. HE ALSO FOUND RUST DAMAGE TO MY BRAKES, ROTORS, PAINT (CH…
Read full complaint
I WENT TO MY MECHANIC FOR A SMALL REPAIR RECENTLY AND HE INFORMED ME (AND SHOWED ME) EXTENSIVE RUST ON THE FRAME AND A MAJOR SPLIT IN THE FRAME FROM THE EXTENSIVE RUST. HE HAS TOLD ME THAT PERFORATIONS ARE IMMINENT IN THE FRAME AND THAT THE FRAME WILL NEED TO BE REPLACED. HE ALSO FOUND RUST DAMAGE TO MY BRAKES, ROTORS, PAINT (CHIPPING WITH RUST), WHEEL CAPS, AND TAILGATE. HE INFORMED ME THAT I CANNOT SAFELY DRIVE THIS TRUCK ON DIRT ROADS OR HAUL ANYTHING. 75% OF THE ROADS WHERE I RESIDE ARE DIRT ROADS. COST OF FRAME REPLACEMENT WOULD EXCEED WHAT I PAID FOR THE TRUCK; I HAVE OWNED THIS TRUCK FOR 6 MONTHS. I HAVE CONTACTED TOYOTA AND A LOCAL TOYOTA DEALERSHIP FOR ASSISTANCE, BUT HAVE YET TO HEAR BACK FROM EITHER. I UNDERSTAND THERE WAS A CLASS ACTION LAWSUIT THAT WAS SETTLED IN 2016 FOR THIS VERY ISSUE. TOYOTA NEEDS TO REPLACE THE FRAME OF MY TRUCK AND REPAIR OR REPLACE ALL OF THE AFFECTED PARTS OF THE TRUCK DUE TO THE EXTENSIVE RUST DAMAGE. I USE MY TRUCK TO TRAVEL LONG DISTANCES IN ORDER TO TAKE CARE OF MY MOM WHO LIVES 600+ MILES FROM ME; MY MECHANIC HAS INFORMED ME THAT IT IS NOT SAFE TO DRIVE THIS TRUCK FOR LONG DISTANCES. THIS HAS A SUBSTANTIAL IMPACT ON MY DAILY LIFE AND MY ABILITY TO TAKE CARE OF MY MOM. I DO NOT BELIEVE I SHOULD HAVE TO BARE THE RESPONSIBILITY OR LIABILITY OF THE DAMAGE CAUSED BY DEFICIENT PARTS USED IN THE MANUFACTURING PROCESS. TOYOTA SHOULD BE MADE LIABLE FOR THESE DAMAGES. PLEASE ADVISE. I WILL BE CONTACTING MY LAWYER.
"TOYOTA RECALL" NHTSA RECALL: 14V604.
THE VEHICLE FRAME IS SO RUSTY EVERYWHERE INCLUDING VISIBLE CRACKS THAT I DO NOT KNOW IF IT IS SAFE TO DRIVE ANYMORE. I AM SURE IT WILL NOT BE SAFE TO TOW ANYTHING FOR SURE OR THE THING WILL BREAK IN HALF.
I PURCHASED A USED 2006 TOYOTA TACOMA SEVERAL YEARS AGO. MY MECHANIC RECENTLY NOTICED SEVERE RUST DAMAGE TO MY FRAME WHEN PERFORMING AN OIL CHANGE. THEY MENTIONED TO ME ABOUT A CAMPAIGN THAT TOYOTA WAS DOING WHERE THEY WERE REPLACING FRAMES OR COATING THEM. WHEN I INQUIRED ABOUT THIS I LEARNED THAT THE CAMPAIGN HAD EXPIRED ON 3/…
Read full complaint
I PURCHASED A USED 2006 TOYOTA TACOMA SEVERAL YEARS AGO. MY MECHANIC RECENTLY NOTICED SEVERE RUST DAMAGE TO MY FRAME WHEN PERFORMING AN OIL CHANGE. THEY MENTIONED TO ME ABOUT A CAMPAIGN THAT TOYOTA WAS DOING WHERE THEY WERE REPLACING FRAMES OR COATING THEM. WHEN I INQUIRED ABOUT THIS I LEARNED THAT THE CAMPAIGN HAD EXPIRED ON 3/31/16. I SPOKE WITH AN EXECUTIVE WITH TOYOTA SEVERAL TIMES ONLY TO BE TOLD THAT THEY WOULD NOT DO ANYTHING FURTHER SINCE IT IS AFTER THE EXPIRATION DATE. THEY SAID THEY MAILED OUT 3 NOTICES IN REGARDS TO THE CAMPAIGN IN WHICH I DID NOT RECEIVE A ONE. I OBVIOUSLY WOULD HAVE TAKEN CARE OF SUCH A SAFETY ISSUE HAD I KNOWN. I AM VERY SURPRISED THAT TOYOTA WOULD NOT EXTEND THIS CAMPAIGN OR THAT IT WOULD NOT BE DEEMED AS A FULL BLOWN RECALL WITH NO EXPIRATION! HOW CAN SUCH A SERIOUS SAFETY ISSUE HAVE AN EXPIRATION DATE! I NOW HAVE A VEHICLE THAT I AM NERVOUS TO BE DRIVING LET ALONE HAVE A MEMBER OF MY FAMILY DRIVE. THIS IS VERY UPSETTING ESPECIALLY SINCE I NEVER RECEIVED A NOTICE. *TR
AIR BAG LIGHT IS ILLUMINATED ON DASHBOARD THIS WILL CAUSE AIR BAG NOT TO FUNCTION IN AN ACCIDENT. CAN SOMETIMES HEAR LOOSE SPRING SOUND COMING FROM STEERING WHEEL WHEN MAKING TURNS.
MAJOR FRAME RUST ISSUE. FRAME IS RUSTED TO THE POINT OF PERFORATION. BACK ON 6/23/14 TOYOTA ADVISED SPRAYING THE UNDERCARRIAGE, WHICH WAS DONE AT A DEALERSHIP REPAIR ORDER #0840463. WENT BACK TO HAVE THE LEAF SPRINGS FIXED DUE TO RECALL AND TO HAVE THE FRAME INSPECTED. NOW THE DEALERSHIP SAYS THE FRAME RUST RECALL EXPIRED I…
Read full complaint
MAJOR FRAME RUST ISSUE. FRAME IS RUSTED TO THE POINT OF PERFORATION. BACK ON 6/23/14 TOYOTA ADVISED SPRAYING THE UNDERCARRIAGE, WHICH WAS DONE AT A DEALERSHIP REPAIR ORDER #0840463. WENT BACK TO HAVE THE LEAF SPRINGS FIXED DUE TO RECALL AND TO HAVE THE FRAME INSPECTED. NOW THE DEALERSHIP SAYS THE FRAME RUST RECALL EXPIRED IN MARCH OF 2016 AND IT IS OUT OF THEIR HANDS. NEED TO KNOW HOW TO GET TOYOTA TO FIX THE FRAME SINCE THE SPRAYING DID NOT RECTIFY THE PROBLEM AND IT CONTINUES TO GET WORSE.
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 30 TO 70 MPH, THE DRIVE TRAIN VIBRATED UNCONTROLLABLY, AND THE SEAT AND STEERING WHEEL ALSO VIBRATED. THE MANUFACTURER WAS NOTIFIED. THE DEALER REPLACED THE TIRES, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE APPROXIMATE FA…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 30 TO 70 MPH, THE DRIVE TRAIN VIBRATED UNCONTROLLABLY, AND THE SEAT AND STEERING WHEEL ALSO VIBRATED. THE MANUFACTURER WAS NOTIFIED. THE DEALER REPLACED THE TIRES, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
I WAS PULLING INTO MY DRIVEWAY WITH THE INTENTION OF PARKING IN THE GARAGE. I WAS SLOWLY WITH MY FOOT ON THE BRAKE, TURNING INTO THE DRIVEWAY WHEN THE VEHICLE SIMULTANEOUSLY STARTED TO SQUEAL (AS I WAS ON THE BRAKE) AND ACCELERATE. I KEPT PUSHING HARDER AND HARDER ON THE BRAKE, THE SQUEALING CONTINUED. I WAS ABLE TO PUT THE TRUC…
Read full complaint
I WAS PULLING INTO MY DRIVEWAY WITH THE INTENTION OF PARKING IN THE GARAGE. I WAS SLOWLY WITH MY FOOT ON THE BRAKE, TURNING INTO THE DRIVEWAY WHEN THE VEHICLE SIMULTANEOUSLY STARTED TO SQUEAL (AS I WAS ON THE BRAKE) AND ACCELERATE. I KEPT PUSHING HARDER AND HARDER ON THE BRAKE, THE SQUEALING CONTINUED. I WAS ABLE TO PUT THE TRUCK IN PARK AND SHUT THE IGNITION OFF PRIOR TO CRASHING INTO ANYTHING.
Official recalls
1116V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V604000 · Suspension:rear:springs:leaf Spring Assembly:leaf
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
13V337000 · Seat Belts
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
12V092000 · Air Bags:frontal
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
06V096000 · Air Bags
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
06V061000 · Tires:bead
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.