NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
154 reportsClear category filter121,000 miles · Jul 4, 2020
Power TrainService BrakesSuspension
EXCESSIVE CORROSION AND RUSTED THROUGH FRAME THAT IS UNABLE TO SUPPORT WEIGHT OF VEHICLE. HAD A BRAKE LINE BUST DUE TO BEING RUSTED OR CORRODED OUT. ALSO SUSPENSION SHOWS EXCESSIVE RUST AND CORROSION. COOLING LINES CORRODED. POWER STEERING LINES CORRODED. TRANSMISSION LINES CORRODED. ANY METAL LINE IS THAT'S ATTACHED TO THIS…
Read full complaint
EXCESSIVE CORROSION AND RUSTED THROUGH FRAME THAT IS UNABLE TO SUPPORT WEIGHT OF VEHICLE. HAD A BRAKE LINE BUST DUE TO BEING RUSTED OR CORRODED OUT. ALSO SUSPENSION SHOWS EXCESSIVE RUST AND CORROSION. COOLING LINES CORRODED. POWER STEERING LINES CORRODED. TRANSMISSION LINES CORRODED. ANY METAL LINE IS THAT'S ATTACHED TO THIS VEHICLE ARE CORRODED. AND ALL BRACKETS AND HARDWARE ATTACHED TO FRAME AND EVEN THE METAL PULLEYS ALL EXCESSIVELY CORRODED.
NHTSA ODI #11337398
199,000 miles · May 26, 2020
StructureSuspension
WHEN INSPECTING THE LEAF SPRING REPLACEMENT FROM A RECALL, FOUND THE FRAME CORRODED TO THE POINT THAT IT WILL FAIL. (SEE PHOTO). TOYOTA HAD A RECALL ON THESE FRAMES AND THIS TRUCK FELL UNDER THE GUIDELINES.WHEN I CONTACTED TOYOTA THEY SAID THIS WAS AN EXTENDED WARRANTY AND HAD EXPIRED.SAID THEY SENT NOTIFICATION WHICH I NEVER RE…
Read full complaint
WHEN INSPECTING THE LEAF SPRING REPLACEMENT FROM A RECALL, FOUND THE FRAME CORRODED TO THE POINT THAT IT WILL FAIL. (SEE PHOTO). TOYOTA HAD A RECALL ON THESE FRAMES AND THIS TRUCK FELL UNDER THE GUIDELINES.WHEN I CONTACTED TOYOTA THEY SAID THIS WAS AN EXTENDED WARRANTY AND HAD EXPIRED.SAID THEY SENT NOTIFICATION WHICH I NEVER RECEIVED. *TR
NHTSA ODI #11326005
156,000 miles · May 20, 2020
SteeringStructureSuspension
THIS VEHICLE IS COVERED IN THE TOYOTA RUSTY FRAME LAWSUIT. AS SUCH, IT HAS BEEN INSPECTED BY 2 DIFFERENT DEALERS AND DEEMED NOT TO NEED A FRAME REPLACEMENT BOTH TIMES. IT WAS TREATED WITH CRC. ITS LAST INSPECTION WAS IN NOVEMBER OF 2018. ON SUNDAY, MAY 17TH, 2020, THE FRAME BROKE AT THE FRONT CROSS-MEMBER CAUSING THE LEFT FR…
Read full complaint
THIS VEHICLE IS COVERED IN THE TOYOTA RUSTY FRAME LAWSUIT. AS SUCH, IT HAS BEEN INSPECTED BY 2 DIFFERENT DEALERS AND DEEMED NOT TO NEED A FRAME REPLACEMENT BOTH TIMES. IT WAS TREATED WITH CRC. ITS LAST INSPECTION WAS IN NOVEMBER OF 2018. ON SUNDAY, MAY 17TH, 2020, THE FRAME BROKE AT THE FRONT CROSS-MEMBER CAUSING THE LEFT FRONT LOWER CONTROL ARM TO SEPARATE AND STEERING THE VEHICLE/CONTROLLING THE VEHICLE BECAME NEAR IMPOSSIBLE. FORTUNATELY FOR ME, THIS HAPPENED IN A PARKING LOT BACKING OUT OF A PARKING SPACE AND TURNING LEFT (IN REVERSE AT LOW SPEED) AFTER A FULL 2 WEEKS OF DRIVING IN THE MOUNTAINS OF WEST VIRGINIA. I QUESTION ALL INSPECTIONS OF FRAMES BEING PERFORMED WITHIN THE TOYOTA DEALER NETWORK AND HOPE THAT NOBODY HAS THIS FAILURE WHILE THEY ARE DRIVING AT SPEED AS THE RESULTS WILL BE CATASTROPHIC. *TR
NHTSA ODI #11325342
Mileage unknown · Mar 24, 2020
Suspension
THE SUBJECT VEHICLES' REAR SUSPENSION SYSTEM CONTAINS LEAF SPRINGS THAT ARE CONSTRUCTED OF EITHER THREE OR FOUR LEAVES. THERE IS A POSSIBILITY THAT A LEAF COULD FRACTURE DUE TO STRESS AND CORROSION. IF THIS OCCURS AND THE VEHICLE CONTINUES TO BE OPERATED, THE BROKEN LEAF COULD MOVE OUT OF POSITION AND CONTACT SURROUNDING COMPONE…
Read full complaint
THE SUBJECT VEHICLES' REAR SUSPENSION SYSTEM CONTAINS LEAF SPRINGS THAT ARE CONSTRUCTED OF EITHER THREE OR FOUR LEAVES. THERE IS A POSSIBILITY THAT A LEAF COULD FRACTURE DUE TO STRESS AND CORROSION. IF THIS OCCURS AND THE VEHICLE CONTINUES TO BE OPERATED, THE BROKEN LEAF COULD MOVE OUT OF POSITION AND CONTACT SURROUNDING COMPONENTS, INCLUDING THE FUEL TANK. SAFETY RISK: IF THE BROKEN LEAF CONTACTS THE FUEL TANK REPEATEDLY, IT COULD PUNCTURE THE TANK AND CAUSE A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, THIS COULD RESULT IN A FIRE. REMEDY: TOYOTA WILL REPLACE THE LEAF SPRINGS WITH NEWLY DESIGNED ONES. IT HAS BEEN REPAIRED I NEED TO HAVE IT SHIPPED OFF ISLAND ASAP
NHTSA ODI #11319099
99,985 miles · Nov 4, 2019
StructureSuspension
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO SERVCO AUTO KAUAI (LOCATED AT 2477 ULU MAIKA ST, LIHUE, HI 96766, (877) 292-9755) FOR INSPECTION. THE CONTACT WAS INFORMED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) AND THE BODY FRAME WAS RUSTED THROUGH. THE VEHICLE WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO SERVCO AUTO KAUAI (LOCATED AT 2477 ULU MAIKA ST, LIHUE, HI 96766, (877) 292-9755) FOR INSPECTION. THE CONTACT WAS INFORMED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) AND THE BODY FRAME WAS RUSTED THROUGH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 99,985.
NHTSA ODI #11278159
Mileage unknown · May 6, 2019
Suspension
REAR LEAF SPRING, RECALL: 14V-604. ON JULY 10TH OF 2016 I MADE A CALL TO ELK GROVE TOYOTA IN REGARDS TO THE RECALL. THE SERVICE WRITER ASK ME IF MY TRUCK HAD A LEVEL KIT INSTALLED ? I TOLD HIM YES, 2'. HE TOLD ME IT VOIDED THE RECALL. I DID SONE RESEARCH AND FOUND MANY CUSTOMERS HAD THE SAME SITUATION, BUT OTHERS DID NOT. THE…
Read full complaint
REAR LEAF SPRING, RECALL: 14V-604. ON JULY 10TH OF 2016 I MADE A CALL TO ELK GROVE TOYOTA IN REGARDS TO THE RECALL. THE SERVICE WRITER ASK ME IF MY TRUCK HAD A LEVEL KIT INSTALLED ? I TOLD HIM YES, 2'. HE TOLD ME IT VOIDED THE RECALL. I DID SONE RESEARCH AND FOUND MANY CUSTOMERS HAD THE SAME SITUATION, BUT OTHERS DID NOT. THEIR DEALERSHIP REPLACED AND TOOK CARE OF THE RECALL EVEN WITH A LEVEL KIT INSTALLED. IN DIFFERENT PARTS OF THE STATES AND COUNTRY. I CALLED AGAIN ON 3/25/19 TO ELK GROVE TOYOTA AGAIN AND WAS TOLD THE SAME. MY RECALL IS VOID BECAUSE OF THE LEVEL KIT. THE DEALERSHIP IS IN ELK GROVE, CA. IF THEY WON'T PERFORM THE RECALL IS THERE A WAY I CAN HAVE ANOTHER SHOP PERFORM THE RECALL AND TOYOTA PAID THEM ? PLEASE ADVICE
NHTSA ODI #11205904
119,000 miles · Apr 8, 2019
SteeringSuspensionUnknown Or Other
RUSTED FRONT END PASSENGER SIDE COMPONENT BROKE OF THE FRAME DUE TO CORROSION. TOYOTA WARRANTY FOR REPAIR EXPIRED 31 JANUARY 2019 AND VEHICLE WAS TAKEN TO TOYOTA 2 MONTHS LATER AND TOYOTA WILL NOT HONOR REPAIR. VERY DISAPPOINTING ON TOYOTAS END. THE RUSTED FRAME TAKES LONGER THAN 2 MONTHS TO CORRODE. TOYOTA CARE NOT WILLING TO W…
Read full complaint
RUSTED FRONT END PASSENGER SIDE COMPONENT BROKE OF THE FRAME DUE TO CORROSION. TOYOTA WARRANTY FOR REPAIR EXPIRED 31 JANUARY 2019 AND VEHICLE WAS TAKEN TO TOYOTA 2 MONTHS LATER AND TOYOTA WILL NOT HONOR REPAIR. VERY DISAPPOINTING ON TOYOTAS END. THE RUSTED FRAME TAKES LONGER THAN 2 MONTHS TO CORRODE. TOYOTA CARE NOT WILLING TO WORK WITH ME AND FIX THERE FAULTY AND VERY UNSAFE PRODUCT!
NHTSA ODI #11194651
Mileage unknown · Jan 11, 2019
StructureSuspension
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING AT ANY SPEED, THE SUSPENSION MADE AN ABNORMAL NOISE. PRIOR TO THE NOISE, THE VEHICLE WAS REPAIRED PER AN UNKNOWN MANUFACTURER RECALL PERTAINING TO THE FRAME. THE CONTACT WAS UNCERTAIN IF THE RECALL REPAIR CAUSED THE SUSPENSION NOISE. THE VEHICLE WAS TAKEN TO MORE THAN TWO …
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING AT ANY SPEED, THE SUSPENSION MADE AN ABNORMAL NOISE. PRIOR TO THE NOISE, THE VEHICLE WAS REPAIRED PER AN UNKNOWN MANUFACTURER RECALL PERTAINING TO THE FRAME. THE CONTACT WAS UNCERTAIN IF THE RECALL REPAIR CAUSED THE SUSPENSION NOISE. THE VEHICLE WAS TAKEN TO MORE THAN TWO DEALERS, INCLUDING TANSKY SAWMILL TOYOTA (6300 SAWMILL RD, DUBLIN, OH 43017, (614) 766-4800) AND BUCKEYE TOYOTA (1903 RIVERWAY DR, LANCASTER, OH 43130, (740) 654-3943) TO BE DIAGNOSED, BUT THE FAILURE COULD NOT BE DUPLICATED. THE CONTACT WAS UNCERTAIN IF THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #11166460
Mileage unknown · Nov 14, 2018
Suspension
BUENA PARK TOYOTA REFUSES TO FIX THE RECALL ON MY TRUCK. THEY SAY IT BECAUSE I DON'T HAVE THE ORIGINAL SHOCKS. MY TRUCK WAS PURCHASED FROM BUENA PARK TOYOTA AS A CERTIFIED USED VEHICLE AND I HAVEN'T MADE ANY CHANGES TO THE TRUCK. THE WAY IT SITS NOW IS THE WAY I BOUGHT IT FROM THE DEALERSHIP AS A CERTIFIED VEHICLE. THE REAR LEAF…
Read full complaint
BUENA PARK TOYOTA REFUSES TO FIX THE RECALL ON MY TRUCK. THEY SAY IT BECAUSE I DON'T HAVE THE ORIGINAL SHOCKS. MY TRUCK WAS PURCHASED FROM BUENA PARK TOYOTA AS A CERTIFIED USED VEHICLE AND I HAVEN'T MADE ANY CHANGES TO THE TRUCK. THE WAY IT SITS NOW IS THE WAY I BOUGHT IT FROM THE DEALERSHIP AS A CERTIFIED VEHICLE. THE REAR LEAF SPRING HAS HIT THE FUEL TAKE A FEW TIMES AND BOTTOMS OUT ON EVERY LITTLE BUMP (WHICH IS WHAT THE RECALL IS FOR) AND EVERYTHING ON THE REAR SUSPENSION IS EXACTLY THE WAY IT CAME FROM TOYOTA. THEY TOLD ME IF I WANTED TO HAVE THE ITEMS REPLACED I WOULD HAVE TO PUT ALL THE OEM STUFF BACK ON THE VEHICLE BUT THAT'S THE WAY THIS DEALER SOLD IT TO ME.
NHTSA ODI #11151526
Mileage unknown · Sep 21, 2018
Suspension
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO SUPREME TOYOTA OF HAMMOND (LOCATED AT 1415 S MORRISON BLVD, HAMMOND, LA 70403…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO SUPREME TOYOTA OF HAMMOND (LOCATED AT 1415 S MORRISON BLVD, HAMMOND, LA 70403, (877) 840-7756), BUT WAS NOT REPAIRED BECAUSE THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11130603
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Illustration