NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
154 reportsClear category filter116,000 miles · Nov 21, 2011
Engine And Engine CoolingSuspension
I RECENTLY HAD AN ISSUE WITH THE ENGINE FAN HITTING THE SHROUD ON MY 2006 TACOMA. I TOOK MY TACOMA INTO THE LOCAL TOYOTA DEALERSHIP FOR DIAGNOSTICS. THEY INFORMED ME THAT THE FRAME WAS CRACKED AROUND THE WELD WHERE THE DRIVERS' SIDE MOTOR MOUNT BRACKET WAS WELDED TO THE FRAME. THE BRACKET HAS STARTED SINKING INTO THE FRAME WHICH…
Read full complaint
I RECENTLY HAD AN ISSUE WITH THE ENGINE FAN HITTING THE SHROUD ON MY 2006 TACOMA. I TOOK MY TACOMA INTO THE LOCAL TOYOTA DEALERSHIP FOR DIAGNOSTICS. THEY INFORMED ME THAT THE FRAME WAS CRACKED AROUND THE WELD WHERE THE DRIVERS' SIDE MOTOR MOUNT BRACKET WAS WELDED TO THE FRAME. THE BRACKET HAS STARTED SINKING INTO THE FRAME WHICH COULD ULTIMATELY CAUSE SERIOUS PROBLEMS TO CONSUMERS LEADING TO VEHICLE ACCIDENTS ETC. I HAVE BEEN DOING RESEARCH AND HAVE HEARD OF THIS SAME ISSUE HAPPENING WITH 2005 & 2006 TACOMAS FROM NUMEROUS OTHER TACOMA OWNERS. THE WELDS AROUND THE MOTOR MOUNT BRACKETS ARE WEAK. THESE SHOULD BE ONE OF THE STRONGEST WELDS ON THE TRUCK. TOYOTA ADVERTISES THEIR TRUCKS FOR OFF ROAD USE YET THEY BARELY HOLD UP TO NORMAL HIGHWAY DRIVING. I HOPE TOYOTA RESOLVES THIS MATTER ACCORDINGLY. *TR
NHTSA ODI #10436622
86,000 miles · Nov 4, 2011
Power TrainSteeringSuspension
NOTICED RUST ON THE FRAME OF THE VEHICLE WITH HEAVIER AMOUNTS NEAR/ON WELD POINTS, & BOLT POINTS. RUST IS ACCUMULATING ON THE STEERING TIE RODS. HEAVY RUST ON REAR DIFFERENTIAL AND VARIOUS STEERING COMPONENT PARTS. I CONSIDER THE AMOUNT OF RUST ON THE FRAME AND THE ABOVE MENTIONED COMPONENTS A MANUFACTURER'S DEFECT. IF A…
Read full complaint
NOTICED RUST ON THE FRAME OF THE VEHICLE WITH HEAVIER AMOUNTS NEAR/ON WELD POINTS, & BOLT POINTS. RUST IS ACCUMULATING ON THE STEERING TIE RODS. HEAVY RUST ON REAR DIFFERENTIAL AND VARIOUS STEERING COMPONENT PARTS. I CONSIDER THE AMOUNT OF RUST ON THE FRAME AND THE ABOVE MENTIONED COMPONENTS A MANUFACTURER'S DEFECT. IF ANY OF THE COMPONENTS FAIL WHILE I AM DRIVING I COULD CRASH AND INJURE, OR KILL ANOTHER MOTORIST/MYSELF. I SPOKE WITH TOYOTA OF SD SERVICE REP WHO TOLD ME I SHOULD CONTACT TOYOTA. I HAVE A 100,000/10YR EXTENDED SERVICE PLAN AND WANT THIS RESOLVED PRIOR TO THE TIME FRAME RUNNING OUT. *TR
NHTSA ODI #10434279
82,050 miles · Mar 3, 2011
Suspension
1) NO KNOWN EVENTS OR DRIVING BEHAVIOR LED TO THE FAILURE. TRUCK IS DRIVEN ON STREETS ONLY, AND RARELY USED TO CARRY HEAVY LOADS 2) SHOCK ABSORBER SEAT COMPONENT SPLIT AND THE CONSEQUENCE WAS THAT THE LOAD-BEARING SPRINGS DROPPED FROM TYPICAL PLATFORM. WHEEL AND TRANSMISSION WERE OUT OF ALIGNMENT. RISK OF TRAVELING AT HIGHWA…
Read full complaint
1) NO KNOWN EVENTS OR DRIVING BEHAVIOR LED TO THE FAILURE. TRUCK IS DRIVEN ON STREETS ONLY, AND RARELY USED TO CARRY HEAVY LOADS 2) SHOCK ABSORBER SEAT COMPONENT SPLIT AND THE CONSEQUENCE WAS THAT THE LOAD-BEARING SPRINGS DROPPED FROM TYPICAL PLATFORM. WHEEL AND TRANSMISSION WERE OUT OF ALIGNMENT. RISK OF TRAVELING AT HIGHWAY SPEEDS WAS MOTOR MELTDOWN AND/OR LOSS OF CONTROL OF VEHICLE. 3) PARTS WERE REPLACED. *TR
NHTSA ODI #10386303
93,000 miles · Aug 26, 2010
Suspension
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT WHEN DRIVING WITH A HEAVY LOAD, THE REAR SUSPENSION WOULD DROP. THE DEALER ADVISED THAT THE REAR SUSPENSION SPRINGS WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 93,000 AND THE CURRENT MILEAGE WAS 97,000.
NHTSA ODI #10352168
57,000 miles · Jan 27, 2009
Suspension
WHEN TRUCK HAS 4 TO 5 PASSENGERS, THE REAR END BOTTOMS OUT WITH THE SLIGHTEST DIP IN THE ROADWAY. *TR
NHTSA ODI #10256501
47,000 miles · Dec 8, 2008
Suspension
TACOMA 2006 REAR END SUSPENSION BOTTOM UP ON ONE SIDE ONLY, THE DEALER DOESN'T WANT TO PASS THE PROBLEM UNDER WARRANTY, I HAVE 75,000KM THE WARRANTY EXPIRE AT 60,000. ANY LITTLE IMPERFECTION ON THE ROAD WILL MAKE THE SUSPENSION BOTTOM UP. DANGEROUS TO DRIVE. *TR
NHTSA ODI #10251132
32,000 miles · Sep 11, 2008
Service Brakes, HydraulicSuspension
I HAVE A 2006 TOYOTA TACOMA V6 4D 6'BED. AT HIGHWAY SPEEDS I NOTICED A VIBRATION IN THE WHIKE TRUCK. MY BRAKE DRUMS AND ROTORS HAE BEEN REPLACED TIRES BALANCED BY TWO COMPANIES AND THE PROBLEM STILL EXIST. *TR
NHTSA ODI #10241838
62,000 miles · Nov 8, 2007
Suspension
TL*THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING 60 MPH ON THE HIGHWAY, THE FRONT DRIVER SIDE WHEEL BEGAN VIBRATING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER. THE VEHICLE HAS NOT BEEN DIAGNOSED. THE CURRENT AND FAILURE MILEAGES WERE 62,000.
NHTSA ODI #10208465
3,000 miles · Nov 2, 2007
Suspension
4. MY REAR END WAS CONSTANTLY BOTTOMING OUT AND AS A RESULT IT CREATED A PRETTY HARSH RIDE. WHAT EXACTLY DOES THAT MEAN? WELL, EVERY TIME I CARRIED A FULL LOAD OF PASSENGERS / TOWED OUR 19' BOAT, / OR HAULED MATERIAL IN THE BED IT WILL BOTTOM OUT. THE SLIGHTEST DIP OR SPEED BUMP EVEN AT 10MPH IS FELT. DO I FEEL IT WHEN I'M BY MY…
Read full complaint
4. MY REAR END WAS CONSTANTLY BOTTOMING OUT AND AS A RESULT IT CREATED A PRETTY HARSH RIDE. WHAT EXACTLY DOES THAT MEAN? WELL, EVERY TIME I CARRIED A FULL LOAD OF PASSENGERS / TOWED OUR 19' BOAT, / OR HAULED MATERIAL IN THE BED IT WILL BOTTOM OUT. THE SLIGHTEST DIP OR SPEED BUMP EVEN AT 10MPH IS FELT. DO I FEEL IT WHEN I'M BY MYSELF AND THE BED IS EMPTY, AND THERE ARE NO OTHER PASSENGERS? YES, BUT AT HIGHER SPEEDS. DO I EVER OFF-ROAD MY VEHICLE? NO. \ WELL, TYPICALLY IN THE PRE 35 THOUSAND MILES WHILE UNDER WARRANTY TOYOTAS PAPER WORK WOULD CONSTANTLY STATE THAT THEY WERE UNABLE TO DUPLICATE THE PROBLEM, THEREFORE THERE WAS NOTHING WRONG WITH IT. I CALLED TO MAKE AN APPOINTMENT THE SECOND TIME AND A GIRL ANSWERED AND I ASKED ABOUT MAKING AN APPOINTMENT AND I TOLD HER ABOUT THE ISSUE THAT I WAS HAVING, AND SHE RESPONDED, TELLING ME THAT MY TRUCK WAS BEYOND ITS WARRANTY PERIOD. OH, I HAVE 66, THOUSAND MILES ON IT AND PURCHASED IT IN JANUARY OF 06. ANYWAY, SHE GAVE ME AN 800 NUMBER TO SEE IF I WAS ELIGIBLE. WELL, A REQUEST WAS PUT IN FOR ONE OF THE MAIN MECHANICS TO TAKE A RIDE WITH ME TO WITNESS THE PROBLEM. A VERY SHORT RIDE LATER AFTER HAVING HIT A FEW SMALL DIPS AT 10, 20, AND 30 MILES PER HOUR WHEN HE BOTH HEARD AND FELT THE BOTTOMING OUT OF THE VEHICLE. HE SUGGESTED THAT WE GO BACK TO THE SERVICE CENTER. WE GOT BACK AND THE FIRST THING HE DID WAS LOOK UNDER THE BED AND HE POPPED UP AND STATED THAT THE SPRINGS WERE FLAT ON ONE SIDE AND OFF ON THE OTHER SIDE. WHY DIDN'T EVERYONE ELSE DO THE SAME BEFORE, NOW WHEN IT'S TO MY CONVENIENCE TO HAVE THE ISSUE ADDRESSED, I'M DENIED. I'M DENIED ABOUT AN ISSUE THAT'S BEEN THERE ALL ALONG. I WAS SIMPLY TOLD "SORRY, WE CAN'T DO ANYTHING FOR YOU. YOUR MILEAGE IS TOO FAR OVER THE WARRANTY. ". I'VE NEVER HEARD OF ANY OTHER 1/2 TON PICKUP NOT BEING ABLE TO CARRY A LOAD. THEY SHOULD JUST CALL THE TACOMA A CRUCK BECAUSE IT'S MORE CAR THAN TRUCK. *TR
NHTSA ODI #10207801
29,816 miles · Sep 7, 2007
Suspension
I OWN A 2006 TOYOTA TACOMA 4X4 DBL CAB LONG BED TRD SPORT ($30,867.00 + TAX!) AND HAVE ENJOYED IT FOR JUST OVER A YEAR NOW. IT HAS 29,816 MILES AND HAS HAD ALL SERVICE DONE AT TOYOTA DEALERSHIP. WHILE DRIVING ON A PAVED ROAD I WENT OVER A VERY SMALL BUMP, AND THE LEFT FRONT SIDE OF MY TRUCK DROPPED ABOUT 3" INCHES CAUSING TIRE …
Read full complaint
I OWN A 2006 TOYOTA TACOMA 4X4 DBL CAB LONG BED TRD SPORT ($30,867.00 + TAX!) AND HAVE ENJOYED IT FOR JUST OVER A YEAR NOW. IT HAS 29,816 MILES AND HAS HAD ALL SERVICE DONE AT TOYOTA DEALERSHIP. WHILE DRIVING ON A PAVED ROAD I WENT OVER A VERY SMALL BUMP, AND THE LEFT FRONT SIDE OF MY TRUCK DROPPED ABOUT 3" INCHES CAUSING TIRE TO RUB FENDER. I GOT OUT AND LOOKED UNDER THE DRIVER SIDE FRONT AND COULD SEE THAT THE COIL OVER SHOCK BROKE OFF NEAR THE BOTTOM. I TOOK PHOTOS AND BROUGHT BOTH THE PHOTOS AND TRUCK TO MY LOCAL DEALER. THE 2 SERVICE PEOPLE AT THE COUNTER BOTH SAID IT WOULD BE COVERED UNDER WARRANTY, BUT THEN THE SERVICE MANAGER TOLD THEM THAT I MUST HAVE HIT SOMETHING TO HAVE THIS HAPPEN. I TOLD THEM I DID NOT HIT ANYTHING AND IT WENT DOWN WHEN I WENT OVER A VERY SMALL BUMP IN THE ROAD. NOT A BIG BUMP! HE AGAIN SAID "NO" HE WOULD NOT WARRANTY IT. THIS TOTALLY DROPPED THE FRONT LEFT SIDE DOWN ONTO THE TIRE AND COULD EASILY HAVE CAUSED AN ACCIDENT. I HAVE CALLED THE TOYOTA CUSTOMER EXPERIENCE CENTER AND WAS ASSIGNED REF: 2007 0907 0986 I REALLY LIKE MY TACOMA, BUT IF TOYOTA CONTINUES TO TREAT ME LIKE THIS, I WILL HAVE TO BUY A DIFFERENT BRAND. I WILL ALSO TELL AS MANY OTHERS AS I CAN ABOUT MY TREATMENT AT THE DEALERSHIP! *JB CONTACT STATED I HAD TO BUY NEW COIL OVER SHOCKS AND REPLACED MYSELF. UPDATED 12/12/2007 UPDATED 12/12/07 *TR
NHTSA ODI #10202221
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Illustration